Model year record

2007 Saturn Outlook recalls & problems

The 2007 Saturn Outlook has 5 safety recalls and 511 owner complaints on file with NHTSA. The most-reported problem area is exterior lighting (154 complaints).

Recalls5safety recalls

Complaints511filed by owners

Crashes · fires5 · 10reported in complaints

Injuries · deaths8 · 0reported in complaints

2007 Saturn Outlook in an NHTSA crash test — NHTSA crash test

Safety recalls

StructureJun 30, 2015

Body › Hatchback/liftgate

Recall 15V415000691,144 vehicles

Problem: General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Risk: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Fix: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.

Electrical systemJun 4, 2010

Electrical system

Recall 10V2400001,365,070 vehicles

Problem: GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Risk: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Fix: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Electrical systemAug 28, 2008

Electrical system

Recall 08V441000857,735 vehiclesopened after NHTSA action (ODI)

Problem: GM IS RECALLING 857,735 MY 2006-2008 BUICK LUCERNE; CADILLAC DTS; HUMMER H2; MY 2007-2008 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL, SATURN OUTLOOK; AND MY 2008 BUICK ENCLAVE VEHICLES EQUIPPED WITH A HEATED WIPER WASHER FLUID SYSTEM. A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WASHER FLUID HEATER MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE.
Risk: THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR, OR CAUSE SMOKE INCREASING THE RISK OF A FIRE.
Fix: DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 12, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CADILLAC AT 1-800-982-2339 OR HTTP://WWW.CADILLAC.COM; CHEVROLET AT 1-800-630-2438; SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM, GMC AT 1-866-996-9436; OR HUMMER AT 1-800-732-5493; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

VisibilityAug 14, 2008

Windshield wiper/washer › Linkages

Recall 08V41000088,809 vehicles

Problem: GM IS RECALLING 88,809 MY 2008 BUICK ENCLAVE, AND MY 2007-2008 GMC ACADIA AND SATURN OUTLOOK VEHICLES CURRENTLY OR PREVIOUSLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IF A BUILDUP OF SNOW OR ICE ON THE WINDSHIELD OR ON THE WIPERS RESTRICTS THE MOVEMENT OF THE WIPER ARM, THE WINDSHIELD WIPER LINKAGE MAY BECOME DETACHED FROM THE MOTOR SHAFT AND THE WIPERS MAY BECOME INOPERATIVE.
Risk: IF THIS WERE TO OCCUR, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Fix: DEALERS WILL INSTALL A NEW WIPER CRANK ARM, DRIVER'S SIDE LINK, AND A CRANK ARM NUT. THE RECALL BEGAN O OCTOBER 13, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, SATURN AT 1-800-972-8876, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Air bagsFeb 21, 2007

Frontal › Sensor/control module-inactive

Recall 07V06200013,032 vehicles

Problem: ON CERTAIN VEHICLES, THE SENSING AND DIAGNOSTIC MODULE (SDM), WHICH CONTROLS THE FUNCTION OF FRONT AIR BAGS, MAY NOT OPERATE PROPERLY. AS A RESULT, THE FRONT AIR BAGS MAY FAIL TO DEPLOY IN A FRONTAL CRASH. ALSO, THE AIR BAG WARNING LAMP ON THE INSTRUMENT PANEL MAY FAIL TO PROVIDE WARNING THAT THE SYSTEM IS INOPERATIVE.
Risk: IN THE EVENT OF A CRASH, THIS CONDITION COULD INCREASE THE RISK OF INJURY TO OCCUPANTS IN THE FRONT SEAT.
Fix: DEALERS WILL REPROGRAM THE SDM COMPUTER MODULE. THIS RECALL BEGAN ON FEBRUARY 22, 2007. OWNERS MAY CONTACT GMC AT 1-866-966-9463 OR SATURN AT 1-800-972-8876.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2007 Saturn Outlook 4-DR. w/SAB

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	★★★★★
Rollover risk	15.5%

2007 Saturn Outlook NHTSA side crash test — NHTSA side barrier crash test

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Outlook FWD

19mpg combined

City / highway	16 / 24 mpg
Fuel	Regular Gasoline

3.6 L · 6 cyl · Automatic 6-spd · Front-Wheel Drive · about $3,550/year to fuel

Outlook AWD

18mpg combined

City / highway	16 / 22 mpg
Fuel	Regular Gasoline

3.6 L · 6 cyl · Automatic 6-spd · 4-Wheel or All-Wheel Drive · about $3,700/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Exterior lightingHeadlights	154	0	5	2	60,400 mi
Power trainAutomatic transmission; Automatic transmission › Lever and linkage › Floor shift	128	2	2	0	78,900 mi
Electrical systemInstrument cluster/panel; Wiring	115	0	3	1	60,800 mi
Air bagsFrontal; Frontal › Sensor/control module	88	3	0	7	80,589 mi
SteeringHydraulic power assist › Hose, piping, and connections; Column	60	1	0	1	59,000 mi
StructureBody	36	0	0	1	80,000 mi
Engine	27	0	2	0	117,733 mi
Electronic stability control (esc)	21	0	1	3	114,770 mi
Unknown or other	20	0	0	0	109,000 mi
VisibilitySun/moon roof assembly; Rear window wiper/washer	16	0	1	0	60,000 mi
Vehicle speed control	12	0	0	0	76,500 mi
SeatsMid/rear assembly	9	1	0	1	93,000 mi

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Exterior lighting
Passenger headlight dim. Grand Street Batteey and Electric replaced bulb and states voltage to connector is good.the vehicle is available for inspection. Headlight is not bright enough to utilize at night as it should be for owner or traffic. No warning lamps light up on instrument panel.
Apr 15, 2025
Air bags1 injury
The contact owns a 2007 Saturn Outlook. The contact stated that the air bag, the traction control, and the electronic stability control warning lights were illuminated. The contact stated that after opening the liftgate with the power liftgate button, the liftgate unexpectedly lowered, and struck her on the head. The contact stated that the failure had occurred twice. The contact had head pain, but medical assistance was not required. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failures to NHTSA Campaign Numbers: 07V062000 (Air Bags) and 15V415000 (Structure); however, the VIN was not included. The manufacturer was notified of the…
Nov 1, 2024 · 163,000 miles
Electrical system
When it's cold I get frost inside my vehicle I replaced my windshield because I thought air was getting inside to cause the frost but after getting it replaced same issue water is leaking in and causing moisture and causing my vehicle not wanting to start because it's doing something to the battery
Jan 20, 2024
Electrical system
I HAVE A WIRE THAT BURNED-OUT AND IT CONTROLS MY WINDOWS, SUNROOF,MY AC CONTROLS, AND THEN ALSO MY TRANSMISSION IS SHUTERING
Feb 17, 2022
Steering
While driving, the car will automatically shift into 1st gear. Steering will then be disabled to the point of crash. Transmission/computer issue. Major issue with Saturn Outlooks.
Jun 23, 2022
Power train
I just purchased this vehicle & on my way home with it the check engine light came on. I hooked up the diagnostic code scanner on the car and it threw several different codes PO700, PO752, PO420. There are specific transmission issues with this particular year, make, and model. My car has the exact same symptoms as the others that were recalled so why has mine not been recalled as well? It's malfunctioning just as the others described in the recall so clearly this is a common issue with these particular vehicles. I feel my car should be covered as part of the safety recall on the transmission and I need it repaired as soon as possible.
Jan 1, 2022
Electronic stability control (esc)
WATER IS LEAKING INTO THE VEHICLE CAUSE ELECTRICAL MALFUNCTIONING. WATER IS COLLECTING INTO THE BATTERY COMPARTMENT. ELECTRICAL PROBLEMS CAUSED BY WATER INCLUDE RADIO, LIGHTS; DASHBOARD( SHUTS OFF FOR A FEW SECONDS THEN COMES BACK ON) AND INTERIOR, DOOR LOCKS, STABILITY TRACK MALFUNCTION AT WHICH POINT THE CAR WILL SHAKE AND SHUT ITSELF OFF WHILE BEING DRIVEN ABOVE 40 MPH.
Jun 15, 2019 · 200,000 miles
Power train
THE VEHICLES AUTOMATIC TRANSMISSION WAS NOT SHIFTING APPROPRIATELY WITH FLUCTUATING CHANGES OF SPEEDS, THEN THE CAR WOULD NOT MAINTAIN A SAFE SPEED TO EXIT THE FREEWAY. AFTER PARKING I CALLED A TOW TRUCK AND HAD IT DELIVERED TO THE CLOSEST DEALER WHERE THEY HAD PUT IN A REBUILT TRANSMISSION WHEN THE VEHICLE HAD 90,223 MILES BACK IN 2013. NOW, LESS THAN 50,000 MILES LATER THE DEALERSHIP IS TELLING ME THE VEHICLE NEEDS ANOTHER TRANSMISSION AT THE COST OF $5,500. IF A VEHICLE ONLY GETS 50,000 MILES OUT OF A TRANSMISSION SOMETHINGS NOT RIGHT! I HAVE MY RECEIPTS FROM THE FIRST TRANSMISSION THAT CLEARLY INDICATE THE MILEAGE.
Jul 27, 2020 · 145,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Loss of Headlamp IlluminationClosed
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp…
DP12003 · opened Jun 4, 2012 · closed Jul 24, 2014
NON-CRASH ENGINE COMPARTMENT FIRESClosedLed to recall 08V441000
IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441:…
EA08010 · opened Jun 12, 2008 · closed Sep 8, 2008