Model year record
2003 Dodge Sprinter recalls & problems
The 2003 Dodge Sprinter has no safety recalls on file with NHTSA, and 15 owner complaints. The most-reported problem area is tires (11 complaints).
Safety recalls
No safety recalls have been filed for the 2003 Dodge Sprinter.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| TiresValve; Tread/belt | 11 | 16,500 mi |
| Engine and engine coolingExhaust system | 3 | — |
| Power trainAutomatic transmission; Automatic transmission › Control module (tcm/pcm/tecm) | 2 | — |
| Electrical systemWiring › Front underhood | 2 | — |
| Service brakes, hydraulicFoundation components › Disc › Rotor | 1 | — |
| Vehicle speed control | 1 | — |
| VisibilityWindshield | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Visibility › Windshield
TL* THE CONTACT OWNS A 2003 DODGE SPRINTER 2500 EQUIPPED WITH A PGW WINDSHIELD, TINT-LAMINATED, PART NUMBER DW01488GBNN. THE CONTACT STATED THAT THE WINDSHIELD WAS REPLACED BECAUSE IT WAS DAMAGED BY A STONE. THE CONTACT STATED THAT THE WINDSHIELD WAS DISTORTED AND DIFFICULT TO SEE THROUGH. THE CONTACT CALLED THE COMPANY WHO INSTALLED THE WINDSHIELD WHO TOLD HIM TO DRIVE THE VEHICLE FOR A FEW WEEKS AND IF HE WAS STILL NOT SATISFIED, THEY WOULD REPLACE IT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 104,000 UPDATED 1/21/11 *CN UPDATED 03/09/11
- Engine and engine cooling › Exhaust system
TL* THE CONTACT OWNS A 2003 CHRYSLER SPRINTER 2500. ON JULY 29, 2010, THE CONTACT RECEIVED THE RECALL NOTICE, NHTSA CAMPAIGN ID NUMBER: 09V418000 - COMPONENT: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. THIS RECALL WAS FOR AN ISSUE WITH CORROSION ON THE INTAKE MANIFOLD. WHEN THE CONTACT RECEIVED THE RECALL NOTICE HE CONTACTED THE DEALERSHIP IN REGARDS TO GETTING THE RECALL REMEDY PERFORMED. AT THAT TIME THE CONTACT WAS INFORMED THAT THE PARTS WERE CURRENTLY NOT IN STOCK. THE CONTACT CALLED THE DEALERSHIP TODAY, AUGUST 27, 2010 AND WAS INFORMED THAT THE PARTS FOR THE RECALL WOULD NOT BE IN STOCK UNTIL SEPTEMBER 23, 2010. THE CONTACT FEELS THAT THE DEALERSHIP IS NOT HANDLING THIS RECALL IN A…
- Engine and engine cooling › Exhaust system
CONSUMER WRITES REGARDING CHRYSLER NON-COMPLIANCE WITH SAFETY RECALL J32-DODGE SPRINTER 03 MANIFOLD/EGR *TGW THE CONSUMER STATED HE SPENT THE PAST WEEK IN REPEATED UNSUCCESSFUL EFFORTS TO ARRANGE THE NECESSARY MODIFICATIONS WITHOUT HAVING TO INCUR UNREASONABLE EXPENSES. THE CONSUMER BELIEVED CHRYSLER WAS MAKING A DELIBERATE EFFORT TO EVADE THE RECALL BY CREATING HARDSHIPS AND OBSTACLES. *JB
- Engine and engine cooling › Exhaust system
2003 DODGE SPRINTER. CONSUMER STATES DEFECTIVE INTAKE MANIFOLD. CONSUMER STATES THAT A NOTICE FROM CHRYSLER REGARDING ARRANGEMENTS TO REPAIR THE DEFECT HAS NOT BEEN RECEIVED *TGW
- Vehicle speed control
TL*THE CONTACT OWNS A 2003 DODGE SPRINTER. THE CONTACT STATED THAT THE THROTTLE PEDAL FAILED WHICH MADE IT IMPOSSIBLE TO ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES AND THEY COULD NOT FIND THE FAILURE. THE MANUFACTURER WAS CALLED AND STATED THAT THEY WERE UNABLE TO REPAIR THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 50,000. THE CURRENT MILEAGE WAS 100,000.
- Tires › Valve
I HAVE HAD 3 VALVE STEM FAILURES WHERE THE STEM GOES INTO THE RIM IN APPROX 6 WEEKS OF TIME RESULTING IN FLAT TIRES. LAST ONE WAS WHILE PARKED BUT WAS RAPID DEFLATION TOLD STEMS FROM THE FACTORY WERE NOT THE CORRECT STEMS. REPLACED BY THE DEALER FOR FREE ALL STEMS. *JB
- Electrical system
I PURCHASED A 2003 DODGE INTREPID IN NOVEMBER OF 2005 AND THE CAR RUNS FINE UP UNTIL ABOUT A MONTH AND A HALF AGO. THE CHECK ENGINE LIGHT CAME ON AND THE CAR WOULD GET STUCK IN ONE GEAR AND MY RPM WOULD GO UP INTO THE RED LINE UNLESS I PULLED OVER AND RESTARTED THE CAR. OTHER TIMES IT WOULD GET STUCK AND THEN JERK INTO THE NEXT GEAR. THEN ABOUT FOUR DAYS AGO I WAS ON THE FREEWAY AND THE WHOLE CAR JUST SHUT OFF. I COULD NOT MOVE IT AND TRAFFIC WAS SPEEDING PAST ME AND A FEW HAD TO SLAM ON BREAKS TO AVOID HITTING ME AND MY TEN MONTH OLD DAUGHTER. I HAD TO HAVE SOME PEOPLE HELP ME TO PUSH IT OFF THE FREEWAY SO THAT I COULD RESTART IT TO MAKE IT BACK HOME. I AM VERY FRIGHTENED TO DRIVE NOW…
- Service brakes, hydraulic › Foundation components › Disc › Rotor
- HAD BRAKES ON 2003 DODGE SPRINTER CHECKED BY LOCAL MECHANIC. SAID THAT THERE WAS ABOUT 40% BRAKE PAD LEFT BUT THE ROTORS WHERE EXTREMELY WORN. I AM WONDERING IF ROTOR LIFE GOES PAST THE BRAKE LIFE AND COULD BE A DANGER. DEALER SAID ROTORS ARE CHANGED EVERYTIME WITH PAD CHANGE! *NM
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- TIRE VALVE FAILUREClosedLed to recall 04V600000
ODI OPENED PE04-066 TO INVESTIGATE FIVE COMPLAINTS ALLEGING TIRE VALVE FAILURE IN MY 2003-04 SUBJECT VEHICLES.SOME OF THE COMPLAINTS ALLEGED MULTIPLE TIRE VALVE FAILURES FOR A SINGLE VEHICLE.ON DECEMBER 16, 2004, DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL (DCMI) NOTIFIED NHTSA OF A SAFETY DEFECT IN APPROXIMATELY 23,000 MY 2002-05 SPRINTER 2500 VEHICLES EQUIPPED WITH TR-600 TIRE VALVES PRODUCED BY ALLIGATOR VENTILFABRICK GMBH (RECALL 04V-600).THE NOTIFICATION IDENTIFIED THE CHEMICAL SPECIFICATION OF THE RUBBER COMPONENTS AND AN UNSTABLE SUPPLIER PRODUCTION PROCESS, WHICH RESULTED IN INADEQUATE MIXING OF THE RUBBER COMPONENTS, AS THE FACTORS CONTRIBUTING TO THIS DEFECT.AS A RESULT OF THESE FACTORS, CRACKS CAN DEVELOP WITHIN THE RUBBER PART OR BETWEEN THE METAL AND THE RUBBER PARTS OF THE VALVE STEM, WHICH CAN LEAD TO A LOSS OF AIR PRESSURE AT THE VALVE STEM AND MAY POSE A RISK TO MOTOR…