Model year record
The 2000 Volvo S40 has 1 safety recall and 122 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (53 complaints).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
| City / highway | 19 / 26 mpg |
|---|---|
| Fuel | Premium Gasoline |
1.9 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,900/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components | 53 | 40,000 mi |
| Vehicle speed control | 17 | 91,500 mi |
| SuspensionFront; Rear | 15 | 63,525 mi |
| Exterior lightingHeadlights; Headlights › High/low beam dimmer switch | 15 | 21,350 mi |
| Electrical systemIgnition › Switch; Alternator/generator/regulator | 13 | — |
| Engine and engine coolingEngine › Gasoline; Cooling system | 10 | 80,000 mi |
| Seat beltsFront › Buckle assembly; Front › Anchorage | 7 | 50,000 mi |
| VisibilityWindshield wiper/washer; Power window devices and controls | 5 | — |
| Unknown or other | 4 | — |
| SteeringColumn locking › Anti-theft device; Hydraulic power assist system | 4 | — |
| EquipmentElectrical › Radio/tape deck/cd etc.; Appliance › Air conditioner | 4 | — |
| Air bags | 3 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
This is to describe airbag injuries. My car performed well. If not for the airbag and good construction of this Volvo I would not be here to ask for your help. I am wondering why we still use explosive materials and a device that causes so many injuries. There has to be another device to absorb the force of impact than an explosive device that injures, maim, and can kill people. I want to send images of my injuries which are extensive. Is this what happens each time the airbags ignite? I was close due to my small stature. The bag hit me in the chest and face. Volvo is a safe car. I was traveling at 55mph, a woman stopped her car in the passing lane feet in front of me, everyone was doing 55…
THE CAR HAS PROBLEMS STARTING AND TAKES A FEW TRIES BEFORE STARTING UP. HAVE ALSO HAD A PROBLEM WHERE THE CAR WAS IN PARK WITH THE PARKING BRAKE ENGAGED AND THE CAR WAS REVVING ON ITS OWN. THERE HAVE ALSO BEEN PROBLEMS WHILE THE CAR HAS BEEN SLOWING DOWN ON THE FREEWAY, SPECIFICALLY WHEN THE BRAKES ARE BEING ENGAGED THE CAR WILL ATTEMPT TO MOVE FORWARD AS THOUGH IT IS TRYING TO PUSH PASS THE FACT THAT THE BRAKES ARE BEING ENGAGED. AS WELL AS THE CAR WILL ACCELERATE FASTER THAN THE GAS PEDAL IS BEING PUSHED E.G WHEN THE GAS PEDAL IS SLIGHTLY PUSHED THE CAR WILL ACCELERATE QUICKLY AS THOUGH THE GAS PEDAL WAS BEING PUSHED UPON FIRMLY.
THIS HAPPENED YESTERDAY 1/28/16 AND IN APRIL 2015 (THE DEALERSHIP "FIXED IT" BUT IT DIDN'T WORK!!!!) YESTERDAY, WHILE DRIVING HOME FROM WORK, THE CAR DID THE SCARIEST THING I'VE EVER EXPERIENCED WHILE DRIVING. ALL THE LIGHTS ON THE DASH, ALL THE WARNING LIGHTS FLASHED SEVERAL TIMES AND THE CAR CAME TO A COMPLETE STANDSTILL. NO POWER AT ALL. IT DIDN'T SLOW TO A STALL, NO WEIRD SOUNDS...IT JUST LITERALLY STOPPED IN IT'S TRACKS. RIGHT THERE, IN THE ROAD. ALL OF A SUDDEN MY CAR SHUT OFF. WHEN I SAY SHUT OFF I MEAN THE HEADLIGHTS, DOME LIGHTS, ENGINE....ANYTHING THAT WAS ELECTRICAL COMPLETELY SHUT OFF. THIS WOULD INCLUDE THE STEERING WHEEL LOCKING UP. IMAGINE DRIVING ON THE FREEWAY/HIGHWAY IN…
TL* THE CONTACT OWNS A 2000 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. THE CONTACT MENTIONED THAT THE BRAKE PEDAL WAS DEPRESSED IN ORDER TO SLOW DOWN OR STOP THE VEHICLE. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,900.
I WAS STOPPED AT A RED LIGHT BEHIND SEVERAL CARS. THE LIGHT TURNED GREEN AND I TOOK MY FOOT OFF THE BRAKE, BUT DID NOT PUT MY FOOT ON THE ACCELERATOR. THE CAR ENGINE REVVED UP AND LURCHED FORWARD DESPITE ME ATTEMPTING TO BRAKE HEAVILY. THE BRAKES WOULD NOT FULLY DECOMPRESS CAUSING ME TO REAR END THE VEHICLE IN FRONT OF ME. I PURCHASED THE CAR USED WITH 134,100 MILES. I NOTICED ABOUT 5 MONTHS AFTER PURCHASE THAT THE ENGINE WOULD REV AND THE RPM'S WOULD REMAIN HIGH WITHOUT PRESSING ON THE ACCELERATOR AND THE CAR WILL MOVE APPROXIMATELY 10-15 MPH WITHOUT PRESSING ON THE ACCELERATOR. WHEN ROADS ARE WET OR WHEN IT HAS BEEN RAINING, THE CAR IS DIFFICULT IN BRAKING AND THE BRAKES OFTEN "FREEZE"…
TL* THE CONTACT OWNS A 2000 VOLVO S40. THE CONTACT STATED THAT WHILE TRAVELING 30 MPH THE VEHICLE'S SPEED ERRONEOUSLY INCREASED TO 55 MPH. THE CONTACT FIRMLY DEPRESSED THE BRAKE PEDAL TO STOP THE VEHICLE. THE CONTACT MERGED TO THE SIDE OF THE ROAD TO RESTART THE VEHICLE. THE VEHICLE THEN FUNCTIONED AS NORMAL. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS FOUND THAT THE COOLANT TEMPERATURE SENSOR HAD FAILED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED SEVERAL TIMES AFTER THE REPAIR. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 96,828. UPDATED 11/13/12 *CN THE IDLE CONTROL VALVE AS REPLACED TO CORRECT THE PROBLEM. HOWEVER, THE CONSUMER CONTINUED TO EXPERIENCE PROBLEMS.…
IT WAS CLOSE TO 9PM. I HAD EXITED THE FREEWAY TO STOP IN A PARKING LOT TO CHECK DIRECTIONS. I HAD BEEN DRIVING FOR ABOUT AN HOUR, SO I GOT OUT TO WALK AROUND AND BUY A CUP OF COFFEE. I CAME BACK A FEW MINUTES LATER AND DROVE OUT OF THE LOT. THE ON RAMP WAS ABOUT 200 YARDS AWAY AND THERE WAS A RED LIGHT AT THE INTERSECTION, SO I WAS ONLY MOVING AT AROUND 20MPH. I WAS THE ONLY CAR IN MY LANE, SO ABOUT 100 FEET AWAY FROM THE INTERSECTION I PRESSED DOWN ON MY BRAKE PEDAL, BUT THE FOR SOME REASON IT THE CAR KEPT ROLLING. I TRIED AGAIN, BUT THE BRAKES WERE NO HELP AS I KEPT ROLLING. FRANTICALLY, I STOMPED HARD, FLOORED THE BRAKES, AND MY CAR STARTED TO SLOW DOWN A LITTLE, BUT THAT TIME IT WAS TOO…
TL* THE CONTACT OWNS A 2000 VOLVO S40. THE CONTACT STATED THAT THE VEHICLE WOULD ACCELERATE ABNORMALLY WITHOUT DEPRESSING THE ACCELERATOR PEDAL. THE FAILURE OCCURRED INTERMITTENTLY WHETHER DRIVING IN REVERSE OR GOING FORWARD, AS WELL AS WHEN SITTING AT A COMPLETE STOP. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THEY NEED TO REPAIR THE ELECTRONIC THROTTLE CONTROL, IDLE CONTROL VALVE AND THE BRAKE SYSTEM. THE REPAIRS WERE NOT COMPLETED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
IN A NOVEMBER 6, 2003 SAFETY DEFECT REPORT, VOLVO INDICATED THAT THEY WILL CONDUCT A SAFETY-RELATED DEFECT RECALL OF THE 2000 MODEL YEAR (MY) SUBJECT VEHICLES (ABOUT 36,000 VEHICLES).VOLVO WILL ALSO CONDUCT A SERVICE CAMPAIGN OF ABOUT 31,000 2001 MY SUBJECT VEHICLES.ODI INVESTIGATED BOTH THE 2000 AND 2001 MY VEHICLES AND DETERMINED THAT THE 2001 MY VEHICLES EXPERIENCED SUBSTANTIALLY LOWER RATES OF FAILURES BASED ON THE NUMBER OF OWNER REPORTS AND WARRANTY CLAIMS SUBMITTED TO ODI.ODI BELIEVES THAT THE PROPOSED ACTION IS SUFFICIENT TO RESOLVE THIS INVESTIGATION'S SAFETY ISSUES. FOR THE CRASHES, IN ADDITION TO THE 22 SUBMITTED BY VOLVO, ODI FOUND 10 ADDITIONAL CRASH ALLEGATIONS IN THE OWNER REPORTS, FIELD REPORTS, AND WARRANTY CLAIMS SUBMITTED BY VOLVO.OF THESE 32 CRASHES, ODI BELIEVES THAT 10 ARE CLEARLY RELATED TO THE ALLEGED DEFECT, AND 5 APPEAR TO BE RELATED.OF THE 17 REMAINING CASES,…