Model year record

2001 Chevrolet Express 3500 recalls & problems

The 2001 Chevrolet Express 3500 has 1 safety recall and 11 owner complaints on file with NHTSA. The most-reported problem area is tires (3 complaints).

Recalls1safety recalls

Complaints11filed by owners

Crashes · fires2 · 0reported in complaints

Injuries · deaths1 · 0reported in complaints

Safety recalls

EquipmentOct 24, 2007

Equipment

Recall 07E088000121,680 vehicles

Problem: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Risk: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Fix: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

What owners report

Problem area	Complaints	Crashes	Injuries	Typical mileage*
TiresTread/belt; Sidewall	3	0	0	—
Engine and engine coolingEngine	2	0	0	—
Service brakes, hydraulic	2	1	0	—
Engine	2	0	0	—
StructureBody › Bumpers	1	0	0	—
Air bagsFrontal	1	1	1	—
Steering	1	0	0	—
Electrical system	1	0	0	—
Fuel/propulsion system	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Tires › Sidewall
TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 EQUIPPED WITH DEXTERO DHT2 TIRES, SIZE: LT245/75R/16 (NA). WHILE TRAVELING AT HIGHWAY SPEEDS, THE REAR PASSENGER TIRE EXPERIENCED A BLOW OUT. THE VEHICLE WAS TOWED TO AMERICAN CUSTOM TIRE INC (1300 W MAIN ST, QUARTZSITE, AZ) WHERE IT WAS DIAGNOSED THAT THE INTERNAL SIDEWALL FAILED. THE TIRE WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND DID NOT ASSIST. THE VIN AND VEHICLE FAILURE MILEAGE WERE UNKNOWN. THE TIRE FAILURE MILEAGE WAS 1,500.
Nov 22, 2017
Electrical system
THE "PCM"-PUMP CONTROL MODULE LOCATED ON THE INJECTION PUMP THAT IS IN CHARGE OF OPERATING AND COORDINATING PUMP OPERATIONS FAILS AFTER 30,000 TO 40,000 MILES. THIS CAUSES THE VEHICLE TO STOP RUNNING--NO BRAKES OR STEERING SIMILAR TO IGNITION SWITCH PROBLEM IN OTHER VEHICLES. GM LIKES TO GET 1,400 TO FIX, AFTER THE TOW. THANKS [XXX] A BETTER FIX NEEDS TO BE MADE HERE RATHER THAN INSTALLING ANOTHER DEFECTIVE PART. THIS PROBLEM HAPPENS IN ALL THE 6.5 DIESEL MOTORS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Jun 1, 2014 · 70,000 miles
Engine
THE REAR MAIN SEAL, FRONT HARMONIC SEAL AND POWER STEERING PUMP SHAFT SEAL ARE LEAKING. THE VEHICLE HAS 96,000 MILES ON IT. THIS SHOULD NOT BE. I TOOK IT TO A SHOP LAST WEEK TO HAVE PROBLEM FIXED. NEED HELP VERY EXPENSIVE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
May 11, 2016 · 98,000 miles
Service brakes, hydraulic
BRAKE LINES SEVERELY CORRODED AND RUSTED AT MULTIPLE LOCATIONS. COMPLETE REPLACEMENT IS REQUIRED TO RENEW SAFETY INSPECTION CERTIFICATION.
Jan 5, 2012 · 68,570 miles
Service brakes, hydraulicCrash
TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 VAN. THE CONTACT WAS APPROACHING A TRAFFIC STOP WHEN HE APPLIED THE BRAKES. THE BRAKES ENGAGED MOMENTARILY AND THEN INDEPENDENTLY RELEASED. THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT STATED THE FAILURE OCCURRED ONCE PRIOR TO THE CRASH. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED THAT THE BRAKE CYLINDER SENSOR MAY POTENTIALLY HAVE CAUSED THE FAILURE AND WERE KEEPING THE BRAKE LINES CLOSED WITHOUT ALLOWING PRESSURE TO RELEASE AND STOP THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 12,419. UPDATED 10/26/10. *LJ UPDATED…
Jun 20, 2010 · 12,419 miles
Engine and engine cooling
TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 VAN. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. AS THE CONTACT WAS COASTING TO A STOP, THE VEHICLE INDEPENDENTLY RESTARTED. THE MANUFACTURER ADVISED THERE WERE NO RECALLS FOR THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 90,000.
Jul 26, 2010 · 90,000 miles
Tires
TIRE TREAD SEPARATED FROM TIRE CARCASS. *TR
Apr 16, 2007 · 43,272 miles
Air bags › FrontalCrash1 injury
TL*- THE CONTACT STATED THAT ON 12/14/06 AT 7:30 PM ON A CLEAR EVENING A SECOND VEHICLE RAN A RED LIGHT AND THE CONTACT'S VEHICLE HIT THE OTHER VEHICLE ON THE PASSENGER FRONT SIDE AT 55 MPH WITH THE 2001 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT HE LOST CONTROL OF THE VEHICLE AND HIT A DITCH HEAD ON AT 50 MPH. THE POLICE WERE CALLED, HE DIDN'T SPEAK WITH AN OFFICER BECAUSE THE CONTACT WAS FLOWN BY HELICOPTER TO THE HOSPITAL. THE CONTACT SUSTAINED BROKEN RIBS, A BROKEN PELVIS, AND OTHER INJURIES. THE CONTACT STATED THAT THE SEAT BELT HARNESS DID RESTRAIN HIM, BUT THE AIR BAG DIDN'T DEPLOY. THE NATURE OF THIS COMPLAINT IS THE AIR BAGS DID NOT DEPLOY. *AK UPDATED 2/22/2007 - *NM
Dec 14, 2006 · 47,500 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.