2015 BMW 328d recalls & problems

Recent owner complaints

• Oct 18, 2025 · 150,000 milesFuel system, diesel
  The contact owns a 2015 BMW 328D. The contact stated that while driving 15-25 MPH, there was an abnormal sound coming from the engine, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle stalled. The contact was able to coast to the side of the road. The vehicle failed to restart. The contact was unsure if any warning lights were illuminated. The vehicle was towed to a BMW-Authorized mechanic, who diagnosed that the fuel pump had failed, and there were metal shavings found in the fuel. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure and referred the contact to the NHSTA…
• Mar 23, 2025 · 49,000 milesPower train
  The contact owns a 2015 BMW 328D. The contact stated that while driving 5 MPH, the vehicle hesitated. Additionally, while attempting to accelerate, the vehicle briefly lost motive power before slamming into gear. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The contact related the failure to NHTSA Campaign Number: 20V185000 (Power Train); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 49,000.
• Oct 29, 2024Fuel/propulsion system
  The high pressure fuel pump failed i see there are recalls for 2014-2018 similar bmw with diesel engine and mine is not included with recall although it clearly has the faulty part. The car will no longer start and I am being quoted $18,000 to repair it which makes the car useless i just got it for $10,000
• Feb 8, 2024Fuel/propulsion system
  I was driving on a busy two lane road. The vehicle instantly decelerated and made a large thump while driving at 55mph. The vehicle information system said there was a drivetrain malfunction, and all power was instantly gone. We were able to quickly pull off onto a small section off the road, but not in a safe manner, almost going into the ditch, in which I strongly was anticipating was going to be a total loss to the car as an accident and Injury to myself and my wife. The vehicle then after waiting several hours was towed to a certified BMW shop to be looked at. The shop noted that it sounded like it was a high pressure fuel pump failure that caused the car to abruptly decelerate. The…
• May 1, 2023Fuel/propulsion system
  Vehicle is 100% BMW Serviced for it's history, showroom to present. Vehicle had been smoking after sitting 2-3 days and driving. We'd park and see wisps of smoke coming from the wheelwells and engine bay. Alarming! Never witnessed open flame, but as the saying goes, if there's smoke... Questionable component: 328xd Fuel Sensor Probe (BMW part #13-53-8-594-893 Fuel Feed Line 135040 ) Complaint/Report pertains to Fuel Sensor Probe failure and resultant fuel propagation(backfeeding/leaking fuel from sensor connection) into adjacent wiring/engine bay foils. Diagnostic System did not report sensor failure until extensive damage and hazard was realized. BMW USA responded to report as NOT COVERED…
• Jan 1, 2023Fuel system, diesel
  The contact owns a 2015 BMW 328D. The contact received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure related to the recall; however, the check engine was intermittently illuminated. The failure mileage was unknown. Parts distribution disconnect.
• Feb 23, 2023Fuel/propulsion system
  High-pressure fuel pump failed while driving causing vehicle to stop abruptly, a recall for this part due to the same issues already exists but not for my VIN.
• Sep 5, 2022Power train
  Date of complete failure noted below (09/05/22) On 2 previous occasions, approx. 7 days earlier and a week earlier as car was making a slow left turn, not from a stop, one rear wheel shuddered, and the engine seemed to rev as if missed a gear. I lifted off the throttle, and then the car operated normally. The complete failure occurred (3rd occurance) on Sept. 7. Accelerating slowly from a traffic light, turning left (again), the car exhibited the above, but much more severe. I was finally able to gain speed, but drove slowly to try to get home, about 1 mile distant. Many malfunction messages came onto the screen (listed below) Got the car home, tried to put car into "Park" but park would…

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• EA23001 · opened Mar 17, 2023 · open · led to recall 24V957High pressure fuel pump failure
  The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed…
• EA21002 · opened Sep 17, 2021 · openDesiccated Air Bag Inflator Rupture
  From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled…