Model year record

2015 Mercedes-Benz ML250 recalls & problems

The 2015 Mercedes-Benz ML250 has 6 safety recalls and 10 owner complaints on file with NHTSA. The most-reported problem area is engine (4 complaints).

Recalls6safety recalls

Complaints10filed by owners

Crashes · fires2 · 0reported in complaints

Injuries · deaths2 · 0reported in complaints

Safety recalls

Fuel system, gasolineDec 23, 2022

Delivery › Fuel pump › Control/drive module

Recall 22V955000348,183 vehicles

Problem: Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012-2014 ML550, 2012-2015 ML350, AMG ML63, 2015 ML250, ML400, 2016 GLE450, GLE300, 2016-2018 GLE350, GLE550, 2016-2019 GLE400, 2017-2019 AMG GLE43, and 2016-2020 AMG GLE63 vehicles. Water might accumulate in the spare tire wheel well and damage the fuel pump control unit, which could cause an engine stall while driving.
Risk: An engine stall while driving increases the risk of a crash.
Fix: Dealers will install a water drain plug, inspect for water intrusion, and replace the fuel pump control unit as necessary, free of charge. Owner notification letters were mailed February 15, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers for this recall are 2023010002 and 2023010003.

Components: Fuel system, gasoline › Delivery › Fuel pump › Control/drive module; Fuel system, diesel › Delivery › Fuel pump › Control/drive module

CommunicationNov 1, 2019

Communication

Recall 19V78700024,226 vehicles

Problem: Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2013-2017 vehicles due to a software fault that may cause the date and time for the emergency call system (eCall) to differ from the actual date and time, potentially relaying an inaccurate vehicle location. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V787-4620.pdf
Risk: An inaccurate vehicle location may delay emergency responders, increasing the risk of injury.
Fix: MBUSA has initiated an Over the Air (OTA) remote update. MBUSA will also notify owners, and dealers will check software for a successful OTA or update the communication module software as needed, free of charge. The recall began December 23, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2019120008.

Power trainDec 14, 2016

Axle assembly › Axle shaft

Recall 16V90000048 vehicles

Problem: Mercedes-Benz USA, LLC. (MBUSA) is recalling certain model year 2015 GL350 4Matic Blutec, GL450 4Matic, GL550 4Matic, ML250 Blutec, ML350, ML350 4Matic, ML400 4Matic and 2015-2016 GL63 AMG 4Matic vehicles manufactured September 29, 2014 through March 27, 2015. The affected vehicles have axle bolts on the front and/or rear drive axle carriers that may not have been assembled correctly. As a result, the remaining bolts may fracture.
Risk: If any of the remaining front or rear axle bolts fracture, the vehicle may be unstable, reducing the handling capability and increasing the risk of a crash.
Fix: MBUSA will notify owners, and dealers will replace the axle carrier bolts, free of charge. The recall is began February 2017. Owners may contact MBUSA customer service at 1-800-367-6372.

Seat beltsJun 16, 2016

Rear/other

Recall 16V442000423 vehicles

Problem: Mercedes-Benz USA, LLC (MBUSA) is recalling certain model year 2015 ML250, ML350, ML350 4Matic, ML400 4Matic, ML63 AMG, and 2016 GLE450 AMG 4Matic vehicles manufactured from April 27, 2015, through May 19, 2015. The affected vehicles may have had the right rear seatbelt anchor bolt incorrectly installed.
Risk: In the event of a vehicle crash, the right rear seatbelt anchor bolt could fail to secure the passenger, increasing their risk of injury.
Fix: MBUSA will notify owners, and dealers will inspect and, if necessary, correct the installation of the right rear seat belt anchor bolt, free of charge. The recall began on July 22, 2016. Owners may contact MBUSA customer service at 1-800-367-6372.

Engine and engine coolingJun 8, 2015

Engine › Diesel

Recall 15V351000814 vehicles

Problem: Mercedes-Benz USA, LLC (Mercedes) is recalling certain model year 2015 E250 BlueTec vehicles manufactured November 3, 2014, to December 15, 2014, E250 BlueTec 4Matic vehicles manufactured November 4, 2014, December 17, 2014, GLK250 vehicles manufactured November 13, 2014, to January 30, 2015, and 2015 ML250 BlueTec vehicles manufactured December 12, 2014, to February 9, 2015. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Risk: Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Fix: Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on June 23, 2015. Owners may contact Mercedes customer service at 1-800-367-6372. Mercedes' number for this recall is 2015050005. Note: This is an expansion of NHTSA recall 14V-762.

Engine and engine coolingDec 1, 2014

Engine › Diesel

Recall 14V7620004,871 vehicles

Problem: Mercedes-Benz USA, LLC (Mercedes) is recalling certain model year 2014-2015 E250 BlueTec, E250 BlueTec 4Matic, GLK250 4Matic BlueTec, and 2015 ML250 4Matic BlueTec vehicles manufactured February 28, 2014, to November 10, 2014. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Risk: Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Fix: Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on December 19, 2014. Owners may contact Mercedes customer service at 1-800-367-6372. Mercedes' number for this recall is 2014120002.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

ML250 Bluetec 4matic Diesel

25mpg combined

City / highway	22 / 29 mpg
Fuel	Diesel

2.1 L · 4 cyl · Automatic 7-spd · 4-Wheel Drive · about $3,850/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
Engine	4	0	0	30,000 mi
Unknown or other	2	0	0	—
Electrical system	1	0	0	—
Fuel/propulsion system	1	0	0	—
Forward collision avoidance	1	0	0	—
VisibilitySun/moon roof assembly	1	0	0	—
Steering	1	1	1	—
Air bags	1	1	1	—
StructureBody	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Structure › Body
Rear subframe rusted from the inside out causing structural failure. This matches the defect in Campaign #2023020002 for other Mercedes models."
Jan 16, 2026
Air bagsCrash1 injury
On 8/15/23 on my parking explode air bag , completely make me blind.Nader air bag push my legs from brake and Car still was driving and stop a the wall, I was completely blind, destroyed my car ,Pain my legs , my arms my head incrediblo,my body is all blue, Thanks to God I am still life. Always I take care my car and I was in Mercedes -Benz dealer in Fletcher N C check my car before I wil drive back home to Florida he told me everything is good and safe .to drive .I need help .All my life I drive Mercedes-Benz .Mercedes mechanic must check car before release to customer to drive ,Please help me with nader car.
Aug 15, 2023
Engine
The Adblue blue malfunctioned and the engine oil cooling is leaking. Also the axle is leaking. This was a previous recall on this specific vehicle and it continues to be an issue
Jun 10, 2022
Unknown or other
SOOTH PARTICULATE SENSOR FAIL, PART OF DIESEL EMISSION SYSTEM. MY CAR HAS 71K MILES AND DEALERSHIP HAD REFUSED TO REPLACE IT UNDER WARRANTY. CANADIAN GOVERNMENT HAS EXTENDED WARRANTY FOR THIS SENSOR UNTIL 120K MILES (ATTACHED)
Feb 1, 2021
SteeringCrash1 injury
TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ ML250. THE CONTACT WAS TOWING AN UNKNOWN TRAVEL TRAILER WHEN THE VEHICLE BEGAN TO DRIFT TO THE RIGHT AND THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED HE WAS UNABLE TO CONTROL THE VEHICLE AND DROVE INTO A DITCH. THE CONTACT STATED ALL 4 AIR BAGS DEPLOYED. THE CONTACT STATED HIS WIFE SUSTAINED A BRUISE FROM THE SEAT BELT BUT DID NOT SEEK ANY MEDICINAL ATTENTION. THE CONTACT STATED THE LOCAL FIRE DEPARTMENT AND TOW COMPANY WAS ABLE TO TAKE THE VEHICLE OUT OF THE DITCH. A POLICE REPORT WAS FILED. THE CONTACT STATED THE VEHICLE WAS DRIVABLE. A DEALER WAS NOT CONTACTED. THE VEHICLE…
Jul 13, 2020 · 78,000 miles
Engine
TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ ML250. THE CONTACT STATED THAT THE ENGINE DEVELOPED A DIESEL FUEL LEAK OVER THE MOTOR, WHICH RAN ACROSS THE ENGINE. THE MOTOR WAS SOAKED WITH DIESEL FUEL. ALSO, WHILE DRIVING, THERE WAS AN ODOR OF FUEL INSIDE THE VEHICLE. THE CONTACT DROVE HOME AND CALLED VALLEY IMPORT (402 40TH ST S, FARGO, ND 58103, (888) 929-9843) TO SCHEDULE AN APPOINTMENT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN FOUND DIESEL FUEL ALL OVER THE ENGINE AND THE PAN UNDER THE ENGINE WAS FILLED WITH FUEL. THE CONTACT STATED THAT THE FUEL SOAKED UP ONE OF THE ENGINE MOUNTS. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE…
Sep 26, 2019 · 30,000 miles
Engine
AT ABOUT 50,000 MILES, NOTICED ENGINE LEAKING OIL EHILR CAR WAS STATIONARY. DIAGNOSED AT DEALERSHIP AS " OIL SEAL" AND REPAIRED. ONLY TO LEAK AGAIN 2 MONTHS LATER. REPLACED AGAIN AT DEALERSHIP. WAS TOLD ITS NOT NORMAL BUT IT CAN HAPPEN.
Dec 18, 2018 · 50,000 miles
Visibility › Sun/moon roof assembly
TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ ML250. ON TWO SEPARATE OCCASIONS, WHILE DRIVING, THE CONTACT HEARD A POP SOUND. LATER THAT NIGHT, THE CONTACT ENTERED THE VEHICLE AND THE MOON ROOF EXPLODED. THE VEHICLE WAS TAKEN TO TYSINGER MOTOR CO (2712 MAGRUDER BLVD SUITE B, HAMPTON, VA 23666, (757) 865-8000) WHERE NO DIAGNOSTIC FAILURE CODES WERE FOUND AND THE FAILURE COULD NOT BE DUPLICATED. THE MOON ROOF WAS REPLACED; HOWEVER, THE CONTACT HEARD THE POP NOISE AGAIN WHILE DRIVING. THE MOON ROOF INADVERTENTLY SHATTERED AGAIN AND ENTERED THE VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MOON ROOF SHATTERED DUE TO TRAUMA. THE VEHICLE WAS…
Dec 11, 2017 · 55,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.