The 2005 Hummer H2 has 3 safety recalls and 79 owner complaints on file with NHTSA. The most-reported problem area is electrical system (27 complaints).
Recalls3safety recalls
Complaints79filed by owners
Crashes · fires3 · 1reported in complaints
Injuries · deaths2 · 0reported in complaints
Safety recalls
Steering
NHTSA recall 06E010000 · Feb 1, 2006 · 1,360 vehicles
Problem: CERTAIN FABTECH AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS71000 AND FTS71001, INSTALLED FOR USE ON CERTAIN 2001-2006 GM C/K 2500 PICK UP TRUCKS AND SPORT UTILITY VEHICLES. THE PIN LOCATED INSIDE THE PITMAN ARM CAN SHEAR OFF DUE TO A REVERSE BENDING FATIGUE CONDITION, RESULTING IN A TOTAL LOSS OF STEERING CONTROL.
Risk: LOSS OF STEERING CONTROL COULD LEAD TO A VEHICLE CRASH WITH POTENTIAL INJURY OR DEATH.
Fix: FABTECH WILL NOTIFY OWNERS AND REPLACE THE PITMAN AND IDLER ARMS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2006. OWNERS MAY CONTACT FABTECH AT 909-597-7800.
Problem: ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Risk: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
Fix: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Service brakes, hydraulic
NHTSA recall 05V043000 · Feb 8, 2005 · 77,411 vehicles
Problem: CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Risk: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Fix: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
2005 Hummer H2 4-DR
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
Not Rated
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Air bags Frontal › Sensor/control module; On-off switch assembly
15
1
0
0
100,000 mi
Steering Linkages › Knuckle › Spindle › Arm
6
1
0
0
140,000 mi
Service brakes
6
0
0
0
80,733 mi
Service brakes, hydraulic Antilock/traction control/electronic limited slip
5
0
0
0
78,250 mi
Power train Driveline › Differential unit; Automatic transmission
4
0
0
1
29,557 mi
Visibility/wiper
4
0
1
0
154,500 mi
Engine
4
0
0
1
122,200 mi
Tires
3
0
0
0
—
Unknown or other
3
0
0
0
—
Wheels Rim
2
1
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Mar 24, 2026 · 140,000 milesSteering The contact owns a 2005 Hummer H2. The contact stated that while the vehicle was parked, fluid started to leak from the steering wheel. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 140,000.
Jun 10, 2020Tires The contact owns a 2005 Hummer H2 equipped with Cooper Tires, Tire Line: Discoverer, Tire size: 35X13.50R20LT, DOT Number: 1V1261B4V1724. The contact stated that while the vehicle was being serviced and on a lift, the mechanic became aware that all four tires were split in the middle of each tire. The vehicle was taken to a tire retailer where the tires were originally purchased and replaced, but the failure reoccurred. The contact stated that on another occasion, while the tires were being rotated, the mechanic became aware that the rear driverâs side tire had a tear in the sidewall. The tire was replaced. The manufacturer was notified of the failure. The failure mileage was unknown.
Jul 4, 2025 · 111,400 miles · 1 injuryPower train The contact owns a 2005 Hummer H2. The contact stated that while parking in the mountains, the vehicle was in the park position, and it unexpectedly rolled and stopped at a boulder. There were no warning lights illuminated. The door hit the driver and knocked him to the ground, and he sustained an injury to his head, but medical attention was not provided. Another person on an ATV provided a jump start, but the vehicle failed to restart. The contact walked several miles to get assistance. The contact was able to view YouTube and replace the part. The contact stated that the transmission shifter cable had failed. There was a hole in the shaft connected to the transmission to the C clip. The…
May 10, 2021 · 70,000 milesService brakes, hydraulic The contact owns a 2005 Hummer H2. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the brakes made a whistling sound. The contact, an independent mechanic, diagnosed that the brake booster needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that there was no recall associated with the VIN. The failure mileage was approximately 70,000.
Nov 19, 2020 · 41,280 milesElectrical system WHILE TRAVELING ON THE MAIN ROADS THE SPEEDOMETER INTERMITTENTLY MALFUNCTIONS THEN DROPS TO ZERO, WHEREAS I'M LITERALLY UNABLE TO DETERMINE MY SPEED THIS SEEMS TO OCCUR WHEN THE ENGINE WARMS UP AND I BEEN DRIVING FOR BETTER THAN A HALF HOUR.
Nov 5, 2020 · 240,000 milesSteering TL* THE CONTACT OWNS A 2005 HUMMER H2. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE, THE POWER STEERING FAILED, CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN IN EITHER DIRECTION. ADDITIONALLY, THE POWER STEERING FLUID LEAKED UNTO THE HYDRO-BOOST BRAKING SYSTEM, CAUSING THE BRAKES TO MALFUNCTION AND BECOME SPONGY, EXTENDING THE BRAKING DISTANCE. THE CONTACT WORKS AS AN INDEPENDENT MECHANIC AND CONFIRMED THE CAUSES OF THE FAILURES. THE LOCAL DEALER APPLE VALLEY CHEVROLET LOCATED AT 650 FOXCROFT AVE, MARTINSBURG, WV 25401 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 05V043000…
Aug 31, 2020 · 62,000 milesTires TOYO TIRES | PART NUMBER: TOY360390 COMING APART AT THE SEAMS
Sep 17, 2019 · 160,000 milesElectrical system THE COMPUTER IN THE H2 HUMMER MALFUNCTION. WIPERS WILL NOT TURN OFF. 4 WHEEL DRIVE WILL NOT ENGAGE. ENGINE LIGHT COMES ON. EVERYTHING THE COMPUTER CONTROLS IS FAILING.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA05017 · opened Oct 28, 2005 · closed Apr 30, 2007HUMMER H2 STEERING KNUCKLE FAILURES ODI UPGRADED THIS INVESTIGATION AT THE CONCLUSION OF PE04-080.THE ALLEGED DEFECT INVOLVES THE FAILURE OF THE STEERING KNUCKLE AT THE LOWER BALL JOINT BOSS, RESULTING IN A SEPARATION OF THE LOWER BALL JOINT FROM THE KNUCKLE.A LOWER BALL JOINT SEPARATION COULD RESULT IN A LOSS OF STEERING AND/OR A DISABLED VEHICLE. IT APPEARS THAT THE FRACTURES OF H2 STEERING KNUCKLES CAN BE ATTRIBUTED TO WHEEL/TIRE COLLISION FORCES BEING TRANSFERRED DIRECTLY TO THE STEERING KNUCKLE.THE ORIGINAL KNUCKLE DESIGN APPEARS TO BE SUFFICIENT FOR THE H2 APPLICATION.EVIDENCE FROM INSPECTED VEHICLES, PHOTOGRAPHS, POLICE REPORTS AND EDR DATA INDICATES COLLISION IMPACT EVENTS PLACED STRESS ON THE STEERING KNUCKLE CAUSING IT TO FRACTURE.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH…