*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Air bags
SRS/airbag warning light illuminated. A diagnostic scan (VCDS) confirmed stored fault codes for both front airbag crash sensors: driver's side 'short to ground' and passenger's side 'open or short to plus.' Upon further inspection, water was found pooled at the airbag control module connector, located under the center dash. The AC condensate drain line is routed directly above this module, and appears to be the source of the water intrusion â water drained from the connector itself when disconnected, and dampness was present at both the upper and lower AC drain hose connections near the module. After drying and reconnecting all components, an attempt was made to clear the fault codes via…
Jul 28, 2026Engine
Junction between thermostat and water pump failed leading to total loss of coolant. At the time I was driving north on I-75 in heavy morning traffic at 65 MPH. I was able to steer the vehicle off the road without hitting anyone or coming to a complete stop. Had the vehicle towed to Jim Ellis VW of Kennesaw where they diagnosed the problem and replaced the water pump. The car had 18,762 miles on it at the time. Mechanic stated that the problem was oil from cam covers leaking onto water pump and was frequently seen. Vehicle had low coolant warning lights twice and I added several ounces of distilled water each time. Car had an engine warning light and was being taken to dealer for service…
Oct 8, 2025Fuel/propulsion system
The fuel pump on my 2016 Volkswagen Golf SportWagen failed approximately three months after a safety recall repair for the suction jet pump (recall 20Y6). My independent mechanic explained that failure of the suction jet pump can cause fuel leakage or vapor transfer into the EVAP system, which may create pressure or vacuum imbalance inside the fuel tank. This can potentially damage other fuel-system components, including the fuel pump. My vehicle had no prior fuel-system issues. After the recall repair, the vehicle began experiencing symptoms consistent with fuel delivery problems, and the fuel pump ultimately failed. The mechanic who performed the repair noted that the failure was…
Oct 8, 2025Unknown or other
Component: Sunroof / Roof Assembly - Water Ingress Make / Model / Year: 2016 Volkswagen Golf SportWagen VIN: [XXX] Mileage: ~40,000 Sunroof leaks water while closed and glass intact. First replacement frame arrived damaged. Repair extended into second week. Known manufacturer defect (VW bulletin MC-10241196-0001). Volkswagen denied reimbursement based on time expiration despite incredibly low mileage ~40,000. Effect: Interior damage to headliner/carpets, possible electrical damage, disruption of daily use. Requested Action: Document for safety/recall investigation; use data to support future recall or enforcement action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT…
May 30, 2025Fuel/propulsion system
My car started smelling like gas 10 days ago. There was no visible leak. We took it to the shop still canât figure out the issues. Took it to pick up my son from school, it started leaking fuel (I had 1/4 of a tank left). I turned off the car and it stopped leaking fuel. Needing a fix quick, I then drove 4 miles to get to the shop. Before I started driving I checked and it said I had enough gas to drive 15 miles. However, while at a stop light, the car shuddered and completely died. We then had it towed to the shop and hour away. The dealership had had it since then and found that it was related to the fuel pump suction recall. However, because the problem has gotten so bad, I now need a…
May 2, 2025Fuel/propulsion system
VW USA is offering no help in getting our recall work done. Their only suggestion is for us to work with our shipper. Our car is located in Italy because we are an active duty family stationed under orders at naval air station Sigonella. Our shipper has contacted VW Italy, and they refuse to help. The shipper also notes that they canât ship the car anywhere anyways because the recall has to do with the fuel system. In effect, our car is now trapped in Italy, unable to be shipped off the continent. Perhaps NHTSA could persuade VW USA to perform our recall work here in Italy?
Jul 31, 2024Fuel system, gasoline
See attached document for complaint.
Aug 2, 2024Electrical system
Despite settling a class action lawsuit re: moonroof leakage, VW refuses to cover the same repair for my VW Golf Sportwagen. I have the same issue but could not participate in the class action suit due to mileage. I routinely have to bail 1/2 - 1 gallon of water out the spare tire area if its been raining. Water now also collects in the footwell behind the driver's seat/in front of my child's seat. The bolts affixing the seatbelts to the floor are rusted and there is mold under the carpet. The car now has electrical issues, including the alarm no longer sounding when I am reversing and someone is approaching in my blind spot. In addition, when the weather has been wet, the back up camera…
May 14, 2024
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
