Model year record

2006 Honda VT750C recalls & problems

The 2006 Honda VT750C has 1 safety recall and 8 owner complaints on file with NHTSA. The most-reported problem area is fuel system, gasoline (6 complaints).

Recalls1safety recalls

Complaints8filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Exterior lightingDec 20, 2005

Headlights › Switch

Recall 05V5620006,786 vehicles

Problem: ON CERTAIN MOTORCYCLES, A DAMAGED CONNECTOR IN THE HANDLEBAR MOUNTED HEADLIGHT SWITCH MAY CAUSE THE HEADLIGHT TO FLICKER AND EVENTUALLY FAIL.
Risk: IF RIDING AT NIGHT, THE SUDDEN LOSS OF HEADLIGHTS COULD RESULT IN A CRASH.
Fix: DEALERS WILL INSTALL NEW LEFT AND RIGHT HANDLE SWITCH ASSEMBLIES WITH UNDAMAGED CONNECTORS FREE OF CHARGE. AN INTERIM LETTER TO OWNERS WAS MAILED ON DECEMBER 13, 2005. THE RECALL BEGAN ON DECEMBER 15, 2005. OWNERS MAY CONTACT HONDA AT 1-866-784-1870.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Typical mileage*
Fuel system, gasolineDelivery	6	3,000 mi
Exterior lightingHeadlights	1	—
Service brakes, hydraulic	1	—
Fuel/propulsion system	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
BOUGHT THE SHADOW AND NOTICED THE PETCOCK WAS LEAKING WHEN TURNED ON. I BOUGHT A FACTORY PETCOCK FROM HONDA AND INSTALLED IT. NOW NOT A FEW MONTHS LATER THE EXACT SAME THING. IT IS A FAULTY DIAPHRAGM THAT CAUSES GAS TO LEAK ONTO A HOT ENGINE BLOCK. IT NEEDS TO BE RECALLED AND SET RIGHT BY THE DEALERS. THIS IS A SERIOUS ISSUE. 1- IT'S LEAKING GAS, THAT'S A PRETTY PENNY NOWADAYS, 2- IT'S AN ENVIRONMENTAL HAZARD IF GAS IS LEAKING ALL OVER THE GROUND,3- IT'S A FIRE HAZARD FOR THE RIDER AND PEOPLE AROUND SHOULD THE BIKE DECIDE TO COMBUST, 4- IT IS NOT A RARE PROBLEM LOOK AT ANY 2004 AND UP SAME PROBLEMS, 5- THE DEALERS ARE SELLING THE SAME FAULTY PARTS, ALL IN ALL THERE IS NO FIX. PLEASE LOOK…
Jul 1, 2013 · 12,000 miles
Service brakes, hydraulic
TL* THE CONTACT OWNS A 2006 HONDA VT750C. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 TO 35 MPH AND DEPRESSING THE REAR BRAKES, THE VEHICLE WOULD NOT STOP. THE DRIVER HAD TO MANUALLY PULL THE LEVER FOR THE FRONT BRAKES IN ORDER TO STOP. AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE MASTER CYLINDER WAS FRACTURED AND HAD CAUSED THE REAR BRAKES TO FAIL. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED TO SEND THE CONTACT A NEW PART FOR THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 8,000.
Sep 8, 2011 · 8,000 miles
Fuel system, gasoline
FUEL LEAKING FROM PETCOCK ONTO ENGINE WHILE RUNNING. *KB
Jan 1, 2011
Fuel system, gasoline
TL*THE CONTACT OWNS A 2006 HONDA SHADOW AERO VT750C MOTORCYCLE. THE CONTACT SMELLED A STRONG ODOR OF FUEL WHEN THE MOTORCYCLE WAS STATIONARY. HE ALSO, OBSERVED A LARGE AMOUNT OF FUEL NEAR THE FUEL TANK . THERE WERE NO PRIOR WARNINGS. AN AUTHORIZED DEALER WAS NOTIFIED OF THE FAILURE. THE MOTORCYCLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION AT THIS TIME. THE MOTORCYCLE IS NOT BEING DRIVEN DUE TO THE CONCERN OF A SIGNIFICANT SAFETY HAZARD. THE FAILURE AND CURRENT MILEAGES WERE 3,340. UPDATED 10/09/09 *CN UPDATED 10/16/09
Sep 5, 2009 · 3,340 miles
Fuel system, gasoline
I HAVE A 2006 HONDA SHADOW AERO 750CC MOTORCYCLE. SOMETIME WHEN I START IT UP IT WILL RUN FOR A COUPLE OF MINUTES AND THEN CUT OFF AND WILL NOT START BACK. THIS HAS HAPPENED 4 TIMES NOW IN THE LAST YEAR. ONCE WHILE I WAS ON THE ROAD DRIVING AND 3 TIMES WHILE I HAVE HAD THE BIKE RUNNING TO WARM UP. I LET IT SET FOR AWHILE ABOUT AN HOUR OR SO AND IT WILL START BACK UP AND RUN GOOD. I KNOW THAT THERE HAS BEEN A RECALL ON SOME OF THE PETCOCKS ON OUR BIKES. I HAVE TAKEN THE VIN # TO THE DEALER AND HAD THEM CHECK TO SEE IF MINE WAS ONE OF THE ONES ON RECALL. THEY HAVE SAID NO. I HAVE TAKEN THE PETCOCK OFF AND TAKEN IT TO THE DEALER TO CHECK IT AND THEY HAVE STATED THAT THERE IS NOTHING THAT THEY…
Jun 30, 2009 · 4,500 miles
Fuel system, gasoline › Delivery
THE RECALL ON HONDA VT750C AEROS FOR A FUEL VALVE PROBLEM SHOULD BE EXTENDED TO ALL 2004 THROUGH THE PRESENT YEAR. THE DIAPHRAGM IN THE PETCOCK IS OF A FAULTY DESIGN AND FAILS WITH GREAT REGULARITY ENDANGERING THE PUBLIC WITH THE GREAT POSSIBILITY OF FIRES FROM GASOLINE LEAKING ON THE HOT ENGINE WHILE RIDING THE MOTORCYCLE. I AM A MEMBER OF THE HONDA AERO 750 FORUM AND THIS IS A TOPIC THAT COMES UP REGULARLY. MANY, MANY RIDERS OF THIS VT750 AERO FROM 2004 TO PRESENT HAVE BEEN ENDANGERED AND CONTINUE TO BE ENDANGERED BY THIS DEFECT. THE RECALL ON THE 2007 AND 2008 MODELS IS #08V14100. THANK YOU. *TR
Sep 15, 2008 · 749 miles
Exterior lighting › Headlights
TL*THE CONTACT OWNS A 2006 HONDA SHADOW ARROW VT750C. WHILE DRIVING 45 MPH, THE HEADLIGHTS DIMMED INTERMITTENTLY. THE VEHICLE HAD NOT YET BEEN TAKEN TO THE DEALER, BUT AN APPOINTMENT WAS SCHEDULED. THE CONTACT DISCOVERED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V562000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE PURCHASE DATE, ENGINE SIZE, NUMBER OF CYLINDERS, AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE WAS 9,623 AND FAILURE MILEAGE WAS 9,600.
Mar 23, 2008 · 9,600 miles
Fuel system, gasoline
TL*THE CONTACT OWNS A 2006 HONDA VT750C. WHILE DRIVING 2 MPH, THE CONTACT NOTICED FUEL LEAKING FROM THE VALVE ONTO THE ENGINE. THE DEALER STATED THAT THE LEAK WAS CAUSED BY OLD FUEL AND RECOMMENDED THAT THE FUEL VALVE BE REPLACED. THE REPLACEMENT WAS MADE. THE CURRENT AND FAILURE MILEAGES WERE 3,000.
Jul 20, 2007 · 3,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.