Model year record

2016 Mercedes-Benz Sprinter 1500 recalls & problems

The 2016 Mercedes-Benz Sprinter 1500 has 1 safety recall and 1 owner complaint on file with NHTSA. The most-reported problem area is engine (1 complaint).

Recalls1safety recalls

Complaints1filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

SteeringOct 28, 2020

Hydraulic power assist › Hose, piping, and connections

Recall 20V66300047,667 vehicles

Problem: Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Risk: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.
Fix: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine
WHILE DRIVING ON THE ROAD IN CRUISE CONTROL ENGINE JUST SUDDENLY GOES INTO LIMP MODE AND LOSES POWER. IT IS VERY UNSAFE TO PULL OVER THE SIDE OF THE FREEWAY OR WHILE GOING UPHILL. ERROR CODE WAS P0087- LOW FUEL RAIL PRESSURE! AFTER PULLING OVER AND SHUTTING OFF THE VEHICLE AND RE-STARTING IT THEN IT GOES BACK TO NORMAL. NEED TO ADDRESS THIS ISSUE AS IT IS VERY UNSAFE! IT HAPPENED 4X DURING MY TRAVEL OF 8000 MILES
Jun 29, 2021

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Desiccated Air Bag Inflator RuptureOpen
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled…
EA21002 · opened Sep 17, 2021