The 1996 Buick Regal has 4 safety recalls and 204 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (47 complaints).
Recalls4safety recalls
Complaints204filed by owners
Crashes · fires14 · 16reported in complaints
Injuries · deaths21 · 0reported in complaints
Safety recalls
Fuel system, other › Storage › Tank assembly › Pressure relief devices
NHTSA recall 07E021000 · Mar 12, 2007 · 742 vehicles
Problem: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Fix: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Steering › Rack and pinion
NHTSA recall 03V527000 · Dec 11, 2003 · 750,283 vehicles · opened after NHTSA action (ODI)
Problem: CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Risk: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Fix: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Problem: A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
Risk: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
Fix: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings
Problem: THE LEFT FRONT BRAKE LINE CAN CONTACT THE TRANSAXLE MOUNTING BRACKET OR ATTACHMENT BOLT.
Risk: THIS CONDITION CAN CAUSE THE BRAKE LINE TO WEAR THROUGH, RESULTING IN LOSS OF BRAKE FLUID AND EVENTUAL LOSS OF ONE-HALF OF THE VEHICLE'S BRAKE SYSTEM, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Fix: DEALERS WILL INSPECT THE VEHICLE FOR PROPER BRAKE LINE CLEARANCE AND REPOSITION THOSE BRAKE LINES FOUND TO HAVE LESS THAN MINIMAL CLEARANCE. ADDITIONALLY, THOSE BRAKE LINES FOUND TO HAVE AN INDENTATION CAUSED BY THE CONTACT WILL BE REPLACED AND PROPERLY ROUTED.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
1996 Buick Regal 2-DR.
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
Not Rated
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Regal
21mpg combined
City / highway
18 / 26 mpg
Fuel
Regular Gasoline
3.1 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel
Regal
21mpg combined
City / highway
17 / 27 mpg
Fuel
Regular Gasoline
3.8 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Service brakes, hydraulic Antilock/traction control/electronic limited slip; Foundation components › Disc › Rotor
47
4
0
3
17,000 mi
Engine and engine cooling Engine; Engine › Gasoline
39
0
5
0
82,558 mi
Electrical system Ignition; Wiring › Front underhood
27
0
7
0
64,000 mi
Air bags Frontal; Side/window
22
8
0
14
98,000 mi
Steering Rack and pinion; Steering wheel/handle bar
21
2
0
0
59,087 mi
Fuel system, gasoline Delivery › Fuel pump; Fuel injection system
19
0
5
1
90,000 mi
Suspension Rear › Springs › Leaf spring assembly; Front
13
0
0
0
—
Seat belts Front › Anchorage; Front › Retractor
11
3
0
3
33,000 mi
Structure Body; Body › Door
10
0
0
0
—
Vehicle speed control Accelerator pedal; Springs
9
1
0
1
—
Power train Automatic transmission; Automatic transmission › Lever and linkage › Column shift
9
0
0
0
—
Unknown or other
9
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Jul 17, 2019 · 102,931 miles · 1 injuryAir bags ON JULY 17, 2019 AT 8:40AM, I GOT INTO MY CAR IN MY DRIVEWAY. I TURNED THE KEY IN THE IGNITION AND THE AIRBAG EXPLODED. (THE CAR WAS NOT STARTED.) THE AIRBAG SOUNDED LIKE A SHOTGUN BEING FIRED AND A POWDER LIKE SUBSTANCE IMMEDIATELY FILLED THE CAR. THE AIRBAG ITSELF HIT ME IN THE ABDOMINAL AREA. I FOUND THE DOOR HANDLE, OPENED THE DOOR, AND ROLLED OUT OF THE CAR ONTO THE GROUND. AT THIS TIME, I YELLED FOR MY SON. MY SON PICKED ME UP OFF THE GROUND AND CALLED AN AMBULANCE DUE TO ME BEING IN A SEVERE AMOUNT OF PAIN AND IN SHOCK. I WAS TAKEN TO THE HOSPITAL VIA AMBULANCE AND OBSERVED FOR THE REMAINDER OF THE DAY. I HAD SEVERAL FOLLOW-UP APPOINTMENTS THAT CONTINUE TO THIS DAY. INSURANCE CAME TO…
Apr 2, 2018Service brakes TL* THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT STATED THAT THE BRAKE AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT FACILITY FOR DIAGNOSTIC TESTING AND FAILURE CODES: C1265 (REAR ABS MOTOR CIRCUIT SHORTED TO GROUND) AND C1286 (EBCM/EBTCM FAILED TO ILLUMINATE THE RED BRAKE WARNING INDICATOR) WERE LOCATED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO THE DEALER (DON BROWN CHEVROLET, 2244 S KINGS HIGHWAY BLVD, ST. LOUIS, MO 63110, (314) 282-7887) WHERE IT WAS DETERMINED THAT THE CODES INDICATED THAT THERE WAS A REAR MOTOR SHORT TO THE GROUND AND THE ELECTRIC BRAKE CONTROL MODULE ACTIVATED THE BRAKE WARNING INDICATORS. FURTHER DIAGNOSTIC TESTING…
Feb 5, 2016 · 60,000 milesStructure › Body DRIVERS SIDE DOOR DOES NOT OPEN FROM INSIDE OR OUTSIDE. THE DOOR DOES NOT WORK WITH KEY EITHER. LOCK SEEMS TO WORKING BUT DOOR DOES NOT OPEN. THE CAR ONLY HAS 60,000 MILES ON IT. THIS IS A VERY COMMON PROBLEM WITH THIS CAR AND SHOULD BE A RECALL.
Oct 15, 2015 · 195,000 miles · fireService brakes WHILE MERGING ONTO THE FREEWAY, I WAS TAKING MY CAR TO BE SMOGGED. AT SPEED, I NOTICED A LITTLE WHITE PUFF OF SMOKE EMIT FROM THE RIGHT SIDE OF THE ENGINE BAY. AS I PROCEEDED TO START MOVING TO THE SHOULDER, THIS PUFF HAD TURNED INTO A GRAY PLUME. AS I FINALLY REACHED THE SHOULDER, THE ENTIRE FRONT OF THE ENGINE BAY WAS BILLOWING BLACK SMOKE. AS I TRIED TO STOP, THE BRAKE PEDAL WENT TO THE FLOOR, SO IT SEEMED THE FIRE HAD BURNT THROUGH A BRAKE LINE. I MANAGED TO ENGAGE THE EMERGENCY BRAKE SLOWLY AND MANAGED TO STOP ON THE SHOULDER. OPENING THE HOOD, I FOUND A SMALL FIRE BURNING AT THE REAR OF THE ENGINE, BUT IN FRONT OF THE FIREWALL. I HAD NOTHING WITH ME, SO I CALLED THE FIRE DEPARTMENT…
Mar 3, 2015 · 238,256 miles · fireEngine MY CAR STARTED TO NOT START AFTER BEING DRIVEN AND SHORTLY AFTER DID NOT WANT TO START IN A SIMPLE IDLE. SOMEHOW FUEL HAS BEEN GETTING TRAPPED IN A PRESSURIZED LINE AND I'M HAVING TO RELEASE THE FUEL OUT. OIL LEAKED INTO THE SPARK PLUGS CAUSED A PILOT FLAME. I HAVE READ MULTIPLE ACCOUNTS OF THIS HAPPENING TO THAT SPECIFIC MAKE AND YEAR AS WELL A FEW OF THE OTHER 90 MODELS. EVERY ACCOUNT SAYS IT IS A FLAW IN THE ENGINE AND FUEL SYSTEM. *TR
Feb 2, 2015 · crashSteering 1996 BUICK REGAL. CONSUMER STATED THE POWER STEERING WAS NOT CRIMPED PROPERLY. THE BALL BEARING WENT THROUGH THE GEAR BOX WHICH CAUSED THE DRIVER TO LOSE CONTROL OF THE VEHICLE AND CRASHED. THE CONSUMER DISCOVERED THERE WAS A RECALL, ON THE STEERING. HOWEVER, HE WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. *JB
Jun 29, 2012 · 55,035 milesAir bags TL* THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT STATED THAT AS THE VEHICLE WAS STARTED, THE AIR BAGS DEPLOYED ERRONEOUSLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIR. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 55,035.
Jul 17, 2010 · 182,000 miles · 1 injuryAir bags › Frontal TL*THE CONTACT OWNS A 1996 BUICK REGAL. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH, WEN THE FRONT DRIVER SIDE AIR BAG DEPLOYED INADVERTENTLY WITHOUT IMPACT TO THE VEHICLE. THE CONTACT SUSTAINED ABRASIONS TO THE LEFT FOREARM. THE VEHICLE WAS DRIVEN WITH CAUTION TO HIS RESIDENCE. THE CONTACT WAS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 182,000. UPDATED 10/20/10 *BF UPDATED 10/26/10*JB
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
EA03019 · opened Sep 15, 2003 · closed Dec 18, 2003 · led to recall 03V527000POWER RACK AND PINION STEERING FAILURE GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER…
RQ03001 · opened Jan 2, 2003 · closed Sep 15, 2003POWER RACK AND PINION STEERING FAILURE GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED…
EA02030 · opened Oct 22, 2002 · closed Mar 9, 2004 · led to recall 04V090000ENGINE COMPARTMENT FIRES EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · opened Jun 13, 2002 · closed Oct 22, 2002ENGINE COMPARTMENT FIRES
EA99026 · opened Aug 31, 1999 · closed Dec 28, 2001 · led to recall 00V171000INADVERTENT AIR BAG DEPLOYMENT There is no summary currently available
EA96023 · opened Sep 27, 1996 · closed Feb 13, 1998INAPPROPRIATE AIR BAG DEPLOYMENT THE FAILURE RATE (1.25/100K) ON THIS ISSUE IS LOW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITURE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO CLOSELY MONITOR THIS ISSUE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.