*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Unknown or other
I recently purchased a used MINI Cooper with incomplete NHTSA Safety Recall 23V-337 involving the Footwell Control Module (FRM). The previous owner did not complete the recall remedy. The vehicle's turn signals and brake lights are currently inoperative. The FRM controls various vehicle lighting functions and is the component involved in Recall 23V-337. Because I purchased the vehicle with these conditions already present, I do not know what warning lamps, messages, or symptoms occurred before the failures. The loss of both turn signals and brake lights creates a significant safety risk because other motorists cannot be properly notified when the vehicle is turning, changing lanes, slowing,…
Aug 28, 2026Electrical systemFire
What happened: Vehicle has experienced failure of the Footwell Control Module (FRM) and associated wiring harness in the driver footwell area, consistent with NHTSA Recall 23V-337. Symptoms: ⢠Exterior lights (headlights / taillights) remain illuminated far longer than normal after vehicle shutoff, sometimes not turning off at all. ⢠Inspection revealed melted wiring, melted connector plugs and receptacles for headlight/taillight circuits. ⢠Water was found in driver side footwell in the past / under carpet padding. Carpet pad is saturated. This is the same failure mode described in Recall 23V-337: "Due to a number of contributing factors, over time, the FRM could become susceptible…
Aug 13, 2026Electrical system
The authorized dealer performed a non-compliant remedy for Safety Recall 23V-337. The initial repair resulted in melted wires and a charred connector due to high resistance. The dealer's subsequent re-repair utilized an un-staggered cluster of approximately 8 inline crimp connectors in a single tight bundle.This directly violates BMW Factory Repair Standard ISTA/AIR 61 13, which explicitly mandates: 'Arrange individual interfaces in an offset manner when repairing multiple cables. The wiring harness thus does not become too thick at the repaired point.' By failing to offset the splices, the dealership created a thick, bunched thermal mass that traps heat and strains the circuits, leaving an…
May 18, 2026Electrical system
The contact owns a 2007 Mini Cooper. The contact stated that while driving at an undisclosed speed, the engine seized. No warning lights were illuminated. The vehicle was towed to the residence. The contact, who was an independent mechanic, researched and diagnosed the failure with water damage to the junction box electronics. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall that had a similar failure description; however, the VIN was not under recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 116,000.
Oct 15, 2025 · 116,000 milesAir bags
The airbag warning light randomly remains on. From what I understand this is a known issue as there has been previous recalls by Mini. This could potentially mean the airbag system is faulty and non-operational. Based on online searches, it seems like a lot of there problem are wiring problems though, bad connections. The previous recalls should be extended further, as there are other cars with the same problem, like mine.
Mar 1, 2025Air bags
On almost all r56 model mini coopers the passenger seat occupancy sensor has a major malfunction that causes it to fail and pop up an airbag sensor light even when someone is sitting in the seat, Mini USA did not issue a recall but rather a reimbursement form for owners in 2017 the last year of production for that car and did not publicly disclose this. I feel as though this should be a recall as it is common enough for bypass devices to be normal for this car
Dec 11, 2024Engine
[XXX]. Mini Cooper 2007-2013: Recalls and TSB. My car is part of a recall under MINI Recall for Timing Chains. I understand now it was settled as part of a class action lawsuit that extended the warranty. I always take my car to a dealer and now after mileage they told me that they want me to pay out of my pocket. My car is a 2007 S. My mileage is 105,000K miles. The recall notice is for the year of my car and they are saying my car is too old and the mileage. This recall is for the year of my car so I am not understanding. Upon inspection by the dealer, it and needs to be replaced and cost $4,100.00. I don't have that kind of money. . My name is [XXX], [XXX]., [XXX], [XXX]. Phone #[XXX].…
Nov 14, 2024Electrical system
The contact owns a 2007 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated the key fob failed to lock and unlock the vehicle, causing the contact to manually lock and unlock the vehicle. The contact also stated that the radio would change stations or power off independently. The vehicle had been taken to an electrician who referred the contact to the dealer. The dealer was contacted. The manufacturer was made aware of the failure. The failure mileage was…
Jul 23, 2023 · 153,000 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.