Model year record

2000 Pontiac Grand Prix recalls & problems

The 2000 Pontiac Grand Prix has 9 safety recalls and 461 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (156 complaints).

Recalls9safety recalls

Complaints461filed by owners

Crashes · fires10 · 162reported in complaints

Injuries · deaths9 · 0reported in complaints

Safety recalls

Engine and engine coolingOct 26, 2015

Exhaust system › Manifold/header/muffler/tail pipe

Recall 15V7010001,003,556 vehicles

Problem: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Risk: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Fix: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engineÂs front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Components: Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe; Engine and engine cooling › Engine

Exterior lightingMay 11, 2009

Headlights

Recall 09E02500042,540 vehiclesopened after NHTSA action (OVSC)

Problem: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Fix: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Engine and engine coolingApr 8, 2009

Engine and engine cooling

Recall 09V1160001,497,516 vehiclesopened after NHTSA action (ODI)

Problem: GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Risk: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Fix: DEALERS WILL REPLACE THE ENGINEÂS FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂS PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

Exterior lightingApr 7, 2009

Exterior lighting

Recall 09E01200016,270 vehiclesopened after NHTSA action (OVSC)

Problem: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

SteeringFeb 17, 2009

Steering

Recall 09E005000979 vehicles

Problem: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Fix: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Engine and engine coolingMar 12, 2008

Engine and engine cooling

Recall 08V118000207,542 vehiclesopened after NHTSA action (ODI)

Problem: GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Risk: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Fix: DEALERS WILL REPLACE THE ENGINEÂS FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂS PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Fuel system, otherMar 12, 2007

Storage › Tank assembly › Pressure relief devices

Recall 07E021000742 vehicles

Problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Seat beltsAug 7, 2000

Seat belts

Recall 00V228003156,305 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Fix: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

Air bagsOct 21, 1999

Frontal

Recall 99V283000111 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE PASSENGER SIDE AIR BAG MODULES HAVE AN UNDERSIZED INFLATOR ORIFICE.
Risk: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER SIDE AIR BAG DEPLOYMENT, THIS UNDERSIZED ORIFICE CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF AN AIR BAG INFLATOR MODULE EXPLODES, METAL AND/OR PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO THE VEHICLE OCCUPANT.
Fix: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG MODULES.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

Grand Prix

21mpg combined

City / highway	18 / 27 mpg
Fuel	Regular Gasoline

3.1 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel

Grand Prix

21mpg combined

City / highway	17 / 27 mpg
Fuel	Regular Gasoline

3.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel

Grand Prix

19mpg combined

City / highway	16 / 25 mpg
Fuel	Premium Gasoline

3.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $4,350/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingEngine; Engine › Gasoline	156	0	89	0	91,730 mi
Engine	73	0	45	0	170,000 mi
Electrical systemIgnition; Wiring › Front underhood	66	0	25	1	110,500 mi
Power trainAutomatic transmission; Driveline › Differential unit	44	0	2	0	63,000 mi
SteeringRack and pinion; Hydraulic power assist system	36	1	0	1	54,000 mi
Exterior lightingHeadlights; Brake lights	28	0	0	0	60,674 mi
VisibilityPower window devices and controls; Windshield wiper/washer	25	0	0	0	64,500 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Caliper	24	0	2	0	38,500 mi
Fuel system, gasolineDelivery › Fuel pump; Fuel injection system	22	0	7	0	90,000 mi
SuspensionFront; Front › Wheel bearing	17	0	0	0	70,000 mi
StructureBody › Door; Body › Trunk lid	15	1	2	0	30,000 mi
Unknown or other	13	0	5	0	127,761 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine
The contact owns a 2000 Pontiac Grand Prix. The contact stated that the vehicle was towed to the dealer for service under NHTSA Campaign Number: 15V701000 (Engine and Engine Cooling) however after the service the vehicle started but did not idle due to an air intake hose not reinstalled on the vehicle. The contact stated that the air intake hose needs to be replaced however, the repairs have not been completed. The contact stated that before taking the vehicle into service the manufacturer was made aware of an issue with the dealer due to his interaction with the service manager. He was worried that the dealer was not going to service his vehicle correctly. The contact did not have a case…
Dec 22, 2022 · 159,000 miles
EngineFire
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. THE CONTACT STATED THAT AFTER DRIVING AND PARKING THE VEHICLE, FLAMES WERE PRESENT COMING FROM UNDER THE VEHICLE. THE FLAMES WERE EXTINGUISHED BY THE OWNER. NO INJURIES WERE REPORTED. NO FIRE REPORT WAS TAKEN REGARDING THE INCIDENT. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER AND MANUFACTURER WERE NOT YET NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.
Nov 5, 2020 · 200,000 miles
Power train
TRANSMISSION FAILURE AT 180K MILES. CAR WILL NOT SHIFT ON IT OWN I HAVE TO FORCE CAR INTO GEAR BY SPEEDING UP HEARING TRANSMISSION WHINE AND THEN LETTING OFF THE GAS PEDAL SO TRANSMISSION SHIFTS GEARS. THIS IS ON ALL ROAD CONDITIONS. SO MANY COMPLAINTS HAVE BEEN MADE WHY HAS GM NOT ISSUED A RECALL ON THIS MATTER.
Jul 2, 2020 · 180,000 miles
Engine
I TOOK MY PONTIAC GTP TO BURLINGAME PUTNAM IN CA BECAUSE I CHECKED ON HERE NHTSA IF I HAD A RECALL AND I DID WHICH WAS FIRE WALL COMPARTMENT RECALL SO WHEN I WENT TO THE DEALER AND HAD MY CAR SERVICED I PICKED IT UP AND ONCE I GOT HOME I NOTICED ONE VALVE COVER WAS REPLACED WHICH WAS ONLY ONE VALVE COVER FACING THE FRONT OF THE CAR! THE VALVE COVER FACING THE REAR TOWARDS THE FIRE WALL WAS STILL THE OLD VALVE COVER! AND IS STILL LEAKING OIL WHICH IM AFRAID MIGHT TAKE OUT MY ENGINE IF IT BLOWS THE HEAD GASKET COMPLETELY AND CAUSE A FIRE,CAN EVEN CAUSE A MAJOR ACCIDENT! PLEASE HELP. TECHNICIANS SHOULD DO A COMPLETE SERVICE NOT JUST HALF OF THE JOB AND BE LAZY TO NOT EVEN REPLACE THE REAR…
Jan 2, 2020
Engine
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE CONTACT CALLED MAUER BUICK GMC (1111 50TH ST, INVER GROVE HEIGHTS, MN 55077) AND A DIAGNOSTIC TEST WAS RECOMMENDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V116000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000. PARTS DISTRIBUTION DISCONNECT.
Jul 20, 2019 · 200,000 miles
Engine
EXCESSIVE OIL LEAK FROM THE TOP OF THE ENGINE. VALVE COVER GASKETS AND INTAKE GASKETS LEAKING OIL DIRECTLY ON TO THE MANIFOLD I SMELL IT BURNING EVERY TIME I DRIVE IT AND THERE IS A VISABLE PUDDLE OF OIL ON THE TOP OF THE ENGINE
Oct 1, 2018 · 223,209 miles
Vehicle speed control › Accelerator pedal
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. WHILE DRIVING UNKNOWN SPEEDS, THE ACCELERATOR PEDAL FAILED TO DEPRESS OR RELEASE WHEN THE OUTSIDE TEMPERATURE WAS HIGH. ADDITIONALLY, THE REVOLUTIONS PER MINUTE INCREASED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 150,000. *TT *TR
Jul 1, 2014 · 150,000 miles
Engine
A WHILE BACK THERE WAS A RECALL ON THE PONTIAC GRAND PRIX YEARS 2000 - 2004 IF IM NOT MISTAKEN DUE TO OIL LEAK CAUSING AN ENGINE FIRE. I JUST BOUGHT THIS CAR FROM A PRIVATE OWNER AND WAS WONDERING IF THIS WAS THE PROBLEM. IT SEEMS THAT WHEN I PUT OIL IN IT IS DOES LEAK ON TO THE GROUND BUT WITH HOW MUCH OIL I PUT IT IN ALREADY DOESNT EXPLAIN WHERE THE REST OF IT WENT, ID SAY ABOUT 5 QUARTS IN A DAY. I JUST DONT WANT TO BE DRIVING AND SUDDENLY HAVE THE ENGINE CATCH FIRE IF THIS IS THE PROBLEM.
Feb 28, 2018 · 150,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

ENGINE COMPARTMENT FIREClosedLed to recall 08V118000
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS…
EA07008 · opened Jun 12, 2007 · closed May 1, 2008
ENGINE COMPARTMENT FIREClosed
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS…
PE07006 · opened Jan 29, 2007 · closed Jun 12, 2007
LOSS OF BRAKE LAMP ILLUMINATIONClosed
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF…
PE07001 · opened Jan 17, 2007 · closed Apr 30, 2007
ENGINE COMPARTMENT FIRESClosedLed to recall 04V090000
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02030 · opened Oct 22, 2002 · closed Mar 9, 2004
ENGINE COMPARTMENT FIRESClosed
PE02050 · opened Jun 13, 2002 · closed Oct 22, 2002
AIR BAG INFLATORClosedLed to recall 02V027001
EA01014 · opened Jun 11, 2001 · closed Aug 26, 2002
ACCELERATOR CABLE DETACHES FROM THROTTLEClosed
There is no summary currently available
SQ00004 · opened Feb 2, 2000 · closed Jan 19, 2001