Model year record

1992 BMW 325i recalls & problems

The 1992 BMW 325i has 4 safety recalls and 40 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (16 complaints).

Recalls4safety recalls

Complaints40filed by owners

Crashes · fires2 · 1reported in complaints

Injuries · deaths2 · 0reported in complaints

Safety recalls

Engine and engine coolingAug 4, 1998

Cooling system

Recall 98V178000340,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Risk: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.

Vehicle speed controlAug 19, 1997

Vehicle speed control

Recall 97V131000410,000 vehicles

Problem: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Risk: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.

Exterior lightingJul 1, 1996

Brake lights › Switch

Recall 96V111000180,000 vehicles

Problem: THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Risk: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Fix: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.

Air bagsJul 1, 1996

Frontal

Recall 96V11000075,000 vehiclesopened after NHTSA action (ODI)

Problem: THE AIR BAG CONTACT RING LOCKING TAB LOCATED IN THE STEERING WHEEL ASSEMBLY CAN BREAK WITHOUT WARNING.
Risk: IF THIS HAPPENS, THE CONTACT RING WIRING COULD EVENTUALLY BREAK. THE AIR BAG READINESS INDICATOR LAMP (SRS OR AIRBAG) IN THE INSTRUMENT CLUSTER WILL ILLUMINATE, AND THE AIR BAG WOULD NOT DEPLOY IN THE EVENT OF A FRONTAL IMPACT VEHICLE COLLISION.
Fix: DEALERS WILL REPLACE THE LOCKING TAB WITH ONE OF A DIFFERENT DESIGN.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1992 BMW 325i 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

325i Convertible

18mpg combined

City / highway	16 / 21 mpg
Fuel	Regular Gasoline

2.5 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,700/year to fuel

325i Convertible

18mpg combined

City / highway	15 / 22 mpg
Fuel	Regular Gasoline

2.5 L · 6 cyl · Manual 5-spd · Rear-Wheel Drive · about $3,700/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingCooling system; Cooling system › Radiator assembly	16	0	0	0	—
Electrical systemIgnition › Module; Wiring › Interior/under dash	5	0	1	0	—
VisibilityDefroster/defogger/hvac system; Power window devices and controls	5	0	0	0	—
StructureFrame and members; Frame and members › Underbody shields	5	0	0	0	—
Seat beltsFront › Buckle assembly; Front › Retractor	4	0	0	0	—
Fuel system, gasolineFuel injection system	3	0	1	0	—
EquipmentMechanical › Accessory scissor/screw/bottle jack/lift; Electrical › Radio/tape deck/cd etc.	3	0	0	0	—
Service brakes, hydraulicFoundation components › Disc › Caliper; Foundation components	2	0	0	0	—
Air bagsFrontal	2	1	0	0	—
Tires	2	0	0	0	—
Latches/locks/linkages	2	0	0	2	—
Vehicle speed control	1	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Tires
I WAS DRIVING AT 70MPH ON I71 WITH CRUISE CONTROL ENABLED WHEN I FELT VIBRATIONS FOR APPROX. 20 SECONDS AND THEN MY RIGHT REAR TIRE BLEW OUT. I HAD DRIVEN APPROXIMATELY 30 MILES UP TO THIS POINT AND I VERIFIED THAT TIRE TO BE 36 PSI AS RECENTLY AS THAT MORNING. THE TIRE HAS NO PUNCTURE DAMAGE AND THE BEAD IS STILL FULLY SET ON BOTH SIDES. THE TIRE SEPARATED BETWEEN THE SIDEWALL AND TIRE FACE. TIRE RACK REFUSED TO RESOLVE THE SITUATION IN A WAY THAT I WOULD NOT INCUR FURTHER OUT-OF-POCKET COSTS, AND THE TIRE MANUFACTURER ACTED CONFUSED AND FAILED TO COMPREHEND THE INFORMATION I WAS GIVING THEM. I ENDED UP FILING A VISA CHARGEBACK AGAINST TIRE RACK. I HAVE THIS SAME TIRE ON TWO CARS AND WE'VE…
Apr 20, 2014 · 207,000 miles
Latches/locks/linkages
TL*THE CONTACT OWNS A 1992 BMW 325I. WHENEVER THE CONTACT LOCKS THE DOORS FROM THE OUTSIDE OF THE VEHICLE, HE IS UNABLE TO UNLOCK THEM FROM INSIDE THE PASSENGER COMPARTMENT. ONCE HE LOCKS THE DOORS, THE DOOR HANDLES AND LOCKS FAIL INSIDE THE PASSENGER COMPARTMENT. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 200,000.
Aug 16, 2008 · 200,000 miles
Latches/locks/linkages2 injuries
I LOCKED MY 1992 BMW 325I WITH THE KEY FROM THE OUTSIDE WITH MY FRIEND INSIDE (I DID NOT REALIZE HE HAD NOT GOTTEN OUT OF THE VEHICLE YET). I HAD DROPPED THE KEY WHEN I HEARD HIM POUND ON THE WINDOW (LOOSING THE KEY IN SOME BRUSH). WHEN THIS SITUATION HAD TRANSPIRED I FOUND OUT THAT HE COULD NOT OPEN ANY OF THE DOORS FROM INSIDE OF THE VEHICLE IN ANY MANNER. IF THIS WERE A SMALL CHILD AND LETS SAY A FORGETFUL GRANDPARENT THE CHILD WOULD NOT BE ABLE TO GET OUT OF THE CAR IN ANY MANNER. (OR WITH THE WEIRD MOTHER DROWNING KIDS AND UNCLES LOCKING KIDS IN HIS BASEMENT THAT WE HEAR ABOUT ON THE NEWS) THIS CAR COULD BE USED AS A POTENTIAL PRISON. IF THIS WERE ANY PERSON(S) WHO ARE NOT VERY…
Aug 17, 2008 · 68,000 miles
Tires
THIS JUNE OF 2005 WHILE MY 92BMW325I WAS PARKED AT THE MALL, THE BACK PASSENGER TIRE I NOTICED BLEW UP. WHEN I BROUGHT IT TO PIT STOP TO HAVE THE TIRE VULCANIZED, THEY SAID THEY CAN'T DO ANYTHING W/IT BUT BE REPLACED. I REPLACED IT AT SAM'S CLUB W/AP205/60R15H TOUR. I ASKED IF THE OTHER 3 TIRES NEED TO BE REPLACED & THEY SAID "NO". LAST SUNDAY JUL 24 WHILE MY SON WAS DRIVING ON INTERSTATE 26, THE FRONT DRIVER SIDE TIRE BLEW UP & CAUSED A LOT OF DAMAGE TO THE VEHICLE & FORTUNATELY SPARED ANY INJURY TO MY SON. I BOUGHT THESE 4 P205/60R15 OR 15-205/60-15GT COOPER COBRA TIRES FROM STROBEL TIRE CO. WE'RE STILL WAITING FOR OUR INSURANCE CO. TO HAVE THE VEHICLE REPAIRED. I READ ABOUT A LAWSUIT…
Jul 24, 2005
Structure › Body › Door
WHILE ENTERING INTO THE VEHICLE THE DOOR FAILED TO OPENED. THE LEFT AND RIGHT SIDE DOOR WAS UNABLE TO OPEN PROPERLY. THE DRIVER WAS ABLE TO CONTACT THE DEALER FOR APPOINTMENT. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
Jan 14, 2005
Structure › Frame and members
1) MOUNTS FOR REAR SUBFRAME TO BODY NOT STRONG ENOUGH. THEY FLEX AND CRACK LEADING TO A CHAIN REACTION THEN THE REAR END RIPS OFF. 2)I WAS DRIVING DOWN A BUSY TWO WAY ROAD. THEN ALL OF A SUDDEN MY CARS REAR END IS MOVING TO THE LEFT AND I LOST CONTROL FOR A LITTLE. LUCKILY DIDNT CRASH INTO ANOTHER CAR. THEN I REGAINED CONTROL AND DROVE BACK TO MY HOUSE WHICH WAS 1 STREET AWAY. 3) I HAD TO HAVE IT TOW TRUCKED TO A GARAGE WHERE THEY HAD TO REPLACE THE WHOLE SHEET METAL PART WHERE THE WHOLE REAR END MOUNTS TO. DOCUMENTED AND COST ME OVER $2000.00 THIS IS NOT AN ISCOLATED INCIDENT CHECK OUT THIS FORUM: HTTP://BIMMER.ROADFLY.ORG/BMW/FORUMS/E36/FORUM.PHP BMW KNOWS OF THE PROBLEM AND THEY MAKE…
Apr 1, 2004 · 125,000 miles
Structure › Frame and members › Underbody shields
I OWN A 1992 BMW 325I, IVE ENCOUNTERED A PROBLEM, THE REAR SUB FRAME IS BREAKING APART FROM THE BODY OF THE CAR. THIS SEEMS TO BE A EXPENSIVE PROBLEM THAT OCCURS TO MANY BMWS. THIS IS NOT NORMAL WEAR AND TEAR ON A CAR, THIS IS A DEFECT THAT BMW SHOULD ACKNOWLEDGE. *AK
Oct 19, 2003 · 158,000 miles
Engine and engine cooling › Engine › Gasoline
TOOK CAR THROUGH CAR WASH. CAR CAME OUT DEAD. TURNS OUT THAT THIS IS A COMMON PROBLEM WHERE WATER GETS INTO THE MAIN ECM COMPUTER AND SHORTS IT OUT. THIS IS TERRIBLE. BMW SHOULD ISSUE A RECALL FOR THIS. $1100 FOR GOING THROUGH A SIMPLE CAR WASH. OWNERS SHOULD BE CAUTIONED. MR
Oct 2, 2002

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.