2002 Porsche 911 recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Engine

  ALUMINUM COOLANT TUBES WHICH APPARENTLY ARE GLUED TOGETHER VIA THE OEM FACTORY BECOME OLD AND BRITTLE AND BLOW APART. COOLANT IS THEN POURING OUT OF THE ENGINE AT A HIGH RATE INTO THE CITY STREET. IN MY CASE, I WAS SITTING AT A RED TRAFFIC LIGHT WHEN THE COOLANT PIPE BURST/SEPARATED. IN ORDER TO FIX/REPAIR THE ISSUE, THE ENGINE MUST BE REMOVED FROM THE VEHICLE AND THE 8 COOLANT TUBES MUST BE WELDED AND/OR DRILLED AND PINNED TO KEEP THE ISSUE FROM HAPPENING AGAIN

  Nov 22, 2016 · 72,135 miles
• Power train

  THE CLUTCH SLAVE FAILED ON MY 911 TURBO AND HAD TO BE REPLACED WITH A GT2 SLAVE WHICH REMOVES THE HYDRAULIC ASSIST. *TR

  Mar 21, 2015 · 52,400 miles
• Engine

  I NOTICED STEAM COMING FROM THE ENGINE BAY WHILE DRIVING IN A RESIDENTIAL AREA. STOPPED THE CAR IMMEDIATELY AND CONTACTED A TOW SERVICE. A COOLANT LINE CAME LOOSE DUE TO A FAILED FITTING AT THE MANIFOLD AND DISCHARGED THE ENTIRE RESERVOIR, LEAVING A PUDDLE OF COOLANT UNDERNEATH THE VEHICLE. *TR

  Feb 8, 2015
• Engine

  THERE WAS NO INCIDENT, BUT THERE IS A COOLANT SMELL WHICH REGULARLY HAPPENS AFTER A LONG DRIVE. MY MECHANIC TOLD ME THAT THIS IS BECAUSE THE COOLANT FITTINGS WEEP; I'VE FOUND MANY FORUM POSTS, AND WAS TOLD BY MY MECHANIC THAT THE LINES BURSTING AND/OR SPILLING IS COMMON IN 996 TURBOS ('01-'05). HE ADVISED ME THAT I SHOULD HAVE PREVENTIVE WELDS TO MAKE SURE THAT THE COOLANT LINES DO NOT UNSEAT AND SPILL ALL OF MY COOLANT. I WAS TOLD THAT IT COULD HAPPEN TOMORROW, OR COULD HAPPEN 50K MILES FROM NOW; EITHER WAY, I WOULD BE STRANDED WHEREVER I WAS. THE WORK TO COMPLETE THE PREVENTIVE MEASURE WAS QUOTED AROUND $5-6K, BUT I HAVE NOT HAD IT COMPLETED. *TR

  Apr 25, 2013 · 39,000 miles
• Engine

  I OWN A 2002 911 CARRERA TURBO, WHICH HAS A WELL-KNOW AND DOCUMENTED DESIGN DEFECT IN THE ENGINE (GT1 MOTOR). IT IS KNOW AS THE COOLANT-PIPE FAILURE ISSUE. WHILE MY CAR HAS NOT YET SUFFERED A FAILURE, THERE IS A REASONABLE PROBABILITY THAT THE COOLANT PIPES MAY FAIL DURING REGULAR USE, CAUSING A SUBSTANTIAL LIKELIHOOD OF PROPERTY DAMAGE AND PERSONAL INJURY TO MYSELF AND OTHERS UTILIZING THE PUBLIC RIGHT-OF-WAY. IT IS A CLEAR SAFETY ISSUE THAT MUST BE ADDRESSED BY WAY OF RECALL AND REPAIR. THERE IS A KNOWN SOLUTION TO THE PROBLEM. HERE IS A HYPERLINK TO ONE OF THE SOURCES OF INFORMATION FOR THIS ISSUE.…

  May 1, 2013 · 60,300 miles
• Engine

  INTERMEDIATE SHAFT FAILURE. *TR

  Oct 18, 2012 · 48,000 miles
• Engine

  INTERMEDIATE SHAFT BEARING FAILED, CAUSING CATASTROPHIC ENGINE FAILURE AND LOSS OF ALL ENGINE OIL ON THE ROADWAY. LUCKILY, THE CAR WAS STOPPED AT THE TIME. *TR

  Jun 10, 2012 · 85,200 miles
• Engine and engine cooling › Engine

  WHILE TRAVELING AT 45 MPH THERE WAS A LOUD RUMBLING NOISE COMING FROM THE REAR OF VEHICLE, THE VEHICLE STARTED TO MISFIRE. THE CONSUMER PULLED OVER AND NOTICED THAT ALL THE OIL HAD LEAKED OUT OF VEHICLE. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, WHO STATED A BEARING HAD BROKE AND THE ENGINE NEEDED TO BE REPLACED. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB

  Mar 1, 2005

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• Rapid coolant lossClosed

  On April 26, 2013, the Office of Defects Investigation (ODI) opened PE13-009 to investigate 10 complaints alleging incidents of sudden coolant loss while traveling on public roadways in certain model year (MY) 2001 through 2007 Porsche 911 vehicles.The complaints alleged that pipe ends joined by epoxy to certain cooling system components may fail suddenly and separate, resulting in large volumes of coolant leakage.The investigation was opened to assess evidence of a design or manufacturing defect in the coolant pipe fittings and any related safety consequences. In response to ODI?s Information Request letter, Porsche identified a manufacturing quality issue with the supplier?s application of adhesive to coolant pipe fittings that resulted in elevated failure rates in approximately 6,800 early production 997 generation vehicles (MY 2007 and early MY 2008).ODI?s analysis of field data…

  PE13009 · opened Apr 26, 2013 · closed Mar 10, 2014