2005 Honda Element recalls & problems

Recent owner complaints

• Aug 31, 2026Air bags
  On 8.31.26, while driving my 2005 Honda Element Mileage: Approximately 125,000), the front passenger-side airbag spontaneously deployed without warning.There was absolutely no vehicle collision, physical impact, pothole, undercarriage strike, or jarring event to trigger a deployment. Approximately 10 hours prior to the spontaneous deployment, the airbag warning light illuminated on the instrument cluster and remained solid, indicating an active system fault. The car then sat parked for about 8 hours, before driving again. The light remained on.The uncommanded deployment filled the cabin with a smell and gases while the vehicle was in motion between towns. A VIN lookup shows no currently…
• Jul 11, 2026Suspension
  Left rear trailing arm mount has rusted and trailing arm is not intact.
• Mar 2, 2026Tires › Markings
  "Reporting a Material Compound Failure on a set of 4 Falken Wildpeak AT Trails tires (size 215/70/16) sold as 'new' but manufactured in 2021 (DOT 3921). Despite 8/32" tread remaining (75% life), from there original 10/32'' tread the rubber is failing with severe dry rot/cracking through the sidewall and markings on all 4 tireson the outside,and inside of the tire walls. This is a safety hazard involving undisclosed 'New Old Stock' this is premature failure ,and was confirmed by Mavis Tire,and Brake center inspection that is also a Falken authorized dealer.
• Jul 27, 2025 · 124,000 milesSuspension
  The contact owns a 2005 Honda Element. The contact stated that while at a complete stop, the vehicle began to tilt sideways while depressing the accelerator pedal. The vehicle became inoperable. There was no warning light illuminated. The contact pulled off to the shoulder of the roadway. Upon inspection of the vehicle, the contact discovered that the rear driver’s side control arm had separated from the frame of the vehicle, causing the rear wheel to tuck in underneath the wheel hub. Due to the failure, the vehicle was towed to an independent mechanic where it remained undiagnosed. The dealer was contacted and stated that based on the pictures, the entire suspension needed to be…
• Jan 19, 2025Air bags
  Air bag in drivers seat deployed when I shut rear door. Car was running at the time.
• Aug 28, 2024 · 190,000 milesSuspension
  The contact owns a 2005 Honda Element. The contact stated while inspecting the vehicle, the contact noticed that the rear trailing arm mount was severely rusted. The vehicle was taken to an independent frame mechanic, where the contact was informed that the rear trailing arm mount could fracture. The vehicle was taken to the dealer, where the contact was informed that the VIN was not included in an unknown recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 190,000.
• Jan 31, 2024Suspension
  The left rear control arm pulled out of the subframe and floor panel and hit the pavement facing forward, the direction in which the car was moving. The left rear tire pulled out and away from the vehicle, and the car lurched downward. There were sparks. I was pulling away from a gas pump at a service station. I stopped the car immediately and had it towed to a mechanic. There was no warning. There were no unusual sounds or movements prior to the incident. Approximately 100 miles before the incident, a licensed mechanic did a safety inspection and test drove the vehicle prior to doing maintenance on other parts of the car. Two different mechanics inspected the vehicle and determined it was…
• Mar 19, 2024Structure › Body
  Rear unibody rust through allowing the drivers side rear trailing arm to become detached. Pulling up to stop sign very slowly luckily. At speed this failure would have assuredly led to a crash from loss of control. Calls have been placed to local Honda dealer as well as American Honda where I was informed there was no recall for this problem in the USA.

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• EA21002 · opened Sep 17, 2021 · openDesiccated Air Bag Inflator Rupture
  From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled…
• EA15001 · opened Feb 24, 2015 · open · led to recall 14V668Air Bag Inflator Rupture
  The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at ODI's insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included Florida, Puerto Rico,…
• PE14016 · opened Jun 11, 2014 · closed Mar 2, 2015 · led to recall 13V172000Air Bag Inflator Rupture
  The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at ODI's insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included Florida, Puerto Rico,…