Model year record

1994 BMW 325i recalls & problems

The 1994 BMW 325i has 3 safety recalls and 17 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (4 complaints).

Recalls3safety recalls

Complaints17filed by owners

Crashes · fires0 · 1reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

Engine and engine coolingAug 4, 1998

Cooling system

Recall 98V178000340,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. A MALFUNCTION OR FAILURE OF A COOLANT SYSTEM COMPONENT, SUCH AS A THERMOSTAT, WATER PUMP, OR FAN BELT, CAN RESULT IN SIGNIFICANTLY INCREASED COOLANT TEMPERATURE AND SYSTEM PRESSURE. IF THE INDICATIONS OF A CRITICAL OVERHEATING CONDITION IS NOT NOTICED BY THE DRIVER, IT IS POSSIBLE THAT DAMAGE TO, OR FAILURE OF, A COOLANT SYSTEM COMPONENT COULD OCCUR.
Risk: IF A CRACK WERE TO FORM OR A SEAM WERE TO SEPARATE IN THE HEATER CORE END PIECE, HOT COOLANT COULD SUDDENLY BE EXPELLED, INCREASING THE RISK OF PERSONAL INJURY TO A VEHICLE OCCUPANT.
Fix: DEALERS WILL INSTALL A NEW DESIGN RADIATOR CAP TO CONTROL PRESSURE AND PROVIDE GREATER COOLANT OVERFLOW IN THE EVENT OF OVERHEATING.

Vehicle speed controlAug 19, 1997

Vehicle speed control

Recall 97V131000410,000 vehicles

Problem: THE CRUISE CONTROL AND THROTTLE CABLES ARE ATTACHED TO THE SAME THROTTLE VALVE ACTUATING LEVER AT THE THROTTLE HOUSING. IT IS POSSIBLE THAT THE PLASTIC BUSHING ON EITHER CABLE COULD BREAK DUE TO ENVIRONMENTAL INFLUENCES COUPLED WITH VIBRATION. IF THE BUSHING BREAKS, THE OUTER CABLE HOUSING CAN SEPARATE FROM THE BUSHING. IN THIS CASE, DURING APPLICATION OF THE THROTTLE PEDAL WITHOUT CRUISE CONTROL BEING ENGAGED, THE OUTER TUBE COULD CATCH ON THE EDGE OF THE BROKEN BUSHING.
Risk: THIS COULD CAUSE THE THROTTLE VALVE TO REMAIN PARTIALLY OPEN. IT HIS WERE TO OCCUR, THE CAR MIGHT NOT DECELERATE AS EXPECTED INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSTALL A SPRING STEEL CLIP ON THE OUTER TUBE OF EACH CABLE IN THE AREA OF THE ADJUSTING SCREW AND PLASTIC BUSHING. THE CLIP IS DESIGNED TO PREVENT THE OUTER TUBE FROM DISLODGING FROM THE BUSHING.

Exterior lightingJul 1, 1996

Brake lights › Switch

Recall 96V111000180,000 vehicles

Problem: THE BRAKE LIGHT SWITCH CAN FAIL ALLOWING THE SWITCH TO REMAIN IN THE "BRAKE LIGHTS OFF" POSITION OR IN THE "BRAKE LIGHTS ON" POSITION.
Risk: IF THIS HAPPENS, THE BRAKE LIGHTS EITHER WILL NOT OPERATE OR WILL BE CONTINUOUSLY ON, REGARDLESS OF BRAKE PEDAL POSITION. FOLLOWING DRIVERS WOULD NOT BE ABLE TO DETERMINE WHETHER THE VEHICLE IS STOPPING, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Fix: DEALERS WILL REPLACE THE EXISTING BRAKE LIGHT SWITCH WITH A NEWLY DESIGNED SWITCH.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

325i Convertible

20mpg combined

City / highway	18 / 26 mpg
Fuel	Premium Gasoline

2.5 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,100/year to fuel

325i Convertible

20mpg combined

City / highway	17 / 26 mpg
Fuel	Premium Gasoline

2.5 L · 6 cyl · Manual 5-spd · Rear-Wheel Drive · about $4,100/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Fires	Typical mileage*
Engine and engine coolingCooling system; Cooling system › Hoses/lines/piping/fittings	4	1	—
Electrical systemInstrument cluster/panel; Ignition › Module	4	1	—
Fuel system, gasolineDelivery	3	0	—
Air bags	2	0	—
Power trainAutomatic transmission; Manual transmission	2	0	—
Seat beltsFront › Anchorage	2	1	—
Exterior lightingBrake lights › Switch; Brake lights	2	0	—
StructureBody › Door	1	0	—
Child seat	1	0	—
Latches/locks/linkagesDoors › Latch	1	0	—
Visibility	1	1	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel system, gasoline
THE BRACE HOLDING ONE OF THE FUEL TANK STRAPS BROKE OFF. IT SEEMS IF BROKE OFF AT THE WELDS. THE STRAP WAS JUST HANGING AND ONLY THE OTHER WAS HOLDING THE FUEL TANK IN PLACE. *TR
Apr 7, 2012 · 188,540 miles
Electrical system › Instrument cluster/panelFire
TL* THE CONTACT OWNS A 1994 BMW 325I. THE CONTACT STATED THAT THE ODOMETER READING WAS INCORRECT. THE MILEAGE INDICATED THAT THE VEHICLE HAD 28,000 MILES WHEN THE TITLE INDICATED THAT THE MILEAGE WAS 128,000. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR A DIAGNOSTIC TEST. THE DEALER ADVISED THE CONTACT THAT ANOTHER MECHANIC HAD ALTERED THE ODOMETER. THE CONTACT ALSO NOTICED THAT THE ANTI-FREEZE WAS LEAKING, THE FRONT WINDOWS FOGGED AND THE SEAT BELTS WERE DEFECTIVE. THE VEHICLE WAS AT THE DEALERSHIP AWAITING REPAIR AT THE TIME OF THE COMPLAINT. THE APPROXIMATE MILEAGE WAS APPROXIMATELY 28,000. THE CURRENT MILEAGE WAS UNKNOWN.
Feb 25, 2010 · 28,000 miles
Electrical system
CONSUMER'S WIFE WAS LOCKED IN THEIR 1994 BMW 325I AND THE DOORS WOULD NOT OPEN. *NJ THE CONSUMER STATED THE WINDOWS AND HORN DID NOT WORK EITHER. *JB
Jun 24, 2009
Electrical system › Instrument cluster/panel
FUEL GAUGE INTERMITTENT FAILURE. BMW'S FROM 70'S TO '07 HAVE BEEN NOTED BY OWNERS AS BEING A PERSISTENT PROBLEM. MOST DUE TO FAILURE OF THE SENDING UNITS. MANY OWNERS END UP HAVING THE SENDERS REPLACED MULTIPLE TIMES D/T MULTIPLE FAILURES OF THE SENDING UNITS. MY E36 HAS 2 SENDING UNITS AND I HAVE BEEN STUCK ON THE SIDE OF THE ROAD MULTIPLE TIMES. AND THE SAME FOR MANY OTHER OWNERS ON BMW ONLINE BOARDS/FORUMS. I'VE BEEN STUCK IN TRAFFIC WHERE I MERELY MISSED AN ACCIDENT BY MANEUVERING W/O ENGINE POWER. PLEASE LOOK INTO THIS. BMW HAS CONTINUED TO HAVE THESE PROBLEMS AND SHOULD RECALL THE FAILED UNITS THAT JUST KEEP FAILING. *TR
Feb 1, 2007 · 90,000 miles
Power train › Manual transmission
DEFECTIVE TRANSMISSION JUMPED OUT OF 1ST GEAR WITH ENGINE LOAD. *BF THE CONSUMER REQUESTED ASSISTANCE TO REMEDY THE PROBLEM THE CONSUMER DISCOVERED A TECHNICAL SERVICE BULLETIN HAD BEEN ISSUED FOR MANUAL TRANSMISSIONS. *SC *JB
Nov 1, 2004
Exterior lighting › Brake lights
WHEN DRIVING THE VEHICLE AT AN UNDETERMINED SPEED, THE BRAKE LIGHT ILLUMINATED ON THE DASHBOARD. THE CONSUMER INFORMED THE DEALER ABOUT THIS ISSUE, HOWEVER THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. *NM THE REAR BRAKE LIGHT BULBS BURNED OUT. *SC *JB
Apr 12, 2004 · 30,000 miles
Child seat
CHILD SEAT WOULD NOT LATCH ONTO LEFT SIDE OF BASE. *MR PH
Jun 16, 2003
Exterior lighting › Brake lights › Switch
CONSUMER IS UNABLE TO OPEN LEFT REAR DOOR FROM BOTH INSIDE AND OUTSIDE. DEALER AND MANUFACTURER WERE NOTIFIED.*AK CONSUMER STATED THE BRAKE LIGHT SWITCH WAS REPLACED.*JB
Sep 17, 1996

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.