2018 Kia Optima recalls & problems

Recent owner complaints

• Aug 8, 2026Engine
  My 2018 Kia Optima has the Theta II 2.4L engine. In February 2026, the dealer performed an engine/powertrain computer reprogramming. In August 2026, the engine failed and the vehicle was taken to an authorized Kia dealer, where the engine was replaced under the Theta II engine warranty. The vehicle was at the dealer from August 8 until the repair was completed on September 29, 2026. When I picked up the vehicle on October 9, it felt shaky and vibrated on the drive home. On October 11, the vehicle began giving off a distinct, unfamiliar smell that is not like burning fuel or oil. On October 21, I found the vehicle leaking an opaque, milky tan fluid onto my garage floor. The type and source…
• Jul 8, 2026 · 126,000 milesEngine
  The contact owns a 2018 Kia Optima. The contact stated that upon starting the vehicle, the vehicle jerked abnormally. The failure persisted while driving, and the vehicle lost motive power. The contact was able to restart the vehicle; however, the failure persisted while driving. The vehicle was towed to a dealer to be repaired under an unknown recall for an engine software update and key fob replacement; however, the dealer failed to honor the recall repair and recommended purchasing a new vehicle. The manufacturer was contacted by phone, and a case was filed. The failure mileage was approximately 126,000. The VIN and License plate number were unavailable.
• Feb 1, 2026 · 136,000 milesEngine
  The contact owns a 2018 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate and failed to exceed 52 MPH. The vehicle shut off. The contact stated that the engine was running rough while stationary and the vehicle shut off without warning. The vehicle was taken to an Auto Parts Store, where it was diagnosed, and it was determined that the vehicle was in LIMP Mode with knock sensor codes displayed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 136,000.
• Jun 3, 2026Engine and engine cooling
  See attached document for complaint.
• Jul 14, 2026 · crash · 1 injuryAir bags
  I was run off the road by a drunk driver I hit a tree at 35MPH MY AIR BAGS DID NOT DEPLOY NOR DID MY SEAT BELT LOCK!!!! I NOW HAVE MULTIPLE INJURIES I HAVE BROKEN BONES ALL THROUGHOUT MY FACE!!!!! A SEVERE CONCUSSION!!!!! Any time I call the the customer care center and try and get information or call someone I either get hung up or gave the run around and then hung up on my mother in law has also tried calling and have received the same response this is so unacceptable and unprofessional.
• May 23, 2026Engine
  I’ve had my 2018 kia optima for round about two years.I only got this car because they refused to replace my previous engine on my 2015 Kia optima,even though I had a warranty but that’s another story(Kia on the Blvd).This car have given me problems from the start.Going through oil in less than a month,which they can never find a leak,not being able to go over a certain speed before I start to hear noises.Ive complained about noises,they act like they can’t hear,and said nothing is wrong with the engine when previously checked.My check engine light has came on twice and both times the car was malfunctioning on the highway resulting in me have to get a tow.First it was plugs…
• Jan 6, 2026Service brakes
  Purchased vehicle from a used car dealership. Had it a few months before brake pedal started losing pressure and going to floor. Had master cylinder replaced. A few months later, brake light started coming on when accelerating. New master cylinder had leaked into brake booster. Had master cylinder replaced along with brake booster. A few weeks later and brake pedal is losing pressure again
• Jun 15, 2026Engine
  The car burns oil within a week of getting an oil change. It was only driven a 200 miles before all of the oil was burned out. This has been a consistent issue with this car that the oil burns at an extreme rate. This is a safety risk as it could lead to engine overheating, the engine could stall out due to the fast burning of the oil, or a potential fire hazard while driving. The oil light will come on for a second and at that point, the oil is already EXTREMELY too low. I brought the car to the mechanic and they have told me multiple times that there is no leak or anything. The mechanic says that the car simply is burning oil too fast.

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• DP22003 · opened Sep 12, 2022 · closed Dec 12, 2023Loss of Motive Power
  The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003)…
• EA19001 · opened Apr 19, 2019 · closed Sep 19, 2024 · led to recall 20V024Electrical overstress
  The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW.  The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications.  The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal,…