*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Power train
After Hyundai 9C2 update the transmission bucks or searches for gear causing what seems to be up and down shifting.
Jun 20, 2026Power train
Driving at highway speed, vehicle stuttered/lurched. The check AWD, engine light, tire pressure warning lights came on. Check by mechanic resulted in error code P0741 (Torque Converter Clutch Circuit Performance or Stuck Off). Search of error code P0741 indicates that there is a Technical Service Bulletin TSB-23-AT-005H regarding this KNOWN problem. A stutter or lurch of the vehicle can cause the driver to over react, stop or swerve suddenly in traffic potentially causing an accident not to mention possible being struck on the side of the road while waiting for a tow/service truck. Vehicle/components have not been checked by manufacturer--only diagnostic code by Mechanic. Warning lights…
Oct 4, 2026Electrical systemFire
On August 14 2026, I drove my 2019 Hyundai Santa Fe approximately one mile from my residence to work at approximately 5:00 AM. The vehicle was operating normally and I experienced no warning lights, unusual noises, odors, smoke, or other indications of a problem. I parked the vehicle in an outdoor parking lot and the vehicle remained parked and turned off for approximately four hours. At approximately 9am, I was notified that my vehicle was smoking. A person who was walking past the vehicle observed the smoke, obtained a fire extinguisher, and extinguished the fire. The fire department subsequently responded, disconnected the vehicle battery, and opened the rear of the vehicle to ventilate…
Aug 14, 2026Engine
On 03/26/2026, my 2019 Hyundai Santa Fe received Hyundai Service Campaign 9C2 (TSB 26-01-013H-1), which included an Engine Control Module (ECM) software update for Theta II emissions improvement. The vehicle did not have the following drivability problem before this software update. Immediately after the 9C2 update, the vehicle began jerking/bucking slightly at low speeds, most noticeably around 10-20 mph when coasting with no accelerator input or when applying very light throttle. Acceleration response also feels slower than before the update, with noticeable hesitation when the accelerator is pressed. The problem is most noticeable during the beginning of a drive when the vehicle is cold.…
Mar 26, 2026Engine
The vehicle experienced a sudden, intermittent engine stall while driving, specifically when slowing down or coasting to a stop in live traffic. When the engine dies, the vehicle immediately loses engine power, power steering, and power braking assist, creating an extreme safety hazard. After stalling, the vehicle refuses to restart for several minutes. An authorized Hyundai dealership previously replaced the high-pressure fuel pump under warranty to address this issue, but the dangerous stalling has persisted over the last 2,000 miles. The vehicle continues to randomly shut off without throwing a permanent check engine light or diagnostic trouble code, and the manufacturer has failed to…
Apr 9, 2026Engine
The car started having problems immediately after replacement with a new battery. The issue with the ISG (Idle Stop and GO System) started appearing. When the Auto Stop Indicator turns green, the car stalls which puts my life at risk. I have spoken to a number of mechanics and I am not getting a satisfactory answer on how to fix this problem.. One mechanic told me it was the starter which turned out not to be true. I have also spoken with a number of other mechanics and they are clueless on how this problem can be remedied. And the Hyundai dealter wanted $275 just to look at it but with no guarentee. The whole issue is putting my life and other motorists at risk.
Apr 15, 2025EngineFire
2019 Santa Fe with 80,000 miles showed signs of excessive oil consumption. Service was scheduled with licensed Hyundai franchise service center. Known oil consumption issues on Theta II engines for that year. Testing requires 3 steps. First step is to change the oil and document levels. Engine is tested for 1000 miles then returned to service center. After 1000 miles, service center reports 2.5 qts of oil per 1000 miles. Hyundai corporate was contacted where they approved warranty work for the vehicle. Step two requires Combustion Chamber Cleaning. During this portion of the work, service center calls about fire that took place immediately after a test drive. Dealership states engine and…
Sep 8, 2026Fuel/propulsion system
My vehicle had a very strong gas smell inside and outside of the car. I found a gas puddle under the car coming from the back of the vehicle. Car was hesitating when I stepped on the gas. I was afraid it may stall. I drove the vehicle to my regular service station. Vehicle has an active fuel leak and this is a fire hazard. I was very concerned whether the vehicle would stall and cause an accident. Warranty coverage was denied.
Aug 28, 2026
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
