2002 Chevrolet Van recalls & problems

Safety recalls

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

• Service brakes, hydraulic

  2002 ASTRO VAN BECOMES DIFFICULT TO STOP . FEELS LIKE THE HYDRAULIC BOOSTER FAILS TO ENGAGE, NECESSITATING EXTREME PRESSURE TO BE APPLIED TO THE BRAKE PEDDLE TO STOP THE VEHICLE. THIS SITUATION TOOK PLACE FAIRLY OFTEN. AFTER REMOVING THE ABS FUSE THE BRAKES ARE WORKING FINE. *TR

  Feb 1, 2011 · 150,000 miles
• Equipment › Appliance › Air conditioner

  I OWN A 2002 CHEVROLET VENTURE AWD. RECENTLY, I NOTICED AN OILY SUBSTANCE COMING FROM THE RIGHT, PASSENGER SIDE OF THE VAN. UPON FURTHER INVESTIGATION, I DISCOVERED THAT THE OIL WAS COMING FROM THE AIR CONDITIONER (A/C ) CONDENSER, DETERMINING THAT THE AIR CONDITIONER DID NOT WORK. IT WORKED FINE UNTIL THIS TIME. I CALLED REPAIR SHOPS, AND FOUND OUT THAT THE REPLACEMENT A/C CONDENSER WAS DESIGNED A LITTLE DIFFERENT, AND/OR THE WAY OF MOUNTING IT HAS BEEN UPGRADED. ALSO, I HAVE BEEN TOLD THAT THIS WAS COMMON ON THE PONTIAC MONTANA VANS. THE COST TO FIX IT WAS ANYWHERE FROM $975.00 TO $1175.00. NOW, IF THIS WAS A FLAW IN THE DESIGN, AND IT' WAS ILLEGAL TO VENT R-134A FREON INTO THE AIR, WHY…

  Mar 26, 2007 · 73,000 miles
• Suspension › Front › Wheel bearing

  CORROSION IN FRONT HUB BEARINGS LEADING TO PREMATURE AND ERRATIC ABS SENSOR PROBLEMS AND PULLING OF VEHICLE TO THE RIGHT. THIS OCCURS AT SLOW SPEED. GM HAS RECOGNIZED THIS PROBLEM AND HAS SELCTIVELY RECALLED CERTAIN MAKES OF AUTOMOBILES IN CERTAIN STATES. MY CHEVY ASTRO WAS NOT RECALLED. THE MECHANIC WHO REPAIRED THE PROBLEM (COST $1081) SAID THERE IS NO QUESTION IT IS THE SAME PROBLEM THAT THE RECALLED VEHICLES HAVE (INCLUDING HIS!). GM IS STONEWALLING IN ORDER TO SAVE MONEY. THIS PROBLEM HAS BEEN SHOWING UP FOR THE PAST COUPLE OF MONTHS AND WAS GETTING WORSE. *NM

  Nov 8, 2006 · 76,000 miles
• Fuel system, gasoline › Storage › Tank assembly › Filler pipe and cap

  ON SEPTEMBER 15, 2005 I FILLED MY GAS TANK UP FOR THE NEXT WEEK. ON SATURDAY SEPTEMBER 17,2005 I WENT TO GO TO THE STORE AND SMELLED GAS. MY HUSBAND LOOKED UNDER THE VAN AND STATED THAT GAS WAS LEAKING. I CALLED OUR MECHANIC MONDAY SEPTEMBER 19,2005 TOLD THEM WHAT WAS GOING ON. DROPPED THE VAN OFF TO THE MECHANIC TUESDAY SEPTEMBER 20,2005. UPON INSPECTION THEY NOTICED THAT THE FILL A NECK HOSE TO THE TANK AND ATTACHING HOSE IN CRACKED 80% AROUND. TO CORRECT THE PROBLEM THEY HAVE TO DROP MY ALMOST FULL TANK OF GAS AND REPLACE THE TANK AND ATTACHING PIECES. *NM

  Sep 20, 2005 · 44,682 miles
• Seat beltsCrash5 injuries

  WE WERE INVOLVED IN A CRASH, A DRUNK DRIVER HIT OUR 2002 CHEVY ASTRO VAN IN THE FRONT LEFT SIDE BY A DODGE DAKOTA. WE WERE TRAVELING 35 MPH, OTHER VEHICLE SPEED UNKNOWN. THERE WERE 5 RESTRAINED PASSENGERS IN THE VEHICLE, THE 2ND ROW RIGHT PASSENGER'S SEAT BELT DID NOT RESTRAIN HER DURING THE ENTIRE CRASH. SHE HAD BRUSES ON HER LEFT HIP, RIGHT BREAST, RIGHT SHOULDER AND RIGHT ARM. (THE AIR BAGS DID NOT DEPLOY). SHE WOULD UP ON THE FLOOR BETWEEN THE BUCKET SEATS WITH HER LEGS UNDERNEATH HER. THE SEAT BELTS ARE BEING REPLACED (4 ARE COMPLETE, 1 THE CHEVY DEALER IS HAVING TROUBLE GETTING THE RIGHT PART). I HAVE THE OLD PARTS IN MY POSSESSION. WE WERE UNABLE TO DRIVE THE VEHICLE FROM THE CRASH…

  Mar 26, 2005 · 64,000 miles
• Tires › Tread/belt

  DRIVING CHEVROLET E3500 VAN WHEN LEFT REAR ORIGINAL EQUIPMENT FIRESTONE STEELTEX RADIAL R4S SEPARATED AND DAMAGED VAN. BODY DAMAGE TO VAN. RIGHT REAR TIRE HAS CRACK AROUND TREAD LIKE FIRESTONE WILDERNESS. *NLM

  May 12, 2003
• Visibility › Rearview mirrors/devices

  CONSUMER WANTED TO KNOW THE STATUS OF A VEHICLE OWNER'S QUESTIONNAIRE. *DT THE VEHICLE EXPERIENCED A PROBLEM WITH THE MIRRORS.*JB

  Sep 13, 2002
• Tires › Tread/belt

  WHILE TRAVELING ABOUT 60MPH ON HIGHWAY, VEHICLE STARTED TO VIBRATE. CONSUMER WAS ABLE TO PULL OVER TO THE SHOULDER. RIGHT REAR TIRE TREAD SEPARATED FROM WHEEL. FIRESTONE, P215/70R DEALERSHIP IS AWARE OF PROBLEM.*AK FIRESTONE REPLACED ALL FOUR TIRES. *SLC

  Aug 7, 2002

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

• HYDRAULIC PUMP FAILRESClosedLed to recall 05V005000

  GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.

  EA04012 · opened Apr 30, 2004 · closed Feb 28, 2005