The 2003 Honda ST1300 has 3 safety recalls and 9 owner complaints on file with NHTSA. The most-reported problem area is electrical system (6 complaints).
Recalls3safety recalls
Complaints9filed by owners
Crashes · fires0 · 0reported in complaints
Injuries · deaths1 · 0reported in complaints
Safety recalls
Service brakes, hydraulic
NHTSA recall 05V010000 · Jan 24, 2005 · 36,046 vehicles
Problem: CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
Risk: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.
Electrical system › Wiring
NHTSA recall 04V568000 · Dec 9, 2004 · 4,345 vehicles
Problem: ON CERTAIN MOTORCYCLES, THE MAIN WIRE HARNESS HAS A GROUND DISTRIBUTION CONNECTOR THAT IS INCORRECTLY ASSEMBLED. SOME ELECTRICAL CIRCUITS MAY OVERHEAT AND SHORT, INCLUDING THE FUEL PUMP.
Risk: IF THE FUEL PUMP STOPS WORKING, THE ENGINE WILL STALL WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
Fix: DEALERS WILL INSPECT THE GROUND DISTRIBUTION CONNECTOR FOR OVERHEATING DAMAGE. IF ANY DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED. IF NO DAMAGE IS FOUND, THE CONNECTORS WILL BE ASSEMBLED PROPERLY. THE RECALL BEGAN ON DECEMBER 8, 2004. OWNERS SHOULD CONTACT HONDA AT 866-784-1870.
Electrical system › Wiring
NHTSA recall 04V549000 · Nov 23, 2004 · 2,185 vehicles
Problem: ON CERTAIN MOTORCYCLES, THE ROUTING OF SOME WIRE HARNESSES MAY ALLOW A CONNECTOR TO CONTACT AND CHAFE AGAINST THE FUEL TANK.
Risk: EVENTUALLY THE CHAFING MAY CAUSE A SHORT CIRCUIT AND BLOW AN IGNITION SYSTEM FUSE. THE ENGINE WILL THEN STALL WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
Fix: DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR POSITION AND CHECK FOR DAMAGE. IF ANY DAMAGE IS FOUND, DEALERS WILL REPLACE THE NECESSARY PARTS. IF NO DAMAGE IS FOUND, DEALERS WILL REPOSITION THE CONNECTOR, AND MAKE SURE ADEQUATE CLEARANCE EXISTS. THE RECALL BEGAN ON DECEMBER 8, 2004. OWNERS SHOULD CONTACT HONDA AT 1-866-784-1870.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Electrical system Wiring
6
0
0
0
—
Engine and engine cooling Exhaust system
2
0
0
1
—
Service brakes, hydraulic
2
0
0
0
—
Suspension Front › Wheel bearing
1
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
May 31, 2006 · 21,400 milesSuspension › Front › Wheel bearing REAR WHEEL BEARING FAILURE: THE DRIVEN FLANGE BEARINGS WHICH TOGETHER MAKE UP THE RIGHT SIDE REAR WHEEL BEARING FAILED AT LOW MILEAGE. THESE TWO BEARINGS FAILED AT 21,000 MILES, AND WERE DISCOVERED AT A ROUTINE TIRE CHANGE. OTHERS HAVE REPORTED SIMILAR AND NEAR CATASTROPHIC BEARING FAILURES AT SIMILAR MILEAGES . SEE HTTP://GROUPS.MSN.COM/ST1300US AND WWW.ST-OWNERS.COM/FORUMS WHEEL BEARINGS CAN BE EXPECTED TO LAST FOR THE LIFE OF THE VEHICLE, BEARING UNUSUAL STRESSES. THESE BEARINGS WERE APPARENTLY SUB STANDARD IN QUALITY AND/OR DESIGN AND SHOULD BE EXAMINED AND REPLACED IMMEDIATELY. CONSEQUENCES OF WHEEL BEARING FAILURE COULD RANGE FROM SIMPLE DISABLEMENT TO SERIOUS CRASHES.*AK
Jun 10, 2005Electrical system › Wiring CONSUMER CONTACTED THE DEALER TO HAVE RECALLS REPAIRS PERFORMED ON HIS 2003 HONDA ST1300 AND WAS INSTRUCTED TO BRING IT BACK AT THE END OF THE SUMMER TO HAVE THE WORK PERFORMED BECAUSE THEY WERE BUSY. *MR RECALL CAMPAIGN#'S 04V549000 AND 05V010000. *SC *JB
Nov 8, 2004Electrical system › Wiring CONSUMER RECEIVED RECALL 04V549000 AND THREE CONSUMER SERVICE AWARENESS CAMPAIGNS. NO PARTS FOR THE RECALL WIRE HARNESS HAVE BEEN MADE AVAILABLE.*AK
Jun 1, 2004Electrical system › Wiring RECALL CAMPAIGN. 2003 HONDA ST 1300 MOTORCYCLE, STALLS ON THE INTERSTATE. *BF THE CONSUMER HAD BEEN TRYING TO GET HIS MOTORCYCLE REPAIRED EVER SINCE HE RECEIVED THE RECALL LETTER IN THE MAIL ON DEC 20,2004. THE CONSUMER WAS ALREADY HAVING PROBLEMS WITH THE MOTORCYCLE, BUT THE PROBLEM WAS SPORADIC. EVERYTIME THE CONSUMER CONTACTED THE DEALER, HE WAS TOLD THE PARTS WERE NOT IN UNTIL FINALLY ON FEB 7 2005, THE BIKE FINALLY STOPPED. RECALL#04V549000 *JB *SC
Nov 19, 2004Service brakes, hydraulic I WAS AT MY HONDA MOTORCYCLE DEALER TODAY FOR THE THIRD TIME. THE DEALER IS OCALA MOTOR SPORTS IN OCALA, FLORIDA. THEY STATED THAT PARTS ARE STILL UNAVAILABLE FOR THE FIRST RECALL ON MY MOTORCYCLE. THE DATE OF THE FIRST RECALL WAS NOV. 19, 2004. IT WAS NHTSA CAMPAIGN ID # 04V549000. THERE HAVE BEEN TWO SUBSEQUENT RECALLS SINCE THEN MAKING IT A TOTAL OF THREE RECALLS, THE LATTER TWO BEING 04V568000 & 05V010000. I THINK THAT THREE MONTHS IS A TOTALLY UNREASONABLE TIME FRAME TO EVEN RESPOND TO THE FIRST RECALL. WHEN YOU PAY OVER $13,000.00 FOR A MOTORCYCLE, YOU DON'T EXPECT IT TO BE PARKED FOR 3 MONTHS.
Sep 16, 2004 · 9,400 milesElectrical system › Wiring THERE ARE A GROUP OF WIRES THAT RUN UNDER THE SEAT LATCHING MECHANISM AND UNDER THE TOP GAS TANK THAT RUB AND FRAY. DUE TO THIS ISSUE BEING TALKED ABOUT ON THE ST 1300 CHAT ROOM I CHECKED MINE. THE INSULATION WAS STARTING TO FRAY FROM THE RUBBING ON THE LATCHING MECHANISM. IF THE WIRES WERE TO SHORT THE POWER COULD BE SHUT OFF TO THE BIKE CAUSING A CRASH AND INJURY OR DEATH.*AK
Aug 15, 2004 · 6,600 milesElectrical system › Wiring 2003 MODEL ST1300 MOTORCYCLE. ENGINE QUIT ABRUPTLY AT 75 MPH. IF VEHICLE WAS LEANED INTO TURN OR IN TIGHT PASSING SITUATION SUBSTANTIAL INJURY OR DEATH WOULD PROBABLY RESULT. A VISIT TO THE ST1300 POST YIELDED THE FACT THAT THIS IS A COMMON FAILURE DUE TO THE ROUTING OF A BLACK AND A WHITE WIRE IN PROXIMITY OF THE UNDERSEAT FUEL TANK WHICH ABRADES THRU THE INSULATION CAUSING A SHORT WHICH IN TURN CAUSES THE FUEL PUMP FUSE TO BLOW AND SHUTS DOWN THE MOTOR.*AK
Dec 3, 2003 · 4,000 miles · 1 injuryEngine and engine cooling › Exhaust system WHILE RIDING THE MOTORCYCLE THE SIDE VENT WAS BLOWING OUT 120 DEGREES OF HOT AIR. CONSUMER SUSTAINED A FIRST DEGREE BURN DUE TO THE HOT AIR. DEALERSHIP WAS NOTIFIED, BUT THE PROBLEM WAS NOT RESOLVED.*AK
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.