Model year record

2006 Hummer H2 recalls & problems

The 2006 Hummer H2 has 5 safety recalls and 22 owner complaints on file with NHTSA. The most-reported problem area is suspension (4 complaints).

Recalls5safety recalls

Complaints22filed by owners

Crashes · fires3 · 1reported in complaints

Injuries · deaths5 · 0reported in complaints

Safety recalls

Electrical systemJun 4, 2010

Electrical system

Recall 10V2400001,365,070 vehicles

Problem: GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Risk: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Fix: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Electrical systemAug 28, 2008

Electrical system

Recall 08V441000857,735 vehiclesopened after NHTSA action (ODI)

Problem: GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Risk: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Fix: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

SteeringFeb 1, 2006

Steering

Recall 06E0100001,360 vehicles

Problem: CERTAIN FABTECH AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS71000 AND FTS71001, INSTALLED FOR USE ON CERTAIN 2001-2006 GM C/K 2500 PICK UP TRUCKS AND SPORT UTILITY VEHICLES. THE PIN LOCATED INSIDE THE PITMAN ARM CAN SHEAR OFF DUE TO A REVERSE BENDING FATIGUE CONDITION, RESULTING IN A TOTAL LOSS OF STEERING CONTROL.
Risk: LOSS OF STEERING CONTROL COULD LEAD TO A VEHICLE CRASH WITH POTENTIAL INJURY OR DEATH.
Fix: FABTECH WILL NOTIFY OWNERS AND REPLACE THE PITMAN AND IDLER ARMS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2006. OWNERS MAY CONTACT FABTECH AT 909-597-7800.

EquipmentDec 7, 2005

Other › Labels

Recall 05V55200032,068 vehicles

Problem: CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Risk: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Fix: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.

SteeringOct 5, 2005

Hydraulic power assist › Hose, piping, and connections

Recall 05V455000123,592 vehicles

Problem: CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Risk: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Fix: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2006 Hummer H2 4-DR

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
SuspensionRear; Front › Control arm › Lower ball joint	4	1	0	2	8,000 mi
Electrical system	4	0	1	1	155,000 mi
Steering	3	0	0	1	54,500 mi
Engine	3	0	0	0	115,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip	2	0	0	1	—
Power trainManual transmission; Automatic transmission	2	0	0	1	—
Engine and engine coolingExhaust system	2	0	0	0	—
Seats	2	0	1	1	—
Air bags	2	2	0	2	—
Service brakes	2	0	0	0	—
Unknown or other	2	0	0	0	—
Interior lighting	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Visibility › Defroster/defogger/hvac system › Fan/motor › Resistor/speed control
The contact owns a 2006 Hummer H2. The contact stated while driving and activating the blower motor, the blower motor was intermittently inoperable. The contact stated that an abnormal electrical burning odor was coming from the vehicle. The contact stated that upon activation, the A/C and the heating systems were intermittently inoperable. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the blower motor wiring harness needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 190,000.
Oct 2, 2024 · 190,000 miles
Electrical system
The contact owns a 2006 Hummer H2. The contact stated while driving at undisclosed speeds with the A/C activated, the contact became aware of an abnormal burning electrical odor. No warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the blower motor resistor needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 196,000.
May 17, 2024 · 196,000 miles
Steering
THE OTHER DAY I TOOK A RIDE IN MY TRUCK AND UPON DRIVING APPROXIMATELY TWO BLOCKS FROM MY HOME THE STEERING CONTROL OF THE CAR TOTALLY FAILED. IMAGINE DRIVING YOUR CAR AND AT SOME POINT, YOU LOSE THE CAPABILITY OF CONTROLLING YOUR CARS DIRECTION WHILE HOLDING YOUR STEERING WHEEL. ONE CAN ONLY IMAGINE IF I WAS GOING 65 MILES AN HOUR AND DRIVING ON A HIGHWAY THEN LOSING THE ABILITY TO TURN YOUR WHEELS. I AM BLESSED THIS MALFUNCTION HAPPENED WHEN I WAS ONLY TRAVELING 10 MILES AN HOUR. AFTER CALLING A TOW TRUCK AND HAVING MY CAR TOWED TO A LOCAL REPAIR SHOP, IT WAS DETERMINED THE CONTROL ARM BOLT HAD BROKEN OFF THEREFORE LOSING TOTAL CONTROL OF THE CARS STEERING CAPABILITY. THIS IS UNHEARD OF…
Jul 15, 2019 · 130,000 miles
Seat belts
SALESMAN MR LAWRENCE SAID THAT THEY COULD NOT SELL A VEHICLE WITH SEAT BELTS THAT DID NOT WORK THE DRIVERS SIDE REAR WAS NOT REPAIRED AS STATED. I TOOK DELIVERY OF THE USED VEHICLE 2-18-19 AT 0800 APPROXIMATELY
Feb 18, 2019
Engine
EXHAUST BOLTS BROKEN , LEAKING EXHAUST FUMES INTO VEHICLE , ENGINE FIRE ???? CITY DRIVING
Mar 14, 2018 · 115,000 miles
Engine
EXHAUST LEAKING BECAUSE MANIFOLD BOLTS BROKEN , THIS IS MY SECOND HUMMER , MY LAWYER HAS A HUMMER ALSO AND I BELONG TO HUMMER GROUP HERE IN FLORIDA
Mar 14, 2018 · 115,000 miles
Electrical systemFire
VEHICLE HAD BEEN DRIVEN APPROXIMATELY 2 MILES FROM START TIME, WAS STATIONARY AND UNOCCUPIED FOR APPROXIMATELY 10-25 MINUTES. VEHICLE INTERIOR CAUGHT FIRE AT THE BASE OF THE TOP SITTING AREA OF THE REAR SEAT, FLAMES FROM FIRE MELTED THE OVER HEAD INTERIOR LIGHT AND IGNITED A FIRE ON THE HEAD LINER, WHICH CAUSED THE FIRE TO SPREAD UNDER NEATH THE HEADLINER AND ROOF OF THE VEHICLE, MELTING THE EXTERIOR PAINT. THERE WAS NO PRIOR INDICATION OF BURNING WHEN DRIVING OR AFTER PARKING THE VEHICLE PRIOR TO THE FIRE. FIRE DEPARTMENT ADVISED IT WAS BELIEVED TO BE RELATED TO REAR SEAT HEATERS MALFUNCTIONING CAUSING COMBUSTION THAT LEAD TO AN INTERIOR FIRE. DOORS WERE LOCKED PRIOR TO THE FIRE, AND STORE…
Aug 5, 2016 · 120,000 miles
Service brakes
TL* THE CONTACT OWNS A 2006 HUMMER H2. THE CONTACT STATED THAT THE BRAKE LINES WERE CORRODED, WHICH CAUSED THEM TO RUPTURE AND LEAK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 111,000.
Oct 20, 2015 · 111,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

NON-CRASH ENGINE COMPARTMENT FIRESClosedLed to recall 08V441000
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441:…
EA08010 · opened Jun 12, 2008 · closed Sep 8, 2008
HUMMER H2 STEERING KNUCKLE FAILURESClosed
ODI UPGRADED THIS INVESTIGATION AT THE CONCLUSION OF PE04-080.THE ALLEGED DEFECT INVOLVES THE FAILURE OF THE STEERING KNUCKLE AT THE LOWER BALL JOINT BOSS, RESULTING IN A SEPARATION OF THE LOWER BALL JOINT FROM THE KNUCKLE.A LOWER BALL JOINT SEPARATION COULD RESULT IN A LOSS OF STEERING AND/OR A DISABLED VEHICLE. IT APPEARS THAT THE FRACTURES OF H2 STEERING KNUCKLES CAN BE ATTRIBUTED TO WHEEL/TIRE COLLISION FORCES BEING TRANSFERRED DIRECTLY TO THE STEERING KNUCKLE.THE ORIGINAL KNUCKLE DESIGN APPEARS TO BE SUFFICIENT FOR THE H2 APPLICATION.EVIDENCE FROM INSPECTED VEHICLES, PHOTOGRAPHS, POLICE REPORTS AND EDR DATA INDICATES COLLISION IMPACT EVENTS PLACED STRESS ON THE STEERING KNUCKLE CAUSING IT TO FRACTURE.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH…
EA05017 · opened Oct 28, 2005 · closed Apr 30, 2007