Model year record

2007 Chevrolet Corvette Z06 recalls & problems

The 2007 Chevrolet Corvette Z06 has 1 safety recall and 45 owner complaints on file with NHTSA. The most-reported problem area is engine (26 complaints).

Recalls1safety recalls

Complaints45filed by owners

Crashes · fires1 · 0reported in complaints

Injuries · deaths0 · 0reported in complaints

Safety recalls

StructureDec 23, 2009

Body › Roof and pillars

Recall 09V49100022,090 vehicles

Problem: GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Risk: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Fix: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2007 Chevrolet Corvette Z06 2-DR

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Typical mileage*
Engine	26	1	33,360 mi
Power trainDriveline	4	0	19,621 mi
Electronic stability control (esc)	4	0	16,064 mi
Exterior lighting	4	0	48,801 mi
Steering	3	0	13,000 mi
Wheels	3	0	—
Fuel/propulsion system	2	0	—
Engine and engine cooling	1	0	—
Equipment	1	0	—
Service brakes	1	0	—
Fuel system, gasolineStorage › Tank assembly	1	0	—
Electrical system	1	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Fuel/propulsion system
VEHICLE HAS A REALLY INTENSE SMELL OF GASOLINE INSIDE CABIN WHEN CARS PARKED OR IN DRIVE.
Nov 10, 2019 · 28,000 miles
Engine
THE HEAD ISSUE VALVE GUIDE ON THE HEADS WAS COMPLETELY OUT OF SPEC....HAVE REPAIRED CAR TWICE BECAUSE OF THIS ISSUE '.
Nov 28, 2012 · 64,000 miles
Electrical system
THE LAST 2 DAYS WHEN I DRIVE AT NIGHT THE HEADLIGHTS (LOW BEAMS) SHUT OFF. I SWITCH TO THE HIGH BEAMS AND THEY WORK. THIS HAS HAPPENED IN THE DARK AND IS DANGEROUS BECAUSE IT HAPPENS ABOUT 30 OR 40 MINUTES AFTER DRIVING THE CAR. I LET THE CAR SIT FOR 4 OR 5 HOURS AND THEN COME BACK AND THEY START WORKING. IT IS THE UNDERHOOD BUSSED ELECTRICAL CENTER (UBEC) HOUSING I SUSPECT.
Apr 7, 2018
Engine
DANGEROUS CONDITIONS. EXHAUST VALVE DESIGN CAUSES EAR THAT EVENTUALLY BREAKS EXHAUST VALVE AND DESTROYS ENGINE. EXHAUST VALVE LOOSE ENOUGH TO BREAK AND CAUSE ENGINE DAMAGE, POSSIBLE FIRE AND/OR FLAMMABLE FLUID LEAKAGE. HTTPS://WWW.YOUTUBE.COM/WATCH?V=WTOA3VLGOES
Mar 18, 2018 · 88,000 miles
Power train
VEHICLE IS ALWAYS STATIONARY WHEN IT GETS STUCK IN PARK, AND UNABLE TO SHIFT INTO GEAR. I LET IT SET FOR A FEW MINUTES THEN PUSH START AGAIN. SOMETIMES IT WILL SHIFT INTO GEAR AND OTHER TIMES IT WILL NOT. 50/50 CHANCE ONE WAY OR THE OTHER. THIS HAS HAPPENED SEVERAL TIMES SINCE I INHERITED THIS VEHICLE FROM MY FATHER IN EARLY 2017 WITH 48,000 MILES ON IT. FAST FORWARD TO TODAY 03/09/2018 VEHICLE DOES NOT GO INTO PARK BUT IS "STUCK" IN NEUTRAL, DOES NOT GO INTO PARK OR ANY OTHER GEAR.
Feb 26, 2017 · 48,800 miles
Fuel system, gasoline › Storage › Tank assembly
2007 CEHVROLET CORVETTE. CONSUMER WRITES IN REGARDS TO A GAS TANK LEAK. *LD THE CONSUMER REQUESTED THE MANUFACTURER'S TO COVER THE REPAIR COST. *JS
Dec 28, 2017
Engine
MY 10,000 MILE 2007 HEADS ARE AT AHP FOR REBUILDING. THEY REPORTED BACK THAT 1 EXHAUST AND 3 INTAKE GUIDES WERE WORN PAST THE SERVICE LIMIT. SEVERAL OTHERS WERE CLOSE OR AT THE LIMIT.
Jan 26, 2018 · 10,350 miles
Engine
'TAKATA RECALL' JUST BOUGHT A 2007 Z06 CORVETTE AND LATELY I'VE BEEN SEEING A LOT OF COMPLAINTS ABOUT THE VALVE STEMS BREAKING AND CAUSING CATASTROPHIC ENGINE FAILTURE CAUSING THE POWER STEERING AND BREAKS TO FAIL SO NOW I HAVE TO PAY 5000.00 + TO GET IT SERVICED AND EVERY 10K MILES DO THE SAME THING BECAUSE THE VALVE STEM AND GUIDES GET HOT AND START TO WIGGLE
Nov 22, 2017 · 59,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

Simultaneous Loss of Low-Beam HeadlightsClosedLed to recall 14V251000
On May 14, 2014, General Motors (GM) submitted a Part 573 defect information report initiating NHTSA Safety Recall 14V-251 to remedy the subject vehicles.GM will remedy a defect condition in the underhood bussed electrical center (UBEC) by modifying the vehicle's electrical harnessing.GM also announced a customer satisfaction bulletin to address this issue on model year (MY) 2008-2013 Chevrolet Corvettes.Both programs will be conducted free of charge.According to GM, when the engine heats up and cools down (from normal use), the plastic material in the UBEC housing expands at a different rate than an electrical conductor routed within it.The difference in expansion rates results in bending of the conductor, a control circuit for the low beam headlights.After multiple thermal cycles, often taking several years of use, the conductor fractures resulting in an open circuit.When this occurs…
EA13007 · opened Aug 23, 2013 · closed Jun 24, 2014
Loss of Low Beam HeadlightsClosed
The Office of Defects Investigation (ODI) opened this investigation based on 30 reports from consumers alleging that, after driving for a short time (5 to 30 minutes), both low beam headlights stopped working simultaneously and without warning. The low beam headlights remained inoperative for the remainder of the drive cycle, however no other lighting is affected.General Motors (GM) provided information in response to ODI's information request letter explaining that the loss of headlights is caused by a fractured low beam circuit wire in the underhood bussed electrical center (UBEC), a device that is similar to a fuse box. The UBEC is located in a high heat area near the engine, and the low beam circuit wire routing within the UBEC makes it susceptible to cyclical stress caused by thermal expansion.The investigation covers model years 2005-2007 Corvettes however ODI also has received…
PE13013 · opened May 6, 2013 · closed Aug 26, 2013