Model year record
2007 Harley-Davidson Flhtcu recalls & problems
The 2007 Harley-Davidson Flhtcu has no safety recalls on file with NHTSA, and 48 owner complaints. The most-reported problem area is engine and engine cooling (29 complaints).
Safety recalls
No safety recalls have been filed for the 2007 Harley-Davidson Flhtcu.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Engine and engine coolingExhaust system › Manifold/header/muffler/tail pipe; Exhaust system | 29 | 200 mi |
| Power trainManual transmission; Clutch assembly | 13 | 200 mi |
| Vehicle speed controlCruise control | 4 | 5,195 mi |
| Service brakes, hydraulic | 3 | 22,441 mi |
| StructureBody; Frame and members | 2 | — |
| Engine | 2 | — |
| Electrical systemWiring › Fuses and circuit breakers | 1 | — |
| VisibilityDefroster/defogger/hvac system › Heater core | 1 | — |
| Fuel system, gasoline | 1 | — |
| Tires | 1 | — |
| Unknown or other | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Unknown or otherCrash1 injury
I was on my 2007 Harley Ultra Classic, going a little over speed limit, but my feet were on the highway pegs away from rear brake. I was in 6th gear as I had a few miles to my destination, the rear wheel locked up causing a straight slide at first the went into a fish tailing state before I completely lost control and crashed causing me to hit the ground with some injuries and a total loss of my bike.
- Engine
TL* THE CONTACT OWNS A 2007 HARLEY-DAVIDSON TRI GLIDE FLTR. WHILE DRIVING VARIOUS SPEEDS, THE DRIVE BELT MALFUNCTIONED AND BECAME MISALIGNED. IN ADDITION, THE BEARINGS THAT HELD THE PIVOT SHAFT TOGETHER EXHIBITED PREMATURE EXCESSIVE WEAR. AN UNKNOWN DEALER WAS CONTACTED ABOUT THE FAILURE. ANOTHER UNKNOWN DEALER INSPECTED THE VEHICLE AND DETERMINED THAT THE BEARINGS WERE FAULTY. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE BEARINGS CONTAINED FRAGMENTS OF RUBBER AND METAL. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 9,000.
- Tires
MICHELIN COMMANDER 11 TIRE, SIZE 149-90-B16REAR, SEPARATED, 8" SECTION OF CAP TREAD CAME OFF TIRE. TIRE IS 14 MONTHS OLD AND HAS 8252 MILES ON IT. *TR
- Engine
TL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FLHTCU MOTORCYCLE. WHILE DRIVING APPROXIMATELY 35 MPH, THE OIL PRESSURE WARNING LIGHT ILLUMINATED AS THE ENGINE BEGAN TO VIBRATE ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE SHIFTING FLY WHEEL WOULD HAVE TO BE REPLACED. THE SHIFTING FLY WHEEL ALSO CAUSED THE OIL PUMP TO BECOME FRACTURED. THE TECHNICIAN ALSO ADVISED THAT THERE WERE NO APPROVED FACTORY REMEDIES THAT WOULD REPAIR THE FAILURE. THE TECHNICIAN SUGGESTED THAT THE CONTACT TAKE THE VEHICLE TO AN INDEPENDENT MECHANIC SO THAT THE ENGINE COULD BE DISASSEMBLED, WELDED AND TRUDED. THE CONTACT STATED THAT HE WOULD NOT TAKE…
- Vehicle speed control
TL* THE CONTACT OWNS A 2008 HARLEY DAVISON FLHTCU MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE ELECTRONIC THROTTLE FAILED AND CAUSED THE VEHICLE TO BE INOPERABLE. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 17,000.
- Power train
ENGINE KNOCKS AND KICKS BACKS, ON STARTING AND WHEN ACCELERATING,HAS BEEN WORKED ON SEVERAL TIMES, BY HARLEY DAVIDSON DEALER. THE PROBLEM I'VE BEEN TOLD IS THE COMPENSATOR SPROCKET AND ASSEMBLY . THROUGH MANY FORUMS AND TALKS WITH OTHER HARLEY RIDERS THAT HAVE HAD THE SAME PROBLEMS, THE FIX TO THE PROBLEM ACCORDING TO PEOPLE WHO HAVE RESEARCHED THE COMPENSATOR IS FOR IT TO BE REPLACED WITH THE SCREAMING EAGLE COMPENSATOR PART #40274-08.IF THIS IS NOT RECALLED OR REPAIRED BY HARLEY IT CAN BE VERY EXPENSIVE FOR THE OWNER TO REPAIR APPROX. 600.00 DOLLARS BUT MORE IMPORTANT THE COMPENSATOR CAN COME APART POSSIBLY BUSTING THE PRIMARY CASE LETTING OIL TO SPILL ON TO ROAD AND TIRES WHICH COULD…
- Power train
TL* THE CONTACT OWNS A 2007 HARLEY DAVIDSON FLHTCU MOTORCYCLE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER AND THEY DIAGNOSED THAT A METAL PIECE WAS JAMMED IN THE CHAIN, BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 14,000.
- Service brakes, hydraulicCrash
FRONT BRAKE FAILURE. *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.