Model year record

1994 Plymouth Grand Voyager recalls & problems

The 1994 Plymouth Grand Voyager has 4 safety recalls and 198 owner complaints on file with NHTSA. The most-reported problem area is power train (57 complaints).

Recalls4safety recalls

Complaints198filed by owners

Crashes · fires12 · 3reported in complaints

Injuries · deaths17 · 6reported in complaints

Safety recalls

SteeringOct 12, 2000

Steering wheel/handle bar

Recall 00V305000679,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH 2-SPOKE LUXURY WHEELS MANUFACTURED JULY 1992 THROUGH JUNE 1993; OR EQUIPPED WITH 4-SPOKE SPORT WHEELS MANUFACTURED FROM JULY 1992 THROUGH SEPTEMBER 1993. THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Risk: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Fix: DEALERS WILL INSPECT THE STEERING WHEEL FOR CRACKS AND ANY WHEELS WITH CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.

StructureSep 2, 1999

Body › Hatchback/liftgate › Hinge and attachments

Recall 99V2130001,318,189 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Risk: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Fix: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.

Air bagsMay 6, 1999

Air bags

Recall 99V113000736,824 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Risk: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Fix: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.

WheelsDec 14, 1993

Lugs/nuts/bolts/studs

Recall 93V21500090 vehicles

Problem: WHEELS WITH MISFORMED LUG NUT SEATS WERE INSTALLED ON THESE VEHICLES. THIS CAUSES REDUCED NUT TO WHEEL CONTACT AREA AND LIMITS THE WHEEL SELF-CENTERING CAPABILITY DURING INSTALLATION. THIS RESULTS IN LOSS OF WHEEL LUG NUT TORQUE RETENTION.
Risk: LOSS OF LUG NUT TORQUE RETENTION MAY LEAD TO WHEEL LUGFAILURE WHICH MAY CAUSE WHEEL SEPARATION AND AN ACCIDENT.
Fix: INSPECT THE WHEEL ASSEMBLY PLANT CODE; REPLACE WHEELS KNOWN TO HAVE THE PROBLEM AND INSTALL NEW LUG NUTS.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Power trainAutomatic transmission; Axle assembly	57	1	1	0	—
Air bagsFrontal; Frontal › Sensor/control module	26	12	0	15	113,071 mi
StructureBody › Door; Body › Door › Hinge and attachments	26	0	0	3	—
Engine and engine coolingEngine › Gasoline; Engine	18	0	0	0	180,000 mi
VisibilityWindshield; Windshield wiper/washer › Motor	17	0	0	1	—
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Rotor	17	2	0	0	—
EquipmentAppliance › Air conditioner	12	0	0	0	—
Electrical systemIgnition; Wiring › Fuses and circuit breakers	11	0	1	0	—
SteeringLinkages › Tie rod assembly; Hydraulic power assist › Pump	10	0	0	0	—
Latches/locks/linkagesDoors › Latch; Tailgate › Latch	7	0	0	0	—
Seat beltsFront › Anchorage; Front › Buckle assembly	7	1	0	1	—
Unknown or other	7	0	0	3	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Air bags
MY CRUISE CONTROL SYSTEM DOES NOT WORK. I HAVE CHECKED ALL THE FUSES. THEY ARE ALL OK. WHEN CONTACTING SEVERAL MECHANIC AND READING ON-LINE FROM OTHER OWNERS WITH SIMILAR PROBLEM, IT IS COMMONLY REVEALED THAT THE AIR BAG SPRING IN THE STEERING WHEEL MAY HAVE GONE BAD WHICH IS NOT UNCOMMON. THE VEHICLE, OTHERWISE IS OPERABLE. I WONDER IF THIS REVELATION IS TRUE, ARE THERE ANY OTHER SERIOUS RISKS THAT COULD BE ASSOCIATED WITH THIS.
Mar 25, 2016 · 196,000 miles
Visibility › Windshield wiper/washer › Linkages
TL* THE CONTACT OWNS A 1994 PLYMOUTH VOYAGER. THE CONTACT STATED THAT SHE HAD TO REPLACE THE WINDOW SHIELD WIPER MOTOR THREE TIMES IN A ONE YEAR PERIOD. THE CONTACT FOUND NHTSA RECALL CAMPAIGN ID NUMBER: 99V189000 (VISIBILITY: WINDSHIELD WIPER/WASHER LINKAGES), WHICH DEALT WITH THE DRIVER'S SIDE PIVOT ASSEMBLY. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS INFORMED THAT THERE WAS NOTHING THAT COULD BE DONE TO REPAIR THE PROBLEM. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 68,000. UPDATED 8/8/12 *CN UPDATED 08/14/12
Jun 13, 2011 · 68,000 miles
Engine and engine cooling
TL* THE CONTACT OWNS A 1994 PLYMOUTH GRAND VOYAGER. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AS IT OPERATED AS NORMAL. THE FAILURE BEGAN TO RECUR INTERMITTENTLY SO THE VEHICLE WAS TAKEN TO VARIOUS INDEPENDENT REPAIR FACILITIES WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE FUEL PUMP WAS REPLACED BUT THE FAILURE CONTINUED TO RECUR INTERMITTENTLY. THE FAILURE MILEAGE WAS 200,000 AND THE CURRENT MILEAGE WAS UNAVAILABLE.
Apr 1, 2010 · 200,000 miles
Suspension › Rear
VEHICLE HANDLING DEGRADED DUE TO REAR AXLE/BEAM FAILURE. THE HANDLING OF THE MINIVAN WAS SIGNIFICANTLY DIFFERENT. I INSPECTED THE VEHICLE AND NOTICED THE REAR WHEEL HAD A SIGNIFICANT NEGATIVE CAMBER WHEN IT HAS A SOLID REAR AXLE/BEAM. I JACKED THE CAR UP AND INSPECTED THE REAR / AXLE AND BEAM AND SAW A NEAR COMPLETE RUST THROUGH OF THE REAR AXLE/BEAM. THE RUST RESULTED IN THE REAR AXLE BENDING UPWARDS NEAR THE RIGHT REAR WHEEL CASTING/HUB. THIS IN TURN YIELDED THE NEGATIVE CAMBER. THE FAILURE WAS CAUGHT PRIOR TO OCCURRING WHILE AT NORMAL SPEEDS (55 MPH). THERE IS NO QUESTION THAT IF THIS HAD FAILED AT 55 MPH IT WOULD HAVE RESULTED IN COMPLETE LOSS OF CONTROL. THE DRIVERS SIDE REAR WHEEL…
Apr 20, 2009 · 133,900 miles
Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe
TL*THE CONTACT OWNS A 1994 PLYMOUTH GRAND VOYAGER. THE CONTACT IS EXPERIENCING A LEAK IN THE FUEL SYSTEM NEXT TO THE EXHAUST MANIFOLD. HE TOOK HIS VEHICLE TO THE LOCAL DEALER AND WAS INFORMED THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V268000 (FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM). THEY REPLACED THE FUEL RAIL, BUT WOULD NOT REPAIR IT WITH A FREE SERVICE CHARGE. THE CURRENT AND FAILURE MILEAGES WERE 180,000.
Oct 26, 2007 · 180,000 miles
Suspension › Rear › Axle › Spindle
TL*THE CONTACT OWNS A 1994 PLYMOUTH GRAND VOYAGER. WHILE DRIVING 4 MPH, THE REAR DRIVER SIDE AXLE SNAPPED. THE VEHICLE SHOOK VIOLENTLY AND THE CONTACT HEARD A SQUEALING NOISE RIGHT BEFORE THE FAILURE OCCURRED. THIS IS THE FOURTH TIME THAT THE AXLE HAS BEEN TOWED AND REPAIRED. THE CURRENT MILEAGE IS 115,000 AND FAILURE MILEAGE WAS 110,000.
Apr 1, 2007 · 110,000 miles
Structure › Body › Door › Hinge and attachments
FATIGUE CRACKING OF THE DRIVER'S SIDE DOOR HINGE PILLAR AROUND THE HINGE. THE CRACK HAS PROGRESSED ROUGHLY 50% OF THE WAY AROUND THE HINGE AND WILL LEAD TO COMPLETE SEPARATION OF THE HINGE FROM THE PILLAR WITHOUT REPAIR. THIS CAR HAS HAD NO ACCIDENTS. THE INCIDENT DATE IS THE APPROXIMATE DATE THE CRACK WAS FIRST DETECTED. *JB
Jun 1, 2006 · 200,000 miles
Visibility › Windshield wiper/washer › Linkages
NHTS CAMPAIGN 99V189000 CONCERNS A FAILURE OF WINDSHIELD WIPER LINKAGES ON 1993 PLYMOUTH VOYAGERS LEADING TO TOTAL LOSS OF WIPER FUNCTION. THIS HAPPENED TO MY DAUGHTER TODAY DURING A STORM, FORCING HER TO RETURN HOME VERY SLOWLY. NO ACCIDENT, NO ONE HURT. (NOTE THAT I AM A REGISTERED PROFESSIONAL ENGINEER.) UPON HER RETURN, I INSPECTED AND FOUND THAT: 1. THE WIPER MOTOR WAS RUNNING AND COULD BE AUDIBLY HEARD WHILE THE WIPERS SAT MOTIONLESS. 2. THE TWO WIPERS WERE LINKED TOGETHER AND COULD BE MOVED EASILY BY HAND. 3. THE RUNNING WIPER MOTOR WOULD NOT MOVE THE WIPERS. AT THAT POINT I REMOVED THE 3 BOLTS HOLDING THE WIPER MOTOR IN PLACE AND LOOKED INSIDE THE WIPER ARM CAVITY. I FOUND WIPER…
Oct 15, 2006 · 140,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

STEERING COLUMN SEPARATIONClosed
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR…
DP03002 · opened May 7, 2003 · closed Jul 22, 2003
STEERING WHEEL SEPARATIONClosedLed to recall 00V305000
There is no summary currently available
RQ00011 · opened May 1, 2000 · closed Apr 1, 2002
AIR BAG CIRCUIT/WINDSHIELD WIPER MOTORClosed
There is no summary currently available
PE97049 · opened Nov 18, 1997 · closed Mar 17, 1998
SAFETY BLT LATCH OPERATIONClosed
There is no summary currently available
PE96008 · opened Jan 25, 1996 · closed Jun 28, 1996
LIFTGATE LATCHESClosed
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER…
EA94005 · opened Jan 31, 1994 · closed Oct 25, 1995