Model year record

2000 GMC Sonoma recalls & problems

The 2000 GMC Sonoma has 4 safety recalls and 136 owner complaints on file with NHTSA. The most-reported problem area is structure (43 complaints).

Recalls4safety recalls

Complaints136filed by owners

Crashes · fires15 · 0reported in complaints

Injuries · deaths9 · 1reported in complaints

Safety recalls

Fuel system, otherMar 12, 2007

Storage › Tank assembly › Pressure relief devices

Recall 07E021000742 vehicles

Problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

EquipmentSep 8, 2000

Other › Labels

Recall 00V258001223,194 vehicles

Problem: VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH INCORRECT PAYLOAD INFORMATION ON THE VEHICLE CERTIFICATION LABEL. THE PAYLOAD SHOWN ON THE LABEL IS GREATER THAN THE MAXIMUM VALIDATED PAYLOAD. IF THE VEHICLE WERE LOADED TO THE INCORRECTLY LABELED PAYLOAD, IT MAY NOT RIDE AND HANDLE IN THE MANNER THAT THE DRIVER EXPECTS.
Risk: THIS COULD RESULT IN A LOSS OF CONTROL OF THE VEHICLE OR AN INABILITY TO STOP THE VEHICLE WITHIN EXPECTED STOPPING DISTANCES.
Fix: OWNERS WILL BE SENT A NEW LABEL FOR INSTALLATION ON THE DRIVER'S DOOR OF THE VEHICLE.

Service brakes, hydraulicFeb 28, 2000

Antilock/traction control/electronic limited slip

Recall 00V05500010,674 vehicles

Problem: VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4-WHEEL DISC BRAKES. SOME OF THESE VEHICLES HAVE AN ANTILOCK BRAKE SYSTEM (ABS) MOTOR CONTAINING AN OUT-OF-SPECIFICATION SPRING CLIP. THIS CLIP COULD ALLOW THE MOTOR BEARING TO BECOME MISALIGNED. IF MISALIGNMENT OCCURS, EVENTUALLY THE ABS WOULD BE NON-FUNCTIONAL.
Risk: THE BASE BRAKES WOULD REMAIN FULLY FUNCTIONAL, BUT THE DYNAMIC REAR PROPORTIONING (DRP) SYSTEM, WHICH OPTIMIZES FRONT TO REAR BRAKE BALANCE, WOULD BECOME INOPERATIVE.
Fix: DEALERS WILL REPLACE THE BRAKE PRESSURE MODULE VALVE ASSEMBLY.

Service brakes, hydraulicAug 11, 1999

Antilock/traction control/electronic limited slip

Recall 99V2200003,947 vehicles

Problem: VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Risk: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Fix: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2000 GMC Sonoma

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

2000 GMC Sonoma Extended Cab

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Sonoma 2WD

23mpg combined

City / highway	20 / 26 mpg
Fuel	Regular Gasoline

2.2 L · 4 cyl · Manual 5-spd · Rear-Wheel Drive · about $2,900/year to fuel

Sonoma 2WD

22mpg combined

City / highway	19 / 25 mpg
Fuel	Regular Gasoline

2.2 L · 4 cyl · Manual 5-spd · Rear-Wheel Drive · about $3,050/year to fuel

Sonoma 2WD

19mpg combined

City / highway	17 / 24 mpg
Fuel	Regular Gasoline

2.2 L · 4 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,550/year to fuel

Sonoma 2WD

19mpg combined

City / highway	17 / 23 mpg
Fuel	Regular Gasoline

2.2 L · 4 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,550/year to fuel

Sonoma 2WD

18mpg combined

City / highway	16 / 21 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Manual 5-spd · Rear-Wheel Drive · about $3,700/year to fuel

Sonoma 2WD

17mpg combined

City / highway	15 / 20 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,950/year to fuel

Sonoma 4WD

17mpg combined

City / highway	15 / 20 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Manual 5-spd · 4-Wheel or All-Wheel Drive · about $3,950/year to fuel

Sonoma 4WD

16mpg combined

City / highway	14 / 19 mpg
Fuel	Regular Gasoline

4.3 L · 6 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $4,200/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
StructureBody › Tailgate › Hinge and attachments; Body › Door	43	0	2	60,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Master cylinder	35	8	3	50,000 mi
Latches/locks/linkagesDoors › Latch; Tailgate › Latch	13	0	0	41,700 mi
Air bagsFrontal; Side/window	11	8	3	—
SeatsFront assembly › Recliner	11	0	1	15,012 mi
Power trainAutomatic transmission; Driveline › Differential unit	9	0	0	—
SuspensionFront; Front › Control arm	9	0	0	55,000 mi
Engine and engine coolingEngine › Gasoline; Engine	7	0	0	—
VisibilityDefroster/defogger/hvac system; Windshield wiper/washer	5	1	0	—
EquipmentElectrical › Radio/tape deck/cd etc.; Other › Labels	5	0	0	92,000 mi
Fuel system, gasolineDelivery › Fuel pump	5	0	0	70,700 mi
TiresTemporary/emergency spare tire; Sidewall	4	0	0	85,000 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Service brakes
I HAD A NEAR DEATH ACCIDENTS (TWICE) DUE TO CATASTROPHIC BRAKE LINE FAILURE FROM SEVERELY RUSTED BRAKE LINES THE FRONT LEFT AND THE INTERMEDIATE LINE FROM FRONT TO REAR SECTION ON TOP OF FRAME RAIL. FIRST INCIDENT WAS AT SPEED OF 45 MPH ON HIGHWAY WITH HARD STOP REQUIRED TO AVOID STOPPED TRAFFIC AHEAD. SECOND FAILURE WAS MORE INSIDIOUS WITH PROGRESSIVE BRAKE LINE RUST THROUGH/ LEAK SPOT TO REAR BRAKE LINES WITH FIN THROUGH AND FAILURE. THIS IS NOT COMPLICATED ... SIMPLY SUBSTANDARD MATERIALS FOR ONE OF THE MOST CRITICAL COMPONENTS IN A VEHICLE. IT SHOULD NOT MATTER WHAT CONDITIONS ARE (IE SALT, COLD, ETC; DESIGN AND MATERIALS SHOULD BE MANDATED FOR BRAKE LINES NOT TO RUST THROUGH. THERE ARE…
Jun 2, 2020 · 102,000 miles
Service brakes
FOR THE THIRD TIME MY BRAKE LINE BROKE AND LOST ALL BRAKES IN MOTION LUCK FOR ME AND MY WIFE WE WERE ABLE TO PULL OFF THE ROAD GOING TO HAVE IT TOWED TO A SHOP FOR REPAIR AGAIN WHAT IS GOING ON WITH GMC QUALITY AND SAFETY.
Apr 13, 2017 · 101,000 miles
Tires › Sidewall
TL* THE CONTACT OWNS A 2000 GMC SONOMA EQUIPPED WITH COOPER COBRA RADIAL G/T TIRES, SIZE: P255/60R15 (NA). WHILE INDEPENDENTLY PERFORMING ROUTINE SERVICE ON THE VEHICLE, THE CONTACT NOTICED THAT ALL THE TIRES DEVELOPED CRACKS ON THE INNER PART OF THEIR RESPECTIVE SIDEWALLS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT ALL FOUR TIRES NEEDED TO BE REPLACED. THE TRIES WERE NOT REPLACED. THE TIRE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS 27,000 AND THE VEHICLE FAILURE MILEAGE WAS 117,366.
Jul 9, 2016 · 117,366 miles
Engine
THE TRUCKS BEEN HANDLING FINE AND ALL OF THE SUDDEN THE OIL PAN BLOWS OUT ON THE TRUCK AND I THINK IT THREW A ROD. WHICH IS NOT MY FAULT A PIECE CAME APART OR CAME OUT OF THE ENGINE CAUSING ALL THAT PRESSURE TO BUILD UP AND MESS IT UP. THE VEHICLE WAS IN MOTION NOT GOING OVER 60
Feb 3, 2016
Unknown or other
THE SPARE TIRE FELL OFF MY GMC SONOMA WHILE I WAS DRIVING IT. THE CABLE IN THE SPARE TIRE HOIST RUSTED INTO.
Apr 2, 2012
Structure › Body › Door
TL* THE CONTACT OWNS A 2000 GMC SONOMA. THE CONTACT STATED THAT THE DRIVER SIDE DOOR WAS LOOSE AND FAILED TO CLOSE COMPLETELY. AN INDEPENDENT MECHANIC PLACED A PIN ON THE BUSHING AND NOTICED THAT THE FRAME WAS COMPLETELY RUSTED UNDERNEATH THE CAB. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.
Aug 4, 2014 · 104,000 miles
Service brakes
BRAKE LINE FAILURE ON THREE DIFFERENT DATES 2/12/2012. 9/18/2013. 3/6/14 STILL DRIVING THE TRUCK SHOULD I BE WORRIED. UPDATED 3/18/2015 *JS
Feb 24, 2012 · 90,711 miles
Air bagsCrash1 injury
OUR SON WAS INVOLVED IN A ACCIDENT ON 09/15/2013 WHERE HE WAS TRAVELING NORTH BOUND ON SOLDIERS HOME ROAD IN MORAINE OHIO. HIS TRUCK WENT OF THE RIGHT SIDE OF THE ROAD, WHEN IT DID HE ACCIDENTALLY HIT THE GAS AND NOT THE BRAKE. TRUCK THEN HIT AN ELECTRIC POLE AS IT PICKED UP SPEED BROKE A TIE ROD IN HALF. HE THEN LOST CONTROL AS IT FLEW ACROSS THE STREET STILL INCREASING SPEED. AT THAT TIME HE HIT 2 TREES AND A FIRE HYDRANT, THEN THE TRUCK SPUN AND THE REAR WRAPPED AROUND ANOTHER TREE. THE AIRBAGS DID NOT DEPLOY EITHER DRIVER OR PASSENGER SIDE. HE WAS KILLED ON IMPACT AND THE PASSENGER DID SURVIVE. *TR
Sep 15, 2013 · 140,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

ENGINE STALL DUE TO FUEL STARVATIONClosed
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE…
PE02066 · opened Sep 6, 2002 · closed Nov 3, 2003