Model year record

2024 GMC Sierra Ev recalls & problems

The 2024 GMC Sierra Ev has 3 safety recalls and 6 owner complaints on file with NHTSA. The most-reported problem area is steering (1 complaint).

Recalls3safety recalls

Complaints6filed by owners

Crashes · fires0 · 1reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Seat beltsJan 16, 2025

Rear/other › Anchorage

Recall 25V0150005 vehicles

Problem: General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado EV and 2024-2025 GMC Sierra EV pickup trucks. The bolt that secures the rear center seat belt assembly to the seat structure may not have been properly tightened.
Risk: An improperly secured seat belt assembly may not restrain an occupant as intended, increasing the risk of injury in a crash.
Fix: GM will tighten the bolt that attaches the center seat belt assembly to the rear seat structure, free of charge. All affected vehicles are still in dealer inventory and, therefore, no owner letters will be mailed. Owners may contact GM customer service at 1-888-988-7267, or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242489901.

Components: Seat belts › Rear/other › Anchorage; Seats › Mid/rear assembly

Exterior lightingOct 10, 2024

Lighting control module

Recall 24V7550001,962 vehicles

Problem: General Motors, LLC (GM) is recalling certain 2024 GMC Sierra EV vehicles. The front turn signal lights and parking lights may be too similar in brightness, making it difficult to see the front turn signals when they are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Front turn signals that are difficult to see may not clearly indicate the driver's intentions to other road users, increasing the risk of a crash.
Fix: Dealers will replace the headlamp multipurpose LED driver (MLD) module, free of charge. Owner notification letters were mailed November 4, 2024. Owners may contact GMC customer service at 888-988-7267. GM's number for this recall is N242474560.

Electrical systemMay 9, 2024

Propulsion system

Recall 24V32000010 vehicles

Problem: General Motors, LLC (GM) is recalling certain 2024 Cadillac Lyriq, Chevrolet Blazer EV, Chevrolet Silverado EV, GMC Hummer EV SUV, and GMC Sierra EV vehicles. The electric motors in the rear drive units may have insufficiently insulated wires that can contact each other, resulting in a loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
Fix: Dealers will replace the rear drive unit, free of charge. Owner notification letters were mailed May 16, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; Hummer customer service at 1-800-732-5493; or GMC customer service at 1-800-462-8782. GM's number for this recall is N242447080.

Components: Electrical system › Propulsion system; Electrical system › Wiring

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Fires	Typical mileage*
Steering	1	0	—
Wheels	1	0	—
Unknown or other	1	0	—
Visibility/wiper	1	0	—
StructureBody	1	0	—
Power train	1	1	—
Fuel/propulsion system	1	1	—
Electrical system	1	1	—
Service brakes	1	0	—
Latches/locks/linkages	1	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Latches/locks/linkages
The contact owns a 2024 GMC Sierra EV. The contact stated that while operating the vehicle the front trunk had erroneously opened. During the failure the vehicle would not shift out of the park position and the warning message indicating that the door was unsecured had displayed. The contact indicated that the failure had occurred on multiple occasions and the battery was disconnected to reset the system and correct the failure. The cause of the failure was not determined. The manufacturer was notified of the failure. The local dealer was not yet contacted. The failure mileage was 15,000.
Jun 18, 2025 · 15,000 miles
Service brakes
After the latest update from the Dealer, the integrated trailer brake module no longer shows an output of how much power it's applying to the trailer brake system. It just stays blank. I can tell that the brakes actually are being applied, however not having indication of them being applied and how much pressure is applied is concerning.
May 8, 2026
Power trainFire
I was driving and noticed a very strong smell of an electrical fire. The truck popped up a High Voltage Battery warning and several warning lights came on. We stopped, restarted the truck and the lights came on again, the smell returned as soon as we started driving. We drove the truck to Cable Dahmer GMC in Kansas City, MO. Service advisor Kracinda asked us to exit the vehicle as quickly as possible as it needed to be moved away from the building ASAP. It was parked several blocks from the building in a col de sac away from all vehicles. The electrical fire smell was very strong. The manufacturer is now saying that a software update is all that is required.
May 2, 2026
Structure › Body
While on freeway going 75 mph, GMC installed soft tonneau cover came loose from forward anchor points and starting flapping loudly in wind and without quickly stopping would have flown off truck and hit surrounding vehicles.
Apr 5, 2025
Visibility/wiper
The truck bed cover is not secure, it fits in via a channel with no straps or other protections and so when driving on the highway, it flies off from the connection to the cab and you canât see behind you. It then smacks into the car until you can pull over. There is no protection against this.
Mar 14, 2025
Steering
MY HUD is not functioning it does not appear on windshield MY CRABWALK OPTION is not available in my infosystem
Sep 9, 2024

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.