2004 Mercedes-Benz SL600 recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Electrical system

  The safety component that is covered under the SBC warranty is the entire brake master cylinder specifically the part that is bad is the brake pedal position sensor The car is undriveable without it, they have a 25-year warranty on it yet they have no parts and no way to fix it which is obviously unacceptable they've also refused to provide a loaner car until they come up with a way to fix my car leaving me on the side of the road with nothing to drive it's unacceptable! My safety and everybody's safety on the road is affected by this because the car won't stop if you drive it and you have really strong legs you can get it to slow down and eventually stop it's completely unsafe The brake…

  Oct 1, 2025
• Electrical system

  Mercedes SL600 BCM has electrical issues leading to a fire it is available for inspection. The car can burn down in a garage putting me and all others in or near the dwelling at risk. Yes the problem has been confirmed independently. No BCM issues lead to red light on dash.

  Nov 29, 2023
• Fuel system, gasoline › Delivery › Fuel pump

  TL* THE CONTACT OWNS A 2004 MERCEDES BENZ SL600. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 40,100.

  Jun 12, 2014 · 40,000 miles
• Fuel system, gasoline

  KNOCKING NOISE BEGIN TO APPEAR BEHIND THE DRIVER'S SEAT. AT FIRST, BELIEVED TO BE LOOSE ITEM IN THE TRUNK BUT CHECK AND CAN'T FIND. LOOKED AT FORUM AND FOUND THAT MANY 2003/2004 MERCEDES BENZ SL CLASS HAS THE SAME PROBLEM WITH DEFECTIVE GAS TANK BAFFLE. WHENEVER I BRAKE OR ACCELERATE, I HEAR THE KNOCKING NOISE, WHICH ALSO KNOCKS TWO OR THREE TIMES EVERYTIME I BRAKE OR ACCELERATE. IT SOUNDS LIKE SOMETHING IS HANGING FROM A STRING OR FLOATING AND THEN BECAUSE OF INERTIA IT KNOCKS AGAINST THE SIDE OF A CONTAINER. THE HAZARD THAT I FEAR IS THAT THE FLOATING MATERIAL IN THE GAS TANK KNOCKS AGAINST THE TANK AND CREATE A SPARK THAT CAN IGNITE THE TANK CAUSING A FIRE. THE KNOCKING NOISE HAPPENS…

  Jul 6, 2010 · 86,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• AIR SUSPENSION SYSTEM FAILUREClosed

  THE SUBJECT S-CLASS VEHICLES CONTAIN A COMPRESSED AIR SUSPENSION SYSTEM THAT USES AIR STRUTS ON EACH OF THE FOUR WHEELS IN LIEU OF TRADITIONAL SPRINGS AND SHOCK ABSORBERS.THESE AIR STRUTS USE COMPRESSED AIR TO SUPPORT THE WEIGHT OF THE VEHICLE AND CONTROL RIDE HEIGHT.IN THE EVENT OF THE LOSS OF AIR FROM THE SYSTEM, AN ALERT WILL FLASH ON THE INSTRUMENT CLUSTER WARNING THE DRIVER TO EITHER DRIVE CAREFULLY OR TO STOP THE VEHICLE.THE VEHICLE RIDE HEIGHT CAN BE REDUCED BY AS MUCH AS 105 MM BELOW NORMAL RIDE HEIGHT BEFORE THE FULL LOAD OF THE VEHICLE FOR THAT WHEEL COMES TO REST ON A STEEL ROD, WITH A RUBBER STOP ON THE END, LOCATED IN THE SHOCK ABSORBER.THIS REST-STOP CONDITION IS DESIGNED SUCH THAT THERE IS NO IMPACT ON VEHICLE CONTROL.MERCEDES-BENZ (MBUSA) SUPPLIED VIDEO SHOWING A VEHICLE IN THIS CONDITION OPERATING UNDER SEVERAL DIFFERENT SITUATIONS INCLUDING EVASIVE MANEUVERS…

  PE07042 · opened Aug 14, 2007 · closed Nov 20, 2007