2001 Isuzu Rodeo Sport recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Suspension › Rear

  TL* THE CONTACT OWNS A 2001 ISUZU RODEO SPORT. WHILE INSPECTING THE VEHICLE, THE CONTACT NOTICED CORROSION ON THE UNDERCARRIAGE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE REAR SUSPENSION LOWER LINK BRACKET WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

  Apr 24, 2015 · 180,000 miles
• Structure › Body

  TL* THE CONTACT OWNS A 2001 ISUZU RODEO SPORT. THE CONTACT STATED THAT THE FRAME WAS SEVERELY CORRODED AND THE REAR LATERAL ARM WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS MADE AWARE THAT NHTSA CAMPAIGN NUMBER: 104V36000 (SUSPENSION) HAD EXPIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 180,000.

  Apr 10, 2015 · 180,000 miles
• Structure › Body

  I GOT A LETTER FROM ISUZU ASKING ME TO COME IN FOR A RECALL DUE TO PRE-MATURE FRAME RUSTING I WAS TOLD THEY HAD TO LIFT THE BODY OFF THE FRAME TO INSPECT IT AND I WAS HAVING THE GAS-LEVEL SENDER REPLACED AT THE SAME TIME. I WAS TOLD BY THE SERVICE DEPARTMENT THAT BOLTS HOLDING THE CASSIS TO THE FRAME HAD A TENDENCY TO FAIL SO THEY WERE BEING REPLACED WITH STAINLESS STEEL HARDWARE. WHEN I GOT THE TRUCK BACK THE NEW SHINY BOLTS AND NUTS WERE VISIBLE EXTERNALLY AND I WAS ASSURED THAT MY TRUCK WAS NOT THAT BAD AND IT WAS JUST A PRECAUTIONARY MEASURE. I WAS TOLD THE FRAME WAS IN PRETTY GOOD SHAPE AND THAT THEY APPLIED SOME ANTI-RUST TREATMENT TO THE AREAS AND FOR ADDED STRENGTH, 2 REINFORCEMENT…

  Jun 1, 2009 · 85,000 miles
• Suspension

  WHILE DRIVING IN VEHICLE, APPROXIMATELY 35 MPH, NORMAL DRY CONDITIONS, DRIVER-SIDE REAR SUSPENSION TRAILING ARM BRACKET BROKE FREE FROM FRAME. VEHICLE VEERED RIGHT SLIGHTLY AND GENERATED A GROANING SOUND. PULLED VEHICLE OFF THE ROAD. UPON INSPECTION UNDERNEATH VEHICLE REALIZED FRAME SECTION CORRODED COMPLETELY THROUGH ALLOWING TRAILING ARM BUSHING MOUNTING BRACKET TO COMPLETELY SEPARATE FROM FRAME. LOW MILEAGE (CONSIDERING YEAR) WELL CARED FOR VEHICLE IN OTHERWISE GOOD CONDITION. HAVE SENSE LEARNED THIS TO BE AN ALL TOO COMMON PROBLEM KNOWN BY OEM BUT NOT BY SECONDARY BUYERS, THESE VEHICLES SHOULD NOT BE ON ROAD. LESS THAN A YEARS USE FROM THIS VEHICLE AFTER LOAN/PURCHASE. *TR

  Mar 21, 2014 · 99,000 miles
• Structure › Body

  THE FRAME IS SO BADLY ROTTED OUT THAT IT WON'T PASS A SAFETY INSPECTION . *TR

  Mar 18, 2014 · 130,000 miles
• Structure › Frame and members › Underbody shields

  ERODING FRAME UNDERNEATH CAR. MY CAR SHAKES AND SQUEAKS HORRIBLY! MY CAR IS SO BADLY RUSTED THAT I HAVE HOLES AND I CAN SEE THROUGH THE CAR UNDERNEATH! *TR

  Jan 15, 2014
• Structure › Body

  TL* THE CONTACT OWNS A 2001 ISUZU RODEO SPORT. THE CONTACT STATED WHILE THE VEHICLE WAS BEING INSPECTED RUST WAS FOUND AROUND THE FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. THE CURRENT APPROXIMATE MILEAGE WAS 140,000.

  May 17, 2012 · 13,000 miles
• Suspension

  TL* THE CONTACT OWNS A 2001 ISUZU RODEO SPORT. THE CONTACT STATED THAT AFTER RECEIVING NOTIFICATION OF NHTSA CAMPAIGN I.D. 10V436000 (SUSPENSION:REAR), THE VEHICLE WAS TAKEN TO THE DEALER FOR RECALL REPAIRS. AFTER INSPECTING THE VEHICLE, THE DEALER ADVISED THE CONTACT THAT THE RUST ON THE FRAME WAS TOO EXCESSIVE AND COULD NOT BE REPAIRED. IN ADDITION, THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 53,123.

  Aug 17, 2012 · 53,123 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• REAR SUSPENSION LOWER LINK FAILUREClosedLed to recall 10V436000

  DURING PRELIMINARY EVALUATION PE09-030, ISUZU MOTORS AMERICA, INC (ISUZU) NOTED TWO PRIMARY DIFFERENCES ONCE THE REAR SUSPENSION LOWER LINK SEPARATION OCCURS BETWEEN THE ALLEGED DEFECT (SEPARATION OF THE LOWER LINK FROM THE FRAME) OF THIS INVESTIGATION AND A SAFETY DEFECT INVOLVING LOWER LINK SEPARATION FROM THE REAR AXLE ADDRESSED BY ISUZU IN SAFETY RECALL 00V-058.IN THE CASE OF THE DEFECT CONDITION IDENTIFIED IN RECALL 00V-058, ISUZU STATED THAT THE ATTACHMENT BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE POSSIBLY CREATING A LOSS OF VEHICLE CONTROL. ISUZU ALSO STATED THAT THIS CONDITION OCCURS EARLY IN THE SERVICE LIFE OF THE VEHICLE.IN THIS INVESTIGATION ISUZU NOTED LOWER LINK SEPARATION FROM THE FRAME IS A PROGRESSIVE CORROSION ISSUE WITH PRIOR WARNING TO CONSUMERS.ISUZU ALSO STATED THAT IN THE EVENT OF A LOWER LINK SEPARATION FROM THE FRAME, THE…

  PE09030 · opened Jun 16, 2009 · closed Dec 8, 2009