Model year record

2014 Suzuki DL1000 recalls & problems

The 2014 Suzuki DL1000 has 3 safety recalls and 8 owner complaints on file with NHTSA. The most-reported problem area is fuel/propulsion system (4 complaints).

Recalls3safety recalls

Complaints8filed by owners

Crashes · fires0 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Electrical systemDec 18, 2015

Ignition

Recall 15V8540002,404 vehicles

Problem: Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 DL1000 motorcycles manufactured January 17, 2014, to June 5, 2014, and 2015 DL1000 motorcycles manufactured November 5, 2014, to February 6, 2015. The ignition switch terminals of the affected vehicles may corrode if they come into contact with liquid such as salt water. As a result, the motorcycle's electrical power may be disconnected or the switch may be bypassed, preventing the engine from being shut off with the ignition key.
Risk: If electrical power is lost, the engine would stall, increasing the risk of a crash.
Fix: Suzuki will notify owners, and dealers will install a cover for the ignition switch connector, and any corroded ignition lead wire and wire harnesses will be replaced. These repairs will be performed free of charge. The recall began January 19, 2016. Owners may contact Suzuki customer service at 1-714-996-7040. Suzuki's number for this recall is 2A53.

Electrical systemDec 18, 2015

Wiring

Recall 15V8510002,410 vehicles

Problem: Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 Suzuki DL 1000 motorcycles manufactured January 17, 2014, to June 5, 2014, 2015 Suzuki DL1000 motorcycles manufactured November 4, 2014, to February 6, 2015 and 2016 Suzuki DL1000 motorcycles manufactured June 11, 2015, to July 15, 2015. The affected motorcycles have a wiring harness that may rub against the bottom of the fuel tank. Vibration from riding may cause the wiring insulation to wear off, allowing a bare wire to short circuit against the fuel tank.
Risk: A short circuit may cause the engine to stall, increasing the risk of a crash.
Fix: Suzuki will notify owners, and dealers will inspect the motorcycles and reroute the wiring harnesses as necessary. Any damaged harnesses will be repaired or replaced. This work will be performed free of charge. The recall began on January 29, 2016. Owners may contact Suzuki customer service number at 1-714-572-1490. Suzuki's number for this recall is 2A53.

Electrical systemDec 18, 2015

12v/24v/48v battery › Cables

Recall 15V8530002,404 vehicles

Problem: Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 Suzuki DL1000 motorcycles manufactured January 17, 2014 to June 5, 2014, and 2015 Suzuki DL1000 motorcycles manufactured November 5, 2014, to February 6, 2015. Due to corrosion or being attached to the painted engine case, the battery ground connection may have poor electrical conductivity.
Risk: As a result of the poor conductivity, the engine may stall and be unable to be restarted, increasing the risk of a crash.
Fix: Suzuki will notify owners, and dealers will relocate the battery ground connection to an unpainted surface and replace the ground wire protector with a high-heat resistance tube, free of charge. The recall began on January 29, 2016. Owners may contact Suzuki customer service number at 1-714-996-7040. Suzuki's number for this recall is 2A53.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Typical mileage*
Fuel/propulsion system	4	1,300 mi
Engine	3	600 mi
Electrical system	2	—
Power train	2	—
Unknown or other	2	—
Vehicle speed control	1	—
Fuel system, gasoline	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel system, gasoline
2014 SUZUKI DL1000. CONSUMER WRITES IN REGARDS TO MOTORCYCLE ECU UNIT WHICH INCLUDES FUELING ISSUES THAT CAUSES LOW RPM THROTTLE CONTROLS/ RESPONSE AND STALLING VIBRATIONS AND NOISES. *M *JS
Mar 1, 2016
Fuel/propulsion system
THE MOTORCYCLE WILL STALL AT ODD INTERVALS. IT WILL ALSO BACKFIRE THRU THE AIRBOX. AT LOW SPEED, IT IS DIFFICULT TO CONTROL THE THROTTLE. IT IS ESPECIALLY BAD WHEN THE ENGINE HASN'T WARMED UP FULLY AND ITS COLD OUTSIDE. I HAVE COME VERY CLOSE TO DROPPING THE BIKE WHEN IT STALLS UNEXPECTEDLY. IT HAS STALLED SEVERAL TIMES AFTER ACCELERATING FROM A STOP. IT HAS ALSO STALLED SEVERAL TIMES WHEN HOT AND SLOWING DOWN ON THE HIGHWAY.
Mar 25, 2017 · 12,000 miles
Fuel/propulsion system
ENGINE WOULD CUT OFF RANDOMLY, APPROXIMATELY ONCE EVERY 300 OR 400 MILES OF RIDING. ALWAYS WOULD START RIGHT BACK UP. ONLY HAPPENED TO ME WHILE NOT MOVING, BUT PROBABLY WOULDN'T NOTICE PROBLEM IF MOVING, UNLESS UNDER LOW POWER OR SLIPPING THE CLUTCH, IE, LOW SPEED MANEUVERING. SOMETIMES COLD ENGINE, SOMETIMES FULLY WARMED UP. SUZUKI REPLACED ECU (WITH PART # ENDING IN ...J12) UNDER WARRANTY TO CORRECT THE PROBLEM. HAVE NOT HAD THAT PROBLEM SINCE, BUT NOW WHEN ENGINE IS WARMING UP AND DRIVING AWAY, ENGINE WILL "PUFF" WITH A BRIEF LOSS OF POWER, USUALLY WHILE TURNING OUT ONTO THE STREET. DOES NOT HAPPEN IF FULLY WARMED UP. *TR
May 7, 2016 · 500 miles
Engine
EVER SINCE THIS VEHICLE WAS PURCHASED AND THEN AFTER THE FIRST OIL CHANGE THE MOTOR DEVELOPED A KNOCK. THE FUELING IS ERRATIC AT TIMES MEANING IT HICCUPS OR SURGES AND HAS STALLED WHILE IN MOTION. I BROUGHT THIS UP TO THE DEALER AND TO SUZUKI IN NOVEMBER OF 2015. I ALSO FOUND ON A SUZUKI FORUM DEDICATED TO THIS PARTICULAR MODEL THAT OTHERS WERE EXPERIENCING THE SAME ISSUES. I TOOK THE BIKE TO THE DEALER AND NOTHING WAS REMEDIED. I SPOKE WITH SUZUKI CORPORATE AND THEY ACKNOWLEDGED THAT SOME MODELS WERE EXPERIENCING A KNOCK DUE TO AN INTOLERANCE BUT THAT IT WOULDN'T AFFECT RELIABILITY. WHEN ASKED TO PUT IT IN WRITING THEY ACTUALLY SAID YES BUT THEN NEVER FOLLOWED THROUGH AND WOULDN'T RETURN…
Nov 6, 2016 · 600 miles
Electrical system
VEHICLE IS A NOS 2014 LEFTOVER PURCHASED IN NOVEMBER 2016. VEHICLE NOW HAS 2,500 MILES ON IT AND HAS INTERMITTENTLY STALLED UPON TAKEOFF IN 1ST GEAR AT LEAST 7 TIMES. EACH TIME THE MOTORCYCLE ENGINE IS WARM. UPON ENGAGING 1ST GEAR FROM A STOP, WHEN THE CLUTCH IS RELEASED AND THROTTLE APPLIED, THE MOTORCYCLE WILL COUGH AND STALL. THIS HAPPENS AT CRITICAL TRANSITION TIMES; AT AN INTERSECTION, IN STOP-AND-GO TRAFFIC AND ONCE IN A CROWDED PARKING LOT CAUSING ME TO DROP THE BIKE ON ITS SIDE. I CALLED SUZUKI AND FILED A CASE/COMPLAINT AND THE VEHICLE IS NOW AT A DEALERSHIP. I SPOKE TO THE DEALERSHIP AFTER 1 WEEK AND THEY STATED THAT THEY WERE UNABLE TO "RE-CREATE THE PROBLEM" AND WERE UNABLE TO…
Jan 2, 2017 · 1,200 miles
Fuel/propulsion system
MOTORCYCLE STALLS WHEN ENGAGING THROTTLE. THE MOTORCYCLE CAN BE IN NEUTRAL AND IT STILL STALLS ENGAGING THROTTLE. HAPPENED ~ 5 TIME WITHINT 2000 MILES. ITS A SAFETY CONCERN BECAUSE CARS BEHIND ME HAVE TO WAIT UNTIL I RESTART THE MOTORCYCLE. IT IS NOT A CLUTCH PROBLEM BECAUSE IT HAPPENS IN NEUTRAL ALSO.
Nov 6, 2016 · 2,000 miles
Engine
BIKE IS 6 MONTHS OLD BIKE HAS STALL ON ME AT LEAST 5 OCCASIONS WHEN IN MOTION IN TRAFFIC THE BIKE HAS STALLED WHEN PULLING IN THE CLUTCH BIKE IS UNRIDEABLE UNDER 2000 RPMS DUE TO POOR FUELLING CANNOT RIDE IN CITY TRAFFIC WITHOUT SLIPPING THE CLUTCH THE ENTIRE TIME BELOW 2000 RPMS MY BIKE HAS BEEN IN THE SHOP TWICE FOR THIS PROBLEM AND BOTH TIMES SUZUKI SAID THE BIKE IS SOPPOSED TO DO THAT WHEN I ASK THE SERVICE MGR IF HIS BIKES WONT RIDE UNDER 2000 ROMS HE SAYS NO HIS ARE FINE AS SHOULD ALL BIKES SERVICE MGR ASYS SUZIKI SAID ITS NORMAL SUZUKI IS REPLACING COMPUTERS UNDER WARRANT FOR THESE SAME PROBLEMS ALL OVER THE GLOBE BUT SUZUKI AMERICA SAYS NO THERE IS ALSO A NEW PART# FOR THE UPDATED…
Mar 18, 2016 · 1 miles
Electrical system
TL* THE CONTACT OWNS A 2014 SUZUKI DL1000. THE CONTACT STATED THAT THAT THE MOTORCYCLE WOULD STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS INFORMED THAT THE PARTS NEEDED TO ORDERED AND NO FURTHER INFORMATION WAS AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 1,900.
Feb 2, 2016 · 1,900 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Motorcycle StallingClosed
On March 3rd 2017 the Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE17-001) to investigate allegations of stalling when accelerating from a stop on 2014-2015 DL1000 Suzuki motorcycles.ODI contacted 4 of the 5 consumers who had filed complaints with the office and learned they all could engage the clutch as the stalling condition presented itself and keep the bike in an upright, stable position.On May 17th 2017 Suzuki responded to ODI's Information Request letter and informed ODI of 21 consumer complaints and 28 warranty claims alleging stalling while accelerating from a stop on 2014 and 2015 subject vehicles.Additionally, Suzuki made ODI aware of three crashes where the consumer alleged they dropped the bike as a result of the stall (no injuries were reported).ODI contacted the complainants, including the consumers alleging a crash and noted the majority…
PE17001 · opened Mar 7, 2017 · closed Nov 13, 2017