*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Engine
TL* THE CONTACT OWNS A 2008 HARLEY-DAVIDSON ROAD GLIDE (FLTR). WHILE RIDING AT VARIOUS SPEEDS, THE THROTTLE BODY SENSOR FAILED. AS A RESULT, THE VEHICLE STALLED AND LOST POWER WITHOUT WARNING. THE CONTACTED PULLED OVER, RESTARTED THE VEHICLE, AND RESUMED NORMAL RIDING. WHEN THE FAILURE RECURRED, THE CONTACT TOWED THE VEHICLE TO BAER SPORT CENTER HARLEY-DAVIDSON AND POLARIS (330 GRANDVIEW AVE, HONESDALE, PA 18431, (570) 253-2000) WHERE THEY REPLACED THE PLUGS ON THE THROTTLE BODY. THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO OTHER UNKNOWN HARLEY-DAVIDSON DEALERS TO HAVE THE VEHICLE SERVICED, BUT THE FAILURE PERSISTED EACH TIME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND…
Jul 4, 2018Service brakes
WHILE RIDING ON 3/31/2018 I WAS APPROACHING A STOPLIGHT AND BEGAN MY DOWN SHIFTING AND BRAKING. I STEPPED ON THE REAR BRAKE PEDAL AND TO MY SURPRISE THERE WAS LITTLE RESISTANCE, I PUMPED THE PEDAL AGAIN ONLY TO HAVE THE SAME RESULT. I THEN PUMPED THE PEDAL SEVERAL TIMES NOTING SAME RESULT AS PREVIOUS ATTEMPTS BUT WAS ABLE TO STOP USING MY FRONT BRAKE. WE PULLED OFF INTO A GAS STATION PARKING LOT TO ASSESS THE PROBLEM. UPON INSPECTION, I FOUND ONE OF TWO WIRES (RED) ON THE REAR BRAKELITE SWITCH SENSOR HAD MELTED OFF FROM THE SWITCH AN WAS LYING NEXT TO THE SWITCH SENSOR AND FLUID HAD LEAKED/SPRAYED OUT COVERING THE SURROUNDING AREA. LOOKING MORE CLOSELY, I FOUND THAT THE BRASS TERMINAL POST…
Mar 31, 2019 · 31,250 milesService brakes
TL* THE CONTACT OWNS A 2008 HARLEY-DAVIDSON FLTR. WHILE DRIVING 5-65 MPH, THE REAR BRAKES SEIZED SEVERAL TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER (FORT WORTH HARLEY-DAVIDSON, 3025 W LOOP 820 S, FORT WORTH, TX 76116, (817) 717-4325) FOR DIAGNOSTIC TESTING AND REPAIR. MONTHS LATER, THE CONTACT WAS NOTIFIED OF NHTSA CAMPAIGN NUMBER: 18V076000 (ELECTRONIC STABILITY CONTROL) BY EMAIL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT CALLED TO DETERMINE THE RECALL SOLUTION TO REPAIR THE MOTORCYCLE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. *TT *TR
May 15, 2017 · 50,000 milesService brakes
FRONT BRAKES FAILED DUE TO BAD ABS MODULE WITH NO WARNING. VERY HARD TO PULL IN WHEN TRYING TO STOP. WORKED FINE AND NOW NOTHING. THIS COULD HAVE RESULTED IN MYSELF WRECKING (REAR ENDING) SOMEONE IF IT HAPPENED A BUSY ROAD.
Nov 30, 2017 · 66,000 milesService brakes
TL* THE CONTACT OWNS A 2008 HARLEY-DAVIDSON FLTR ROAD GLIDE. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE BRAKES FAILED TO STOP THE VEHICLE. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE TO STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ASSISTANCE. THE FAILURE MILEAGE WAS 50.
May 15, 2016 · 50 milesService brakes
FRONT BRAKE ABS SYSTEM HCU FAILURE RESULTING IN LOSS OF FRONT BRAKE FUNCTION
Dec 17, 2016 · 12,797 milesService brakesCrash1 injury
TL* THE CONTACT OWNED A 2008 HARLEY-DAVIDSON FLTR ROAD GLIDE. WHILEDRIVING APPROXIMATELY10 MPH, THE BRAKE PEDALWAS DEPRESSED,BUT THE VEHICLE FAILED TO RESPOND WITHOUT WARNING. AS A RESULT,THE CONTACT SIDESWIPED ANOTHER VEHICLE AND CRASHED INTO AN ALUMINUM BRIDGE.A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE LEFT ARM, LEFT FOREARM, LEFT KNEE, AND ANKLES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 36,000.
Jul 22, 2016 · 36,000 milesService brakes
THE ABS MODULE ON MY BIKE HAS QUIT WORKING. WITH THE IGNITION ON THE MODULE CLOSES AND THE FRONT BRAKES CANNOT BE APPLIED. IF THIS WERE TO HAPPEN WHILE RIDING, A CRASH WOULD BE INEVITABLE. THE MODULE SHOULD BE DESIGNED SO THAT THERE IS AN EMERGENCY BYPASS IN THE EVENT THE INTERNALS INSIDE THE MODULE BECOMES STUCK SO THAT THE RIDER IS NOT SUDDENLY WITHOUT BRAKES. HARLEY DAVIDSON SHOULD ISSUE AN IMMEDIATE RECALL.
Apr 15, 2016 · 27,000 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.