*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Unknown or other
The front panel of the two-panel glass moonroof spontaneously shattered, buckled and collapsed onto the panoramic roof sunshade of my 2025 Toyota Grand Highlander Hybrid without any impact or accident. I was driving at about 35-45 mph on a paved road and noticed the sound of wind coming from the car ceiling. I opened the panoramic roof sunshade slightly to see if the moonroof was open and saw that the front panel of the two-panel glass moonroof had spontaneously shattered. By the time I got home about an hour later, the moonroof glass had buckled about 1/2 inch into the air and a large chunk of the moonroof glass had collapsed onto the sunshade on the ceiling of the car. I now have a…
Oct 27, 2026Power train
Experienced repeated axle issues, acceleration hesitation, and poor suspension performance. Dealer failed to identify or reproduce the problem despite multiple visits and diagnostic fees. Axles eventually required out-of-pocket replacement due to popping and clicking. Suspected axle defect persists, and the vehicle remains unsafe-feeling and unresolved. Requesting Toyota investigate and provide free repairs.
Dec 17, 2025Fuel/propulsion system
The vehicle exhibits abnormal fuel system behavior. When the vehicle reaches a low fuel condition (approximately 40â50 miles to empty), the fuel tank only accepts about 12 gallons, even though the listed tank capacity is 17.2 gallons. After refueling, the fuel gauge displays FULL and the âDistance to Emptyâ reading jumps to over 360 miles, which is inconsistent with the amount of fuel added. A Toyota dealer documented this behavior on a repair order, stating that the tank accepted only 12 gallons from a low fuel condition and immediately displayed a range of 363 miles. A second repair order states that the fuel system was inspected and that the tank supposedly has a â3â5 gallon…
Aug 20, 2026Steering
I experienced a serious safety incident involving my 2025 Toyota Grand Highlander with approximately 14,000 miles. While driving on a straight interstate highway at approximately 70 mph, surrounded by other vehicles, the steering wheel suddenly made two to three sharp, forceful jerking movements to the left. Afterward, the steering wheel remained approximately 20 degrees off-center to the left. All lane departure assistance sensors were active during the incident. This unexpected steering behavior created a significant safety hazard. At highway speed, I could have lost control of the vehicle, departed my lane, or collided with surrounding traffic. I was able to reach my destination, but the…
Sep 19, 2026Service brakes
On 9/26 at about 10:15am, my husband and I were fully stopped at a red light with his foot on the brake. Without him touching the gas pedal, the car suddenly surged forward as if it had been accelerated. It stopped for a moment, then surged forward again. Because he was holding the brake, the car didnât move much, but each surge caused a hard jolt that felt like being rear-ended. No other vehicle hit us.
Sep 26, 2026Power train
While driving in neighborhood at around 25 mph car started to sputter and lose power. Started flashing on display regarding ADAS which all disengaged then hybrid system failure message displayed. Stopped car, called dealership and asked if safe to drive. They said it was ok and set appointment for next morning, they contacted Toyota and confirmed it needed a new transmission. Gave me a rental and said car was do not drive. Said transmission backordered under warranty.
Oct 2, 2026Structure › Body
Driving in city traffic during morning rush hour, sitting at traffic light, when display lights up indicating âHybrid Malfunctionâ and âtake vehicle to dealerâ. Leaving traffic light, the vehicle at first does not move after pressing accelerator, then slowly engages and thugs along. Pull over on closest side street and turn off vehicle, hoping just a fluke. Restart vehicle and drive a few yards. Stop and attempt to resume driving. This time the vehicle does not react at all, neither in drive or reverse. I was able to put in neutral and coast to nearby parking spot so not to block traffic. Had vehicle towed to my hometown Toyota dealer. Upon inspection, they notified me that a small…
Sep 25, 2026Engine
Engine temperature overheated during long idle on an out of town event. The vehicle put in park and engine running in idle with AC running. Vehicle coolant temp reach high mark in the red area. Vehicle temp alarm gave a warning to shutdown. I estimated the car idle time 40 min due to traffic accident ahead. The incident occurred on 9/11/26. The car was taken to dealer 9/17/26 for checkup/diagnose the issue. Dealer stated, they could not duplicate the issue. But they did my find the vehicle computer log, the engine registered high temp.
Sep 11, 2026
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
