Model year record
2003 Chevrolet Express 3500 recalls & problems
The 2003 Chevrolet Express 3500 has no safety recalls on file with NHTSA, and 12 owner complaints. The most-reported problem area is electrical system (3 complaints).
Safety recalls
No safety recalls have been filed for the 2003 Chevrolet Express 3500.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Electrical systemWiring › Front underhood | 3 | 150,000 mi |
| VisibilityDefroster/defogger/hvac system | 2 | — |
| Fuel system, gasolineStorage › Tank assembly › Filler pipe and cap | 2 | — |
| Seat belts | 2 | — |
| StructureBody | 1 | — |
| Service brakes, hydraulic | 1 | — |
| Air bagsFrontal | 1 | — |
| Fuel/propulsion system | 1 | — |
| Engine | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Seat belts
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE SEAT BELT BUCKLES PREMATURELY DETERIORATED TO THE POINT THAT THE BUCKLES FAILED TO LOCK THE SEAT BELTS TO SECURE A PASSENGER. THE MANUFACTURER INDICATED THAT A SEAT BELT RECALL REPAIR WAS PERFORMED IN 2016, BUT THE CONTACT EXPLAINED THAT THE REMEDY MAY NOT HAVE PROVIDED A SOLUTION. THE DEALER (MARSHFIELD CHEVROLET, 14963 MO-38, MARSHFIELD, MO 65706, (866) 218-7896) WAS CONTACTED. THE CONTACT WAS UNCERTAIN AS TO WHEN THE VEHICLE WOULD BE REPAIRED DUE TO THE MANUFACTURER STATING THAT THE RECALL HAD ALREADY BEEN PROVIDED. THE MANUFACTURER ISSUED FOUR TSBS AND THREE RECALLS FOR THE SEAT BELTS. THE APPROXIMATE…
- Electrical system
WHILE DRIVING VEHICLE, ALL ELECTRICAL STOPPED, DISCOVERED THAT THE IGNITION HAD TURNED OFF BY ITSELF AND CAUSED A LOSS OF ALL POWER CREATING DANGEROUS STEERING AND STOPPING SITUATION.. I WAS ABLE TO PULL TO THE SIDE OF ROAD AND STOPPED VEHICLE. TOOK THE TRUCK TO CHEVROLET DEALER IN SARASOTA RT. 41 AND BEE RIDGE AND WAS TOLD IT WAS NOT PART OF RECALL. THIS DOES NOT MAKE SENSE, IT HAS THE SAME SYMPTOMS AS THE OTHER DEFECTIVE VEHICLES MAYBE THEY DON'T WANT TO INCREASED THEIR PROBLEMS WITH ANOTHER YEAR AND MODEL. PLEASE HELP, I AM UNABLE TO DRIVE MY TRUCK FOR WORK AND AM LOSING MONEY AND CUSTOMERS, AS I AM A GENERAL ONE MAN CONTRACTOR. PLEASE ADVISE. *TR
- Engine
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE THE TRANSMISSION FAILED TO SHIFT INTO GEAR. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE CAUSE OF FAILURE WAS UNKNOWN. HOWEVER, THE TECHNICIAN STATED THAT THE MAF CENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO STATED THAT THE VEHICLE NEEDED THE CATALYTIC CONVERTERS REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 58,500.
- Fuel/propulsion system
WHEN THE VEHICLE FUEL TANK IS FILLED, GAS FUMES ARE DETECTED AND SOME FUEL CAN BE SEEN ON THE BOTTOM OF THE TANK (A FEW DROPS OF FUEL). AS THE TANK CONTENTS LOWER THE SMELL AND LEAK GOES AWAY. AN ACCESS HOLE ON THE SIDE OF THE VAN REVEALS THAT THE TANK HAS A SMALL LEAK WHERE THE PLASTIC FILL NECK WAS BONDED TO THE TANK. THE STEEL FILL NECK AND RUBBER CONNECTION LOOK FINE. THIS IS A CONVERSION VAN W/O A LEFT HAND DOOR. THIS VEHICLE WAS BOUGHT FROM A SOUTHERN CLIMATE AREA AND IS ONLY RECENTLY BEEN BROUGHT TO A NORTHERN CLIMATE SO CORROSION IS NOT SUSPECTED. SINCE I SEE NO RECALL OR MANY COMPLAINTS, I AM LOOKING TO REPAIR OR REPLACE THE TANK. CURRENTLY LOOKING FOR A SEAL MATERIAL THAT COULD BE…
- Seat belts
TL* THE CONTACT OWNS A 2003 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE FRONT DRIVER AND REAR SEAT BELTS WOULD NOT LATCH AND ONE OF THE REAR SEAT BELTS WAS COMPLETELY INOPERABLE. THE DEALER AND MANUFACTURER WERE CONTACTED AND ADVISED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 05V558000 (SEAT BELTS). THE RECURRING FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,030 AND THE CURRENT MILEAGE WAS 65,040. UPDATED 01/20/12*LJ UPDATED 01/20/12
- Fuel system, gasoline
GAS LEAKING FROM FUEL FILLER PIPE ONTO INSIDE OF WHEEL WELL AND GROUND. EXAMINATION REVEALS DESIGN OF PIPE ASSEMBLY (METAL PIPE INSIDE CORRUGATED PLASTIC TUBE), TRAPS CONDENSATION AND WATER AROUND METAL PIPE GUARANTEEING RUST AND LEAKS. MAY BE WORSE IN HIGH HUMIDITY REGIONS BUT SAME ASSEMBLY IS OPEN TO WATER SPLASHED UP FROM ROAD. THIS MAY ONLY OCCUR ON CARGO VANS WITH LEFT HAND DOOR OPTION. UPDATED 08/11/11 *BF *KB
- Electrical systemFire
WIRE HARNESS FIRE. WATER GOT INTO THE END OF ONE OF THE CONNECTORS FROM THE WIRE HARNESS GOING INTO THE TRASMISSION. THE RESULT OF THE WATER GETTING INTO THE TRANSMISSION CAUSED AN ELECTRICAL FIRE AND CAUSED A SHORT IN THE TRANSMISSION AND ENGINE WIRE HARNESS, THE FINAL RESULT WAS THE WIRE HARNESS WAS COMPLETELY BURNED UP. THERE WAS EVIDENCE OF GLUEING THE CONNECTORS YEARS AGO.I IF THE CONNECTORS ARE NOT SEALED, IT IS POSSIBLE FOR WATER TO ENTER AND SHORT OUT CONNECTORS AND OTHER ELECTRICAL COMPONENTS. *TT
- Air bags › FrontalCrash2 injuries
I WAS IN AN ACCIDENT TRAVELING 65 MPH AND HIT ANOTHER VEHICLE BROADSIDE AND THE AIR BAG NEVER DEOLOYED. THE VEHICLE WAS TOTALED. ITS A 2003 3500 CHEVY VAN. *TR
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- Fuel Filler Pipe Corrosion/LeakageClosedLed to recall 12V388000
On August 7, 2012 General Motors (GM) notified the Office of Defects Investigation (ODI) that it will conduct a safety related recall for model year (MY) 2003-2004 Chevrolet Express and GMC Savana vehicles.The recall affects vehicles equipped with a left side cargo door and that were originally sold or currently registered in the corrosion or salt-belt states of Connecticut, Delaware, District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia and Wisconsin. Dealers are to install a new fuel filler neck. Consumer notification letters will be sent in early October 2012, when sufficient parts are available. ODI has received 12 complaints alleging unique incidents of fuel leakage during refueling of a subject vehicle. Eleven of the complaints…