Model year record

2006 Chevrolet Corvette Z06 recalls & problems

The 2006 Chevrolet Corvette Z06 has 1 safety recall and 48 owner complaints on file with NHTSA. The most-reported problem area is engine (18 complaints).

Recalls1safety recalls

Complaints48filed by owners

Crashes · fires3 · 2reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

StructureDec 23, 2009

Body › Roof and pillars

Recall 09V49100022,090 vehicles

Problem: GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Risk: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Fix: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2006 Chevrolet Corvette Z06 2-DR

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Typical mileage*
Engine	18	0	2	37,670 mi
Electronic stability control (esc)	15	3	0	12,400 mi
StructureBody; Body › Roof and pillars	7	0	0	7,723 mi
Power trainDriveline › Differential unit	4	0	1	30,670 mi
Steering	4	0	0	32,537 mi
Electrical system	4	0	0	105,000 mi
Exterior lighting	3	0	0	—
Air bags	2	0	0	—
Fuel system, gasoline	1	0	0	—
Suspension	1	0	0	—
Traction control system	1	0	0	—
Fuel/propulsion system	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Electrical system
THE FRONT LIGHTS OF THE CAR ONE OF THEM ISN'T WORKING. I BELIEVE THIS ISN'T THE FIRST COMPLAIN ABOUT THIS KIND OF CAR. IT IS DANGEROUS TO BE DRIVING ON THE ROAD. I HAVE TO CONTINUE TO PUT MY HIGH BEAMS ON FOR THEM TO WORK. AT TIMES BOTH THE LIGHTS ARE ON AND WITH TIME DRIVING IT WILL TURN ONE OF THEM OFF. IT'S DANGEROUS BECAUSE THE VISIBILITY ON THE ROAD FOR ME AND OTHER DRIVERS.
Jan 1, 2018 · 160,000 miles
Electrical system
VALVE RATTLE, NOT DRIVING VEHICLE TO KEEP FROM DROPPING VALVE......COSTS $4K FOR REPAIR TO HEADS....31000 MILES... IF I DRIVE IT AND DROP VALVE, WILL COST $18K TO REPLACE ENGINE ASSEMBLY.....LONG TERM VALUE OF VEHICLE DECREASES WITH NON-MATCHING NUMBERS VEHICLE. ONE HELLUVA WAY TO TREAT CUSTOMERS THAT SPEND $85K ON A VEHICLE.
Jun 15, 2016 · 31,000 miles
Electronic stability control (esc)
I NEVER RECEIVED ANY NOTICE FROM GM, BUT I BROUGHT IT TO THE DEALER'S ATTENTION WHILE I WAS IN FOR A RECALL REPAIR IN 2008. I TOLD THE TECH THAT MY TRACTION CONTROL, ACTIVE STABILITY CONTROL, WASN'T WORKING PROPERLY. WHEN I RECEIVED THE CAR BACK THE TECH SAID THE TRACTION CONTROL IS FIXED AND WORKING FINE. I DIDN'T SEE HOW HE COULD HAVE SAID THAT WHEN THE CAR NEVER LEFT THE SHOP. I REALIZE NOW THAT HE WAS AWARE OF SOMETHING THAT I WASN'T. THE TRACTION WASN'T FIXED, BUT I FELT THAT I CAN'T BRING IT BACK DUE TO INCOMPETENCE. I WENT TO FORUMS AND FOUND PLENTY OF COMPLAINTS FROM OTHERS. THEN I NOTICED THAT 2005-2006 CORVETTES WITH THE RPON37 STEERING COLUMN BUILT IN 2005 WERE RECALLED FOR THIS.…
Sep 18, 2017 · 2,500 miles
Engine
I RECENTLY HAD MY VALVES TESTED BY A LOCAL SHOP SINCE IVE HEARD FROM OTHER OWNERS THAT THE LS7 VALVES DROP AT ANY GIVEN TIME. I HAD TWO VALVES OUT OF SPECS AND HAVE TO GET IT FIXED IN ORDER TO SAVE ENGINE FROM FUTURE DAMAGE. MY CAR CURRENTLY HAS 52,241 MILES.
Feb 10, 2017 · 52,241 miles
Engine
I HAD A FRIEND WHO HAD AN ENGINE FAILURE ON THIS SAME ENGINE DUE TO A FAILED EXHAUST VALVE. THE VALVE GUIDES WERE EXTREMELY WORN ON HIS CAR CAUSING THE VALVE FAILURE. DUE TO HIS FAILURE AND MANY OTHERS LIKE IT, I REMOVED MY HEADS AND INSPECTED. SURE ENOUGH, THEY WERE SIGNIFICANTLY BEYOND GENERAL MOTORS PUBLISHED TOLERANCES AND REQUIRED MACHINING TO REPAIR. THIS WAS AT SIGNIFICANT COST TO ME AND OUT OF POCKET. GM KNOWS OF THIS ISSUE AND REFUSES TO PARTICIPATE IN REPAIR COSTS FOR CARS OUT OF WARRANTY EVEN THOUGH IT'S A DESIGN FLAW AND SAFETY CONCERN. IF AND WHEN THE VALVE CATASTROPHICALLY FAILS, THE ENGINE WILL HAVE A COMPLETE SHUT DOWN, LARGE AMOUNTS OF SMOKE OUT THE EXHAUST CLOUDING THE…
Jan 1, 2014 · 55,000 miles
Engine
VALVE GUIDES OUT OF WEAR WITH POSSIBLE FAILURE INCLUDING VALVE TO DROP INSIDE COMBUSTION CHAMBER
Apr 23, 2016 · 22,269 miles
Engine
I WAS INTERNING THE INTERSTATE 15 IN CALIFORNIA AND WAS PICKING UP SPEED TO INTER THE HWY AND MY CORVETTE Z06 STARTING MAKING A KNOCKING SOUND AND LOST POWER AND I TURNED IT OFF AND HAD IT LOOKED AT MY A VERY WELL KNOW AUTOMOTIVE SHOP WHO SPECIALIZES IN GM VEHICLES. THEY TOLD ME IT DROP AN EXHAUST VALVE.
Oct 29, 2012 · 51,051 miles
Engine
I WAS CONCERNED ABOUT A NOISE THAT I WAS HEARING IN MY 2006 Z06 THAT IS UNLIKE ANY OTHER NOISE I HAVE HEARD WHILE CURRENTLY OWNING MY THREE OTHER GM VEHICLES. I DECIDED TO BRING IT TO A WELL KNOW CORVETTE SPECIALITY SHOP NEAR ME. THE TOLD ME ABOUT THE VALVE GUIDE ISSUE THAT HAS BEEN LINKED TO THE LS7 HEADS. I IMMEDIATELY TOLD HIM TO TAKE THE HEADS OFF THE CAR AND CHECK THEM. I HAD 4 EXHAUST VALVES THAT WERE WAY OUT OF GM SPECS. I HAD THE HEADS RE-MACHINED PROPERLY AND INSTALLED NEW INTAKE AND EXHAUST VALVE GUIDES, VALVE SPRINGS AND SEALS.
Oct 13, 2015 · 29,400 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Simultaneous Loss of Low-Beam HeadlightsClosedLed to recall 14V251000
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs…
EA13007 · opened Aug 23, 2013 · closed Jun 24, 2014
Loss of Low Beam HeadlightsClosed
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received…
PE13013 · opened May 6, 2013 · closed Aug 26, 2013
Electronic Stability ControlClosedLed to recall 10V172000
On April 26, 2010, at NHTSA's request following this investigation, General Motors submitted a Defect Information Report to NHTSA to correct a defect associated with the Vehicle Stability Control (VSC) system in approximately 40,000 Model Year (MY) 2005 and 2006 Chevrolet Corvette vehicles (NHTSA Recall No. 10V-172).According to the report, these vehicles may have a problem with the Steering Wheel Position Sensor (SWPS) connector created by a fretting condition in the connector (small movement of the pins back and forth creating a residue build up) which could change the electrical resistance and corrupt the information signal to the VSC computer.The VSC system uses the information from the SWPS to calculate the driver's intended vehicle direction; this information is cross referenced to sensors that tell the system which direction the vehicle is actually going and the system will, if…
EA09002 · opened Jan 14, 2009 · closed May 11, 2010
ELECTRONIC STABILITY CONTROL MALFUNCTIONClosed
ON SEPTEMBER 17, 2008, ODI OPENED PRELIMINARY EVALUATION PE08-056 TO INVESTIGATE ALLEGATIONS OF INAPPROPRIATE ACTIVATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM IN MODEL YEAR (MY) 2005 AND 2006 CHEVROLET CORVETTE VEHICLES.SOME REPORTS RECEIVED BY ODI AND SOME REPORTS TO GENERAL MOTORS (GM) CONTAINED IN GM'S RESPONSE TO PE08-056 ALLEGE THAT THE ESC SYSTEM MALFUNCTIONED CAUSING A SUDDEN AND INAPPROPRIATE BRAKING ACTION WITHOUT ILLUMINATION OF THE BRAKE LIGHTS AND CAUSING THE VEHICLE TO SWERVE LEFT OR RIGHT UNEXPECTEDLY. GM ISSUED A TECHNICAL SERVICE BULLETIN IN JANUARY 2006, LATER REVISED IN OCTOBER 2007 (BULLETIN NO. 06-02-35-002B) CONCERNING ESC PROBLEMS IN MY 2005 AND 2006 CHEVROLET CORVETTE VEHICLES WITH THE TELESCOPING STEERING WHEEL OPTION.THE BULLETIN WAS INTENDED TO CORRECT A FRETTING CORROSION PROBLEM WITH THE STEERING WHEEL POSITION SENSOR CONNECTOR C202. AN ENGINEERING…
PE08056 · opened Sep 17, 2008 · closed Jan 14, 2009