2017 BMW 328d recalls & problems

Recent owner complaints

• Jul 20, 2026Engine
  Diesel fuel pump failed while driving on the road. I also own a 2014 328d BMW which was recalled earlier where the diesel fuel pump was replaced by the dealership. While driving on the road, the car unexpectedly turned off in traffic. I managed to get the vehicle off the road and called a tow truck. I contacted my local BMW dealer and informed me my 2017 328d is not under a recall like my 2014 328d was. I then instructed the tow truck driver to take the car to an independent mechanic who specializes on BMWs. The diagnosis is a fail fuel pump.
• May 1, 2024Service brakes
  I started to hear a grinding noise from the center-underside of my car about 4 months ago. I did some research and found that many BMW customers had experienced the same noise and the diagnosis was a parking brake line that drops on the main driveshaft after breaking free of the plastic support that is supposed to hold it in place. A video with sound of of the problem can been seen/heard here - [XXX] I had my BMW dealer look into the problem and his diagnosis was the same. The plastic clip that holds the parking brake cable in place had broken. And when the cable drops it rubs on the driveshaft making the grinding noise. A copy of the estimate to repair is attached. So far this failure has…
• Sep 13, 2023Exterior lighting
  Headlight vertical aim control malfunction, TONS of f series BMWs affected.
• May 26, 2023Unknown or other
  Was driving down highway going 70mph, I heard a loud pop above me and realized the front sunroof section shattered. Luckily it was not open and shade protected from glass. Glass has gone everywhere on the highway and scratched up the roof and my windshield also cracked.
• May 19, 2022Fuel/propulsion system
  Hi, my vehicle has a recall, 21v586, for high pressure fuel pump. I suggest this recall should be elevated to a mandatory recall. When my fuel pump failed it immediately lost power while driving. I was fortunate to maneuver the car across traffic to a safe location. I consider myself a defensive and conscious driver. Had this been my wife or someone else I'm not real confident that they would be able to safely maneuver the vehicle as there was no warning. Moreover, my car has been unavailable since 5/19 when this occurred. This pump had a such a catastrophic failure that it sheared a mounting bolt holding it to engine. Metal fragments were displaced throughout the fuel system. Most recent…
• Feb 22, 2022Unknown or other
  Failed component: Failure for a motor vehicle to signal the intention to perform a U-TURN maneuver. Safety at risk: U-TURN maneuvers often result in accidents that cause material damage, severe injuries and death of motorists, passengers, motorcycle riders, bicyclists, and pedestrians. These accidents usually happen due to the inability of drivers to properly signal or warn others of the intention to execute a U-TURN maneuver because of the non-existence of a U-TURN signal in motor vehicles. Problem reproduced/confirmed? Yes, this problem occurs every day on the public roads/streets of our Nation. Has vehicle/component been inspected? NO, the U-TURN signal has not been added under the…
• Jan 1, 2022Fuel system, diesel
  The contact owns a 2017 BMW 328D. The contact received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The dealer had been notified and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.
• Feb 5, 2022Engine
  On February 5, 2022 while driving on 70 mph on I64 my vehicle shut down due to the recall causing the the high-pressure fuel pump to shut down causing the engine to stall and a message that there was a powertrain malfunction and the vehicle would not start back or go into gear. The interstate was very busy and I could have been hit by a tractor trailer or another vehicle at high speed. I received a recall notice that stated there was a remedy available November 2021, but when I called the dealership I was told there were no parts available and they would call me when parts became available. A month went by and the issue with the recall happened leaving me in a very dangerous situation. The…

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• EA23001 · opened Mar 17, 2023 · open · led to recall 24V957High pressure fuel pump failure
  The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a comprehensive recall population could not be produced by FCA and BMW.During the investigation FCA filed recalls 22V406, 22E048, 22V767, and 22E087 which include vehicles not identified in the initial subject population by ODI. ODI also received recall 21V586, involving loss of motive power due to failed…
• EA21002 · opened Sep 17, 2021 · openDesiccated Air Bag Inflator Rupture
  From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled…