Model year record
The 2000 Harley-Davidson FLHTCUI has 1 safety recall and 13 owner complaints on file with NHTSA. The most-reported problem area is electrical system (10 complaints).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Electrical systemWiring › Fuses and circuit breakers; Ignition | 10 | 33,500 mi |
| Engine and engine coolingEngine | 3 | — |
| Exterior lightingHazard flashing warning lights | 2 | — |
| SuspensionRear | 1 | — |
| EquipmentElectrical | 1 | — |
| Power train | 1 | — |
| Fuel system, gasolineDelivery › Fuel pump | 1 | — |
| StructureBody | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
TL* THE CONTACT OWNS A 2000 HARLEY DAVIDSON FLHTCUI. WHILE DRIVING 80 MPH ON THE HIGHWAY, THE BIKE STARTED WOBBLING AND SHAKING. THE CONTACT PULLED OVER THINKING THERE WAS A FLAT TIRE, BUT DID NOT NOTICE ANY DAMAGES. ONCE THE CONTACT ARRIVED HOME, THE BIKE BELT DRIVE WAS DAMAGED AND THE SWING ARM WAS FRACTURED. THE BIKE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000.
UNEXPECTED COMPLETE SHUT-DOWN OF ENGINE AND ELECTRICAL SYSTEM. USUALLY HAPPENS AT SLOW SPEEDS, IN FIRST, SECOND, OR THIRD GEAR. HAS BEEN HAPPENING MORE OFTEN. ONCE A MONTH THEN ONCE A WEEK, NOW ALMOST EVERY DAY. HAVE REPLACED FORK KEYED LOCK ELECTRICAL SWITCH ONCE IN PAST YEAR. HAVE ALSO BEEN EXPERIENCING MOMENTARY ENGINE HESITATIONS AS IF IGNITION WERE INTERRUPTED FOR A MOMENT. HAPPENS ALL THE TIME BUT NOT AT ANY REGULAR INTERVALS. *TR
ALTERNATOR ON 2000 MODEL HARLEY DAVIDSON ULTRA CLASSIC MOTORCYCLES WERE KNOWINGLY INSTALLED (SEE HARLEY DAVIDSON SERVICE BULLETIN M-1111 DATED FBE.16,2001)ON THIS YEAR MOTORCYCLE WITH A MISMATCHED STATOR/ROTOR COMBINATION. IN DOING SO THE STATOR BEING UNDERSIZED FAILS UNDER NORMAL DRIVING CONDITIONS. MINE FAILED ON ME. I , SINCE HAVE FOUND OUT THAT THIS WAS A KNOWN PROBLEM TO HARLEY DAVIDSON AND THEY DID NOT PERFORM A RECALL TO CORRECT THIS DANGEROUS SITUATION. ALL PERSONS OWNING THIS YEAR MOTORCYCLE HAVE HAD TO REPLACE THESE STATORS AT THEIR OWN EXPENSE. A VERY EXPENSIVE LABOR EXPENSE FOR THE OWNERS OF THESE MOTORCYCLES. TO MAKE THE SITUATION EVEN MORE DANGEROUS TO OPERATORS OF THESE…
2000 HARLEY-DAVIDSON FLHTCUI (ELECTRA GLIDE ULTRA CLASSIC) CAM CHAIN TENSIONER FAILED AT 37,400 MILES. LARGE CHUNK OF MATERIAL BLOCKED OIL FLOW. *TR
WHILE DRIVING 65 M.P.H. ON HIGHWAY WITH PASSENGER, EXPERIENCED COMPLETE ELECTRICAL SYSTEM SHUTDOWN, RESULTING IN A DANGEROUS EMERGENCY STOP IN RURAL AREA. REPAIRING DEALER INFORMED ME THAT THE STATOR HAD BURNED UP, AND NEEDED TO BE REPLACED WITH A NEW HEAVY-DUTY DESIGN. AN H-D SERVICE BULLETIN STIPULATED WARRANTY REPLACEMENT ONLY IF STATOR FAILED WITHIN FIRST 12,000 MILES, EVEN THOUGH STATOR FAILURE IS KNOWN TO BE A WIDESPREAD PROBLEM. MY MOTORCYCLE HAD LESS THAN 16,000 MILES WHEN FAILURE OCCURRED. THESE FAULTY STATORS SHOULD BE REPLACED AT NO CHARGE DUE TO THE POSSIBILITY OF SERIOUS INJURY OR DEATH IN A FAILURE AT HIGH SPEED. *NM
THE PROBLEM INDICATED IN THE CIRCUIT BREAKER RECALL 04V134000 OCCURRED WHILE DRIVING AT 75 MPH OVER A BRIDGE ON THE FREEWAY. THE MOTORCYCLE REGAINED POWER WITHIN 45 SECONDS, BUT THIS ALMOST RESULTED IN AN ACCIDENT. MOTORCYCLE WAS TAKEN TO A DEALERSHIP, BUT THEY DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE RECURRED WITHIN 6,000 MILES. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
YOUR CAMPAIGN NUMBER 04V134000 INCLUDES MODEL YEAR 2001-2003 H-D MOTORCYCLES. I HAVE A MODEL YEAR 2000 H-D MOTORCYCLE WITH THE EXACT SAME ELECTRICAL PROBLEM. THE PROBLEM HAS OCCURRED APPROXIMATELY 10 TIMES SINCE I HAVE HAD THE MOTORCYCLE. (THE INCIDENT DATE IS THE LAST TIME THE PROBLEM OCCURRED) *LA
COMPLETE ELECTRICAL SYSTEM SHUTDOWN LIKELY CAUSED BY SAME PROBLEM AS ADDRESSED IN NHTSA RECALL CAMPAIGN 04V134000. THE MAIN CIRCUIT BREAKER OPENS WITHOUT WARNING AND CAUSES A COMPLETE FAILURE OF ALL SYSTEMS. THIS AFFECTED MY 2000 FLHTCUI AND POSES AN EXTREMELY DANGEROUS SITUATION WHERE ALL SYSTEMS, INCLUDING LIGHTS FAIL. THIS COULD EASILY RESULT IN A FATAL ACCIDENT IF IT OCCURS IN A HIGH TRAFFIC CONDITION.*AK
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.