2018 Toyota RAV4 Hybrid recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Forward collision avoidance

  The contact owns a 2018 Toyota Rav4 Hybrid. The contact stated that while operating the vehicle, the messages "Pre-Collision", "Braking Power Low", and "AWD System Malfunction" were displayed. The cause of the failure was not yet determined. The local dealer and manufacturer were not notified of the failure. The contact stated that the failure had occurred on the previous two model years of the same vehicle, but no cause for the failure was found when the vehicle was taken to the local dealer. The vehicle was not repaired. The failure mileage was 52,700.

  Aug 1, 2025 · 52,700 miles
• Engine and engine cooling

  The contact owns a 2018 Toyota Rav4 Hybrid. The contact stated that while receiving an oil change by a certified mechanic, the contact was informed that there was no coolant in the coolant reservoir. The mechanic confirmed that the radiator, hoses, and thermostat had failed and needed to be replaced. The vehicle was repaired; however, the failure persisted. While the contact was checking the coolant levels, the coolant level was always lower than expected. The contact was continually adding coolant. There was no warning light illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified…

  Jun 18, 2022 · 115,000 miles
• Electrical system

  The contact owns a 2018 Toyota Rav4 Hybrid. The contact stated that the vehicle was difficult to start. The contact recharged the vehicle and the vehicle restarted. The vehicle was taken to Toyo Cars, where it was diagnosed with an auxiliary battery failure. The dealer was contacted to order the part, but the part was not available. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the part was not available due to the global pandemic. The failure mileage was approximately 32,000.

  Feb 1, 2025 · 32,000 miles
• Fuel/propulsion system

  WHILE DRIVING ON LONG TRIP GOING SOUTH ON HWY 101, VEHICLE STARTED BUCKING AND JERKING GOING 70ISH MPH. EV LIGHT WOULD COME ON LIKE IT WANTED TO SWITCH TO EV MODE. IT HAPPENED GOING DOWN A STEEP GRADE NEAR SAN LUIS OBISPO. IT STOPPED WHEN WE GOT TO FLAT GROUND. ABOUT 25 MILES LATER IT DID IT AGAIN AND I WAS ABLE TO RECORD A QUICK VIDEO OF INSTRUMENT CLUSTER. TOOK IT TO ONE TOYOTA IN OAKLAND CA AND THEY WERE UNABLE TO DUPLICATE CONCERN. WIFE WAS DRIVING VEHICLE ON ANOTHER LONG TRIP A FEW MONTHS LATER AND IT HAPPENED TO HER FOR ABOUT 1 1/5 HOURS. SEEMS LIKE SYSTEM RESETS AFTER CYCLING IGNITION AND SHE WAS NOT AWARE OF THAT AT THAT TIME.

  Dec 23, 2018 · 15,000 miles
• Power trainCrash1 injury

  I PULLED INTO A PARKING SPOT. IT WAS SLOPED BACKWARD. THE CAR WAS STOPPED COMPLETELY, AND SILENT. I WAS DISTRACTED BY A MINOR TASK, AND THEN EXITED THE CAR, INADVERTENTLY WITH THE POWER ON AND THE TRANSMISSION IN DRIVE, NOT PARK. WHEN I NOTICED THAT I COULD NOT LOCK THE CAR, AND REALIZED THAT THE CAR WAS STILL ENERGIZED, I REACHED OVER AND PRESSED THE ON BUTTON TO TURN-OFF THE CAR-- WHICH IT DID. AT WHICH POINT THE CARD IMMEDIATELY HEADED BACKWARDS, DOWNHILL, CROSSED A STREET WHILE I WAS TRYING TO SLOW THE CAR FROM OUTSIDE THE DRIVERS DOOR, AND FINALLY HIT A LAMP POST AND STOPPED WITH DAMAGE TO THE REAR BUMPER. I TRIED TO REPRODUCE THE ISSUE, WITH THE SAME RESULT: THE CAR CAN APPEAR TO BE…

  Apr 25, 2019 · 6,300 miles
• Unknown or other

  WHILE ACTIVELY BRAKING AT LOW SPEED TO LINE UP TO A TICKET DISPENSER IN A PARKING GARAGE, THE CAR SUDDENLY ACCELERATED AS IF THE GAS PEDAL WAS FLOORED. I SLAMMED THE BRAKE AND THE CAR STOPPED AT ABOUT 10 FEET. THE PARKING ARM WENT OVER THE HOOD ABOUT HALFWAY. WHEN I TRIED TO REVERSE I SAW THE GEAR SHIFT HAD MOVED AND THE ENGINE WAS OFF.

  Apr 3, 2019 · 26,500 miles
• Service brakes

  I WAS DRIVING ON THE FREEWAY WITH ADAPTIVE CRUISE CONTROL ON. OUT OF THE CORNER OF MY EYE, I SAW A VERTICAL RED LINE FLASH ONCE ON THE DASH DISPLAY. SUDDENLY THE CAR BRAKED AND CAME TO A COMPLETE STOP. THERE WAS ALSO A LOSS OF POWER AS I COULD NOT STEER THE CAR TO THE SHOULDER. THERE WAS NOTHING IN FRONT OF ME AT THE TIME. THANKFULLY THE TRUCK BEHIND ME WAS ABLE TO SWERVE AND AVOID HITTING MY CAR. AFTER STOPPING, I SHIFTED THE CAR INTO A LOWER GEAR AND THEN BACK, AND WAS ABLE TO DRIVE AGAIN. I BROUGHT THE CAR TO THE TOYOTA DEALER, BUT THEY COULD NOT REPRODUCE THE PROBLEM.

  Feb 21, 2019 · 18,900 miles
• Structure › Body

  WE WERE DRIVING ON I 80 APPROXIMATELY 1 MILE WEST OF DIXON AT ABOUT 65MPH. THE DAY WAS SUNNY AND TEMPERATURE APPROXIMATELY 60F. THERE WAS NO OVERPASS NEARBY. WE THEN HEARD AN EXPLOSION LIKE A SHOTGUN BLAST AND GLASS CAME INTO THE PASSENGER COMPARTMENT THROUGH THE PARTIALLY OPEN SUNSHADE ON THE ROOF. NO ONE WAS INJURED. WE TOOK THE NEXT EXIT AND DISCOVERED THE MOON ROOF HAD EXPLODED. THE MAJORITY OF GLASS WAS GONE, INDICATING IT HAD GONE UP INTO THE AIR. THE CAR IS 7 MONTHS OLD. IT'S EXTREMELY UNLIKELY ANY OBJECT HIT THE MOON ROOF FROM ABOVE SO IT'S OUR OPINION THE GLASS WAS DEFECTIVE. TOYOTA HAS DENIED ANY RESPONSIBILITY UNDER ITS WARRANTY.

  Jan 12, 2019 · 11,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• Pedestrian alert soundsClosedLed to recall 22V063000

  NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review…

  DP22005 · opened Jan 27, 2023 · closed Aug 7, 2023