The 2006 Chevrolet Silverado has 10 safety recalls and 182 owner complaints on file with NHTSA. The most-reported problem area is service brakes (83 complaints).
Recalls10safety recalls
Complaints182filed by owners
Crashes · fires8 · 7reported in complaints
Injuries · deaths2 · 5reported in complaints
2006 Chevrolet Silverado in an NHTSA crash test
Safety recalls
Exterior lighting › Headlights
NHTSA recall 08E050000 · Aug 11, 2008 · 1,921 vehicles · opened after NHTSA action (OVSC)
Problem: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Wheels › Hub
NHTSA recall 07E106000 · Dec 17, 2007 · 130,000 vehicles
Problem: CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
Risk: WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
Fix: FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Equipment › Electrical
NHTSA recall 07E066000 · Aug 28, 2007 · 175 vehicles
Problem: CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Fix: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
Wheels › Rim
NHTSA recall 06V307000 · Aug 11, 2006 · 3,227 vehicles
Problem: CERTAIN SPORT UTILITY VEHICLES AND TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES HAVE AN INCOMPLETE TIRE RIM DESIGNATION ON THE CERTIFICATION/TIRE LABEL LOCATED ON THE DRIVER'S DOOR EDGE. IN ADDITION, THE LABEL MAY ALSO BE MISSING THE TIRE LOAD RATING ON THE LABEL. ALTHOUGH THIS INFORMATION IS NOT REQUIRED BY THE STANDARD, IF A TIRE OF A LESSER LOAD RATING IS INSTALLED, THE TIRE MAY NOT BE ABLE TO SUSTAIN THE LOADS ENCOUNTERED DURING USE.
Risk: IF A CUSTOMER REPLACES A WHEEL AND ONLY RELIES ON THE RIM SIZE DESIGNATION THAT IS INDICATED ON THE LABEL, A WHEEL THAT IS OF A DIFFERENT RIM CONTOUR DESIGNATION MAY BE INSTALLED. IT MAY BE DIFFICULT OR IMPOSSIBLE TO MOUNT THE TIRE ON A WHEEL WITH THE WRONG CONTOUR. IF THE TIRE IS MOUNTED ON THE WHEEL WITH THE WRONG CONTOUR, THE WHEEL AND TIRE MAY NOT PERFORM AS INTENDED, WHICH COULD INCREASE THE RISK OF A CRASH.
Fix: A LABEL THAT WILL CORRECT THE LABEL ORIGINALLY INSTALLED WILL BE MAILED TO CONSUMERS ALONG WITH INSTALLATION INSTRUCTIONS. THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL. THE RECALL BEGAON ON NOVEMBER 7, 2006. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239, CHEVROLET AT 1-800-630-2438, AND GMC TRUCKS AT 1-866-996-9463.
Engine and engine cooling
NHTSA recall 06V289000 · Aug 3, 2006 · 38,439 vehicles
Problem: ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Risk: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Fix: DEALERS WILL REPLACE THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC TRUCKS AT 1-866-996-9463.
Exterior lighting
NHTSA recall 06E064000 · Jul 17, 2006 · 4,029 vehicles · opened after NHTSA action (OVSC)
Problem: CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Fix: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Exterior lighting
NHTSA recall 06E060000 · Jun 29, 2006 · 87,745 vehicles · opened after NHTSA action (OVSC)
Problem: CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH
Fix: AAI MOTORSPORTS WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 1, 2006. OWNERS MAY CONTACT AAI MOTORSPORTS AT 909-923-9188.
Exterior lighting › Headlights
NHTSA recall 06E023000 · Mar 13, 2006 · 292,000 vehicles · opened after NHTSA action (OVSC)
Problem: CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Equipment › Other › Labels
NHTSA recall 05V552000 · Dec 7, 2005 · 32,068 vehicles
Problem: CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
Risk: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Fix: OWNERS WILL BE PROVIDED WITH CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON MARCH 31, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, HUMMER AT 1-800-732-5493, PONTIAC AT 1-800-620-7668, SATURN AT 1-800-972-8876, OR ISUZU AT 1-800-255-6727.
Steering › Hydraulic power assist › Hose, piping, and connections
NHTSA recall 05V455000 · Oct 5, 2005 · 123,592 vehicles
Problem: CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Risk: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Fix: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
2006 Chevrolet Silverado Extended Cab
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
★★★★★
Rollover risk
18.5%
2006 Chevrolet Silverado Regular Cab
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
★★★★★
Rollover risk
18.5%
2006 Chevrolet Silverado 4-DR.
Overall
Not Rated
Frontal crash
Not Rated
Side crash
Not Rated
Rollover
★★★★★
Rollover risk
18.5%
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Silverado 15 Hybrid 2WD Hybrid
17mpg combined
City / highway
16 / 19 mpg
Fuel
Regular Gasoline
5.3 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $3,950/year to fuel
Silverado 15 Hybrid 4WD Hybrid
16mpg combined
City / highway
15 / 18 mpg
Fuel
Regular Gasoline
5.3 L · 8 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $4,200/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Service brakes
83
2
0
0
64,888 mi
Service brakes, hydraulic Antilock/traction control/electronic limited slip; Foundation components › Hoses, lines/piping, and fittings
22
0
0
0
24,000 mi
Suspension Front; Front › Wheel bearing
16
0
0
0
33,600 mi
Electrical system Wiring › Interior/under dash; Instrument cluster/panel
14
0
5
0
50,000 mi
Air bags Frontal
11
4
0
2
76,000 mi
Tires Valve; Sidewall
9
0
1
0
44,085 mi
Steering
9
2
0
0
15,000 mi
Power train Automatic transmission; Driveline
8
0
0
0
35,789 mi
Engine and engine cooling Exhaust system › Manifold/header/muffler/tail pipe; Engine
7
0
2
0
59,800 mi
Structure Body; Body › Door
6
1
0
0
34,500 mi
Wheels Lugs/nuts/bolts/studs; Rim
6
1
0
0
42,000 mi
Exterior lighting Headlights
5
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Jul 1, 2019 · 200,000 milesTires The contact owns a 2006 Chevrolet Silverado 1500 equipped with Continental General Grabber STX tires, tire size 24570R17, DOT Number vynhhm55. The contact stated that all four tire sidewalls had begun to deuterating exposing the white another. The vehicle returned the tires to Walmart where they purchased the tires from who confirmed the tires needed to be replaced. The tires had not been replaced. The manufacturer was not made aware of the issue. The vehicle's approximate mileage of 72,000. The tire's approximate failure mileage was 169,000 with the first set of tires purchased and 169,000 miles with the second set of tires. The contact was unsure of which tires had what mileage due to…
Jan 26, 2016 · 98,000 milesService brakes RUSTED BRAKE LINE RESULTING IN TOTAL BRAKE FAILURE WHILE DRIVING AND ATTEMPTING TO STOP
Nov 15, 2015 · 86,642 milesService brakes TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING 35 MPH AND ATTEMPTING TO DECREASE IN SPEED, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,642.
Oct 8, 2015 · 96,000 milesService brakes THIS VEHICLE HAS HAD MULTIPLE BRAKE ISSUES SINCE NEW. FIRST OFF, IT GOES THROUGH FRONT BRAKE PADS AND ROTORS TOO FREQUENTLY. FIRST REPLACED AROUND 25K AND AGAIN AROUND 60K. THIS VEHICLE HAS MOSTLY BEEN USED FOR LONG HIGHWAY TRIPS, NY TO FL ETC., NOT AROUND TOWN. USED IN RURAL AREA. NEXT, SEVERAL BRAKES LINES HAVE BURST AND HAD TO BE REPLACED. THE LAST INCIDENT LUCKILY WAS IN MY DRIVEWAY. HAVING DUAL BRAKE CYLINDERS ON THESE TRUCKS DOES NOT SEEM TO HELP IF A BRAKE LINE BURSTS. I NEEDED THE EMERGENCY BRAKE TO STOP IT ON ALMOST FLAT GROUND. A RECURRING PROBLEM IS WITH THE ABS. EVIDENTLY THEY RUST EASILY, ESPECIALLY IN SALT BELT STATES, THEN CORROSION ON THE SENSOR AND HUB CAUSES IT TO ACTIVATE…
Sep 17, 2015 · 57,000 milesService brakes MY VEHICLE WITH 57,000 MILES HAD THE BRAKES GO OUT WHILE DRIVING WITHOUT WARNING. I TOOK IT TO A MECHANIC WHO SAID THE FRONT BRAKE LINES HAD RUSTED AND BROKE. I HAVE HAD THE WORK COMPLETED. I FEEL THIS IS A PRODUCT DEFECT FOR A LOW MILEAGE VEHICLE. IT IS VERY WELL TAKEN CARE OF AND HAS VERY FEW MILES ON IT, AND I HAVE OWNED IT SINCE IT WAS NEW. I HAVE BEEN IN CONTACT WITH CHEVROLET AND THEY WILL NOT PROVIDE ME WITH ANY ANSWERS. THEY KEEP TELLING ME TO TAKE IT TO A DEALERSHIP, HOWEVER THE DEALERSHIP HAS TOLD ME THERE IS NOTHING THEY CAN DO.
Mar 22, 2010 · 70,000 miles · crash · 1 injuryAir bags TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING AT 25 MPH, ANOTHER VEHICLE FAILED TO YIELD. AS A RESULT, THE CONTACT CRASHED INTO THE PASSENGER SIDE OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HIP AND PELVIC INJURIES ON THE RIGHT SIDE THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
Sep 8, 2015 · 24,905 milesService brakes WHILE APPROACHING A TRAFFIC SIGNAL MY BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I DROVE MY VEHICLE SLOWLY HOME AND CHECKED BRAKE FLUID LEVEL. IT WAS LOW AND I TOPPED IT OFF. I TRIED THE BRAKES AGAIN AND ONCE AGAIN THE PEDAL WENT TO FLOOR. I WENT UNDER THE VEHICLE AND BRAKE FLUID WAS DRIPPING OFF THE CROSS MEMBER JUST BEHIND THE ENGINE. I COULD SEE THAT ALL THE BRAKE LINES WERE VERY RUSTY. I WAS ABLE TO GET THE VEHICLE TO BIG O TIRES. AFTER INSPECTION, IT WAS FOUND THAT THE BRAKE LINE HAD RUSTED THROUGH AND ALL THE OTHERS WERE IN VERY BAD SHAPE AND I HAD ALL THE LINES REPLACED. AFTER SOME RESEARCH I FOUND THIS WAS A KNOWN PROBLEM AND GM HAS REDESIGNED THE LINES BUT, REFUSED TO RECALL AND…
Oct 31, 2013 · 9,000 milesService brakes TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS COMING TO A STOP, THE ANTI-BRAKE SYSTEM ENGAGED INDEPENDENTLY AND CAUSED THE BRAKES TO FAIL. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 9,000.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
