Model year record

2003 Honda ST1300A recalls & problems

The 2003 Honda ST1300A has 3 safety recalls and 5 owner complaints on file with NHTSA. The most-reported problem area is electrical system (3 complaints).

Recalls3safety recalls

Complaints5filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Service brakes, hydraulicJan 24, 2005

Service brakes, hydraulic

Recall 05V01000036,046 vehicles

Problem: CERTAIN MOTORCYCLES EQUIPPED WITH COMBINED-BRAKE SYSTEMS HAVE A PROPORTIONING CONTROL VALVE (PCV) THAT MECHANICALLY PROPORTIONS BRAKE FORCE WHEN THE REAR BRAKE IS APPLIED. A SEAL IN SOME PCVS IS IMPROPERLY SHAPED, AND BRAKE FLUID LEAKAGE MAY OCCUR.
Risk: IF THE MOTORCYCLE CONTINUES TO BE USED AFTER A LEAK OCCURS, THE REAR BRAKE WOULD EVENTUALLY BECOME INOPERATIVE. A LOSS OF REAR BRAKE FORCE COULD INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL INSPECT THE REAR BRAKE FORLEAKAGE. IF LEAKAGE IS CONFIRMED, THE DEALER WILL REPLACE THE PCV FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS MAY CONTACT HONDA AT 866-784-1870.

Electrical systemDec 9, 2004

Wiring

Recall 04V5680004,345 vehicles

Problem: ON CERTAIN MOTORCYCLES, THE MAIN WIRE HARNESS HAS A GROUND DISTRIBUTION CONNECTOR THAT IS INCORRECTLY ASSEMBLED. SOME ELECTRICAL CIRCUITS MAY OVERHEAT AND SHORT, INCLUDING THE FUEL PUMP.
Risk: IF THE FUEL PUMP STOPS WORKING, THE ENGINE WILL STALL WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
Fix: DEALERS WILL INSPECT THE GROUND DISTRIBUTION CONNECTOR FOR OVERHEATING DAMAGE. IF ANY DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED. IF NO DAMAGE IS FOUND, THE CONNECTORS WILL BE ASSEMBLED PROPERLY. THE RECALL BEGAN ON DECEMBER 8, 2004. OWNERS SHOULD CONTACT HONDA AT 866-784-1870.

Electrical systemNov 23, 2004

Wiring

Recall 04V5490002,185 vehicles

Problem: ON CERTAIN MOTORCYCLES, THE ROUTING OF SOME WIRE HARNESSES MAY ALLOW A CONNECTOR TO CONTACT AND CHAFE AGAINST THE FUEL TANK.
Risk: EVENTUALLY THE CHAFING MAY CAUSE A SHORT CIRCUIT AND BLOW AN IGNITION SYSTEM FUSE. THE ENGINE WILL THEN STALL WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
Fix: DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR POSITION AND CHECK FOR DAMAGE. IF ANY DAMAGE IS FOUND, DEALERS WILL REPLACE THE NECESSARY PARTS. IF NO DAMAGE IS FOUND, DEALERS WILL REPOSITION THE CONNECTOR, AND MAKE SURE ADEQUATE CLEARANCE EXISTS. THE RECALL BEGAN ON DECEMBER 8, 2004. OWNERS SHOULD CONTACT HONDA AT 1-866-784-1870.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Electrical systemWiring	3	0	0	0	—
Tires	2	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Tires
THE FRONT TIRE ON MY MOTORCYCLE, A DUNLOP ROADSMART SIZE 120/70ZR-18, SUFFERED A CATASTROPHIC FAILURE WHILE TRAVELING ON THE FREEWAY. VISUAL EVIDENCE SUGGESTS THE BELT SEPARATED UNDER THE TREAD, THEN SPLIT THE TIRE CARCASS RESULTING IN ABOUT A 3 INCH GASH AND A RAPID LOSS OF PRESSURE. IT DOES NOT APPEAR TO BE THE RESULT OF HITTING A ROAD HAZARD. LUCKILY I MANAGED TO GET THE MOTORCYCLE OFF THE ROAD SAFELY. I HAVE DETAILED PHOTOGRAPHS OF THE FAILURE AT HTTP://USMOTOGPFANS.COM/PIX/MAIN.PHP?G2_ITEMID=117. THE TIRE IS BEING HELD AT A MOTORCYCLE DEALERSHIP WHO DID MY REPAIRS, BELLEVILLE HONDA IN BELLEVILLE IL. THE FAILURE LOOKS NEARLY IDENTICAL TO THIS ONE EXPERIENCED BY ANOTHER RIDER USING THE…
Aug 26, 2010 · 52,600 miles
Tires
I HAD THE FRONT DUNLOP ROADSMART TIRE OF MY MOTOR CYCLE DEVELOP A LARGE BLISTER AFTER A RIDE OF APPROX. 60 MILES.(TOTAL TIRE MILEAGE IS 13,800M) THE BLISTER SIZE IS 4 INCHES LONG, 2 INCHES WIDE AND 0.5INCHES HIGH. THIS CAUSED A DANGEROUS VIBRATION THROUGH THE MOTORCYCLE AND BADLY AFFECTED THE HANDLING OF THE MOTORCYCLE. THE TIRE SIZE IS 120/70/ZR18. THE PRESSURE WAS SET AT THE RECOMMENDED PRESSURE BY THE MANUFACTURER (42PSI) AND THERE WERE NO ROAD HAZARDS ENCOUNTERED AT THE TIME THE BLISTER OCCURRED. A COMPLAINT E-MAIL WAS SENT TO DUNLOP ON 6/22/2010 REQUESTING COMMENTS ON THIS BLISTER BUT TO DATE NO REPLY HAS BEEN RECEIVED. *TR
Jun 20, 2010 · 13,861 miles
Electrical system › Wiring
(1) NO FAILURE HAS OCCURRED YET. (2) POTENTIAL FAILURE - THE MAIN WIRE HARNESS HAS A GROUND DISTRIBUTION CONNECTOR. THE CONNECTOR WAS IMPROPERLY WIRED AND COULD OVERHEAT. IF THE CONNECTOR OVERHEATS, POWER TO VARIOUS CIRCUITS COULD BE LOST. AS ARESULT, A LOSS OF CRITICAL LIGHTING OR ENGINE POWER COULD OCCUR WITHOUT WARNING, WHICH COULD CAUSE A CRASH. (3) NOTHING HAS BEEN DONE BY THE DEALER TO CORRECT THIS PROBLEM - ACCORDING TO THE DEALER THE PARTS NEEDED TO REPAIR THIS FAILURE ARE NOT AVAILABLE TILL JULY 2005 THUS THE DEALER IS UNABLE TO REMEDY THE DEFECT WITHIN A REASONABLE PERIOD OF TIME (60 DAYS FROM THE DATE I FIRST CONTACTED THE DEALER FOR REPAIR).*AK
Mar 28, 2005
Electrical system › Wiring
PARTS ARE NOT AVAILABLE FOR HONDA RECALLS NHTSA 04V568000 AND 04V549000. RECALLS CAME OUT OVER 90 DAYS AGO. THEY HAVE HAD MY BIKE FOR OVER 30 DAYS. DEALER CANNOT DO WORK BECAUSE OF LACK OF PARTS. I FEEL HONDA NOT LIVING UP TO INTENT OF THE RECALL IN FAILING TO PROVIDE EXPEDIENT REPAIR.*AK
Sep 20, 2004 · 12,500 miles
Electrical system › Wiring
HONDA MOTORCYCLE WIRING HARNESS SAFETY RECALL. *NM RECALL CAMPAIGN : 04V568000. THE CONSUMER STATED THAT HE IS HAVING DIFFICULTY GETTING HONDA TO COMPLY WITH THE SAFETY RECALL OF HIS MOTORCYCLE. THE CONSUMER STATED THAT THE PROBLEM CENTERS ON THE FACT THAT AMERICAN HONDA ISSUES PARTS REQUIRED BY THE RECALL TO THE SELLING DEALER. AMERICAN HONDA WILL NOT SEND PARTS TO THE LOCAL DEALER, THEY WILL ONLY SEND PARTS TO THE SELLING DEALER AND THE CONSUMER PURCHASED THE MOTORCYCLE IN OHIO, AND HE DOES NOT LIVE THERE. *TC
Jan 1, 2005

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.