*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Power train
THIS IS THE THIRD TIME MY BIKE HAS BEEN IN THE SHOP SINCE AUGUST 2019. ON MAY 8, 2019, IT HAS BEEN BACK IN THE SHOP FOR SIX WEEK. THE FIRST TIME IT BROKE DOWN IN WAS IN THE SHOP FOR 6 WEEKS. I'M BEING TOLD THE OUTPUT SHAFT IS BEING REDESIGNED. WHEN YOU'RE GOING THOUGHT THE GEARS THE OUTPUT SHAFT BREAKS. YOU DON'T EVEN GET THOUGH THE 6 GEARS. THEN BIKE LOSES ALL POWER TRAIN ONCE THE OUTPUT SHALL. THIS IS VERY DANGEROUS WHEN YOU ARE IN TRAFFIC. YOU HAVE TO FIND A SAFE PLACE TO COAST TO THE SIDE OF THE ROAD. THIS IS THE THIRD TIME IT'S BEEN IN THE FOR THE SAME THING. FIRST TIME AUGUST 27, 2018. SECOND TIME OCTOBER 24, 2018. TOOK MY BIKE IN FOR THEM TO CHECK THE OUTPUT SHAFT AND BOLT. THIRD…
Mar 27, 2019 · 3,000 milesFuel/propulsion systemCrash1 injury
FIRST ACCIDENT WAS AT A TRAFFIC LIGHT INTERSECTION, WITH LOW FUEL, BUT NO FUEL LIGHT YET. ACCELERATING ON SLIGHT UPHILL LEFT TURN, FROM STOP AT LIGHT. WENT FROM 1ST TO 2ND, WAS LEAVING THE CURVE WHEN I HIT A POT HOLE. THE BIKE LAGGED SLIGHTLY, THEN ACCELERATED SUDDENLY I WAS UNABLE TO AVOID HITTING THE CURB AND CRASHED. BEING A NEW RIDER I ASSUMED THAT THE POT HOLE HAD CAUSED ME TO ROLL ON THE THROTTLE, WHICH IS VERY RESPONSIVE, AND PUT THIS INCIDENT DOWN TO RIDER ERROR. IT WAS A SANCTIONED CLUB RIDE, SO REPORTS WERE FILED WITH THE DEALERSHIP. THE BIKE SPENT ABOUT 4 MONTHS AT HARLEY DAVIDSON OF BALTIMORE SERVICE DEPARTMENT, FOR WHAT WAS MOSTLY COSMETIC DAMAGE, AND I WAS PAYING CASH FOR…
Apr 24, 2016 · 50 milesUnknown or other
I BROUGHT MY XG500 TO A HARLEY DAVIDSON DEALER TO FIX A RECALL ON THE FUEL PUMP. AFTER AN ESTIMATED 100 MILES, THE BIKE SUDDENLY LOST ALL POWER TO THE BACK WHEEL WHILE I WAS DRIVING ON THE HIGHWAY AT ABOUT 65MPH. THE THROTTLE WOULD REV UP THE ENGINE, BUT IT WASN'T MAKING ME MOVE. THIS PUT ME IN A VERY UNSAFE PREDICAMENT AND I HAD TO ROLL ACROSS LANES OF TRAFFIC WHILE DECELERATING.
Sep 25, 2015 · 8,700 milesVehicle speed control
JULY 3, 2015 - IT STALLED TWICE WHILE SITTING COMPLETELY STOPPED AT STOP SIGNS WITH THE CLUTCH FULLY PULLED IN. IT IDLED LOW AND THEN COMPLETELY DIED. RESTARTING THE BIKE, I WAS ABLE TO GET IT MOVING WITH QUITE A BIT OF LEAPING AND LAGGING AND THE ENGINE SPUTTERING. ONCE UP AND THROUGH 1ST AND 2ND GEAR (SPUTTERING LIKE IF WAS MISSING FUEL) IT SEEMED TO SUDDENLY ENGAGE AND WAS OK. I COMPENSATED FOR THE LAGGING, BUT IT KEPT JUMPING AS IF SUDDENLY CATCHING WITHOUT PRESSURE ON THE THROTTLE INCREASING. IT DID THIS MOSTLY AT LOWER SPEEDS AT FIRST, BUT ALSO LEAPS WHEN AT HIGHER SPEEDS (45-55MPH) ON RURAL ROADS - AGAIN, JUMPING INTO THE HIGHER SPEED SUDDENLY AND WITHOUT AN INCREASE ON THE THROTTLE.…
Jul 3, 2015 · 32 milesFuel/propulsion system
I PREVIOUSLY FILED A REPORT ABOUT MY MOTORCYCLE STALLING AND SURGING ON 4/18 WHICH RESULTED IN A CRASH IN WET WEATHER. MY LOCAL DEALERSHIP BROUGHT MY BIKE IN AND HAD IT FOR A WEEK WHILE WAITING FOR A NEW FUEL PUMP. I AM ON MY SECOND FUEL PUMP. THE EXACT SAME SYMPTOMS AS BEFORE BUT A COMPLETELY NEW FUEL PUMP. I WAS ALMOST HIT WHILE TAKING OFF SLOWLY FROM A LIGHT WHEN THE BIKE SURGED AND THE CAR BEHIND ME EXPECTED ME TO CONTINUE MOVING THROUGH THE INTERSECTION. THIS IS MY ONLY VEHICLE AND I AM FINANCIALLY TIED INTO IT AND IT IS UNSAFE TO RIDE. MY FUEL LIGHT DOES NOT COME ON AND IT ACTS AS IF THERE IS NO FUEL. IT HAS A 3.3 GALLON TANK AND I HAVE NEVER BEEN ABLE TO PUT MORE THAN 2.5 GALLONS IN…
Jun 24, 2015 · 2,450 milesFuel/propulsion system
LIKE MANY OTHERS, SINCE DAY 1 MY HARLEY STREET 500 HAS BEEN EXPERIENCING A "LAG AND LEAP" ISSUE. THE FIRST DAY I HAD MY BIKE I EXPERIENCED AN ISSUE WHERE WHEN STARTING FROM A STOP, OR MAKING A TURN AT LOW SPEEDS, THE BIKE WOULD STALL LIKE IT WAS OUT OF GAS, AND THEN SUDDENLY ACCELERATE AGAIN, ALMOST THROWING ME OFF THE BACK OF THE BIKE. I BROUGHT MY BIKE TO THE DEALER, THEY TOLD ME I WAS LOW ON GAS, FILLED ME UP AND SENT ME ALONG MY WAY. HOWEVER, THE ISSUE HAS CONTINUED TO HAPPEN EVERY SINGLE TIME (IT IS 100% REPRODUCIBLE) THE BIKE TRAVELS FOR ROUGHLY 100 MILES AFTER FILLING (3.5 GALLON TANK WITH ADVERTISED ~60MPG). WHEN I FILL UP (THE ONLY REMEDY TO THE ISSUE), I CAN USUALLY NEVER GET MORE…
Jun 18, 2015Fuel/propulsion systemCrash
MOTORCYCLE WILL BOG DOWN AND THEN SURGE WITHOUT WARNING IF THERE IS ABOUT 1/3 OF A TANK LEFT. LOW FUEL INDICATOR NEVER COMES ON BEFORE IT HAPPENS AND IT'S WORSE WHEN DRIVING ON HILLS OR WHILE BANKING IN TURNS. LAST NIGHT WAS THE THIRD TIME THIS HAS HAPPENED TO ME AS I WAS COMING UP THE HILL AND TURNING IN TO MY DRIVEWAY THE MOTORCYCLE BOGGED DOWN, AND BEFORE I COULD COMPLETELY ROLL OFF THE THROTTLE IT ACCELERATED AND PUSHED THE REAR WHEEL OUT CAUSING ME TO LAY MY BIKE DOWN. *TR
Apr 17, 2015 · 145 milesVehicle speed controlCrash1 injury
VEHICLE LURCHES FORWARD UNCONTROLLABLY. THROTTLE RESPONSE IS EXTREMELY ERRATIC. THIS CAUSED INEXPERIENCED RIDER TO LOSE CONTROL AT A LOW SPEED AND WAS THROWN FROM VEHICLE AS IT WENT OUT OF CONTROL ONTO THE SIDEWALK. FUEL TANK WAS NEARLY FULL. CONTINUED RIDING EXHIBITED EXTREMELY ERRATIC THROTTLE CONTROL. VEHICLE IS VERY UNPREDICTABLE. *TR
Oct 18, 2014 · 94 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.