Model year record

1996 Dodge Stratus recalls & problems

The 1996 Dodge Stratus has 11 safety recalls and 554 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (360 complaints).

Recalls11safety recalls

Complaints554filed by owners

Crashes · fires36 · 36reported in complaints

Injuries · deaths26 · 1reported in complaints

Safety recalls

SuspensionDec 27, 2010

Front › Control arm › Lower arm

Recall 10E05900022,689 vehicles

Problem: FEDERAL-MOGUL IS RECALLING CERTAIN REPLACEMENT CONTROL ARM ASSEMBLIES, PART NUMBERS K7425, 10945, FA4510X, K7427, 10946, AND FA4611X, SOLD FOR USE ON VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE BALL JOINT ON THE CONTROL ARM ASSEMBLY CAN FAIL CAUSING THE BALL STUD TO WEAR THROUGH THE CONTROL ARM HOUSING RESULTING IN NOISE AND/OR SEPARATION OF THE BALL STUD FROM THE HOUSING.
Risk: IF THERE IS A SEPARATION OF THE BALL STUD FROM THE HOUSING, THE DRIVER CAN LOOSE STEERING CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: FEDERAL-MOGUL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED CONTROL ARMS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 28, 2011. OWNERS MAY CONTACT FEDERAL-MOGUL AT 1-877-489-6659.

SuspensionOct 9, 2009

Front › Control arm › Lower ball joint

Recall 09E0560005,787 vehicles

Problem: QUALIS AUTOMOTIVE IS RECALLING CERTAIN AFTERMARKET BALL JOINTS SOLD FOR USE ON CERTAIN PASSENGER VEHICLES. THE SOCKET MAY HAVE BEEN EXCESSIVELY HARDENED WHICH COULD CAUSE IT TO CRACK NEAR THE RETAINING RING GROOVE ALLOWING THE BALL STUD TO SEPARATE UNDER IMPACT LOAD. THE SUBJECT BALL JOINTS WERE SOLD AS FOUR PART NUMBERS, D10945, D10946, G10945, AND G10946. THE AFFECTED CONTROL ARMS, D10945 AND D10946, ARE STAMPED WITH THE FOLLOWING DATES ON THE BALL JOINTS: 134308, 135708, 100109, 102709, 104109, 105509, 107609, 108909, 110309, 113209, AND 116609. THE G10945 AND G10946 ARE THE SAME PART AS THE D10945 AND D10946 RESPECTIVELY. THEY ARE LABELED DIFFERENTLY DEPENDING ON THE AFTERMARKET CUSTOMER.
Risk: SEPARATION OF THE BALL STUD FROM THE SOCKET OF THE BALL JOINT HOUSING WOULD ALLOW THE CONTROL ARM TO COLLAPSE AND THE WHEEL TO FOLD IN CAUSING LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.
Fix: QUALIS AUTOMOTIVE WILL REPLACE THE BALL JOINTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT QUALIS AUTOMOTIVE AT 1-800-493-4128.

Fuel system, gasolineNov 2, 2006

Delivery › Fuel pump

Recall 06E09100024,358 vehicles

Problem: CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Risk: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.

Fuel system, gasolineOct 23, 2006

Delivery › Fuel pump

Recall 06E08800039,243 vehicles

Problem: CERTAIN TIGAS FUEL PUMP MODULES MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006, SOLD UNDER VARIOUS BRAND NAMES AND P/NOS. THESE FUEL PUMP MODULES ARE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
Risk: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Fix: TI AUTOMOTIVE WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 6, 2006. OWNERS MAY CONTACT TI AUTOMOTIVE TOLL-FREE AT 1-877-461-1834.

Power trainJan 13, 2004

Automatic transmission › Lever and linkage › Floor shift

Recall 04V0210002,315,768 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Risk: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Fix: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Power trainAug 6, 1998

Automatic transmission › Park/neutral start interlock switch

Recall 98V183000685,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Risk: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Fix: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.

SuspensionNov 13, 1997

Front › Control arm › Lower ball joint

Recall 97V201000599,000 vehiclesopened after NHTSA action (ODI)

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Risk: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.

StructureJun 6, 1997

Body › Hood › Hinge and attachments

Recall 97V095000219,000 vehicles

Problem: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SECONDARY HOOD LATCH SPRING CAN DISENGAGE FROM ITS RETENTION HOLE IF THE HOOD IS SLAMMED SHUT.
Risk: IF THIS CONDITION OCCURS SIMULTANEOUSLY WITHOUT ENGAGING THE PRIMARY LATCH, THE HOOD WOULD NOT BE RESTRAINED INCREASING THE RISK OF A VEHICLE CRASH.
Fix: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH SPRING WITH A LONGER END HOOK SPRING.

Service brakes, hydraulicMay 3, 1996

Foundation components › Master cylinder

Recall 96V075000151,800 vehicles

Problem: THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Risk: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Fix: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.

Service brakes, hydraulicMay 2, 1996

Antilock/traction control/electronic limited slip

Recall 96V07400090,000 vehicles

Problem: CORROSION OF THE ABS HYDRAULIC CONTROL UNIT CAN CAUSE THE SOLENOID VALVES TO STICK IN THE OPEN POSITION.
Risk: IF EITHER FRONT WHEEL VALVE STICKS, THE VEHICLE WOULD SWERVE FROM A STRAIGHT STOP WHEN THE BRAKES ARE APPLIED.
Fix: DEALERS WILL INSTALL A PLATE AND SILICONE GREASE INJECTED INTO THE SOLENOID CAVITY TO ELIMINATE THE POTENTIAL FOR THIS CONDITION.

Engine and engine coolingJan 11, 1996

Engine › Gasoline

Recall 96V00600040,000 vehicles

Problem: IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Risk: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Fix: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1996 Dodge Stratus 4-DR.

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Stratus

26mpg combined

City / highway	22 / 33 mpg
Fuel	Regular Gasoline

2 L · 4 cyl · Manual 5-spd · Front-Wheel Drive · about $2,600/year to fuel

Stratus

22mpg combined

City / highway	19 / 28 mpg
Fuel	Regular Gasoline

2 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,050/year to fuel

Stratus

21mpg combined

City / highway	18 / 26 mpg
Fuel	Regular Gasoline

2.4 L · 4 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel

Stratus

21mpg combined

City / highway	18 / 26 mpg
Fuel	Regular Gasoline

2.5 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,200/year to fuel

Stratus

20mpg combined

City / highway	17 / 26 mpg
Fuel	Regular Gasoline

2.5 L · 6 cyl · Automatic 4-spd · Front-Wheel Drive · about $3,350/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Engine and engine coolingEngine; Engine › Gasoline	360	1	23	2	90,000 mi
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components	75	9	0	4	100,000 mi
Power trainAutomatic transmission; Manual transmission	66	1	3	1	60,500 mi
SteeringLinkages › Tie rod assembly; Linkages	48	1	1	0	80,000 mi
Electrical systemWiring › Front underhood; Ignition › Module	38	1	10	2	80,000 mi
SuspensionFront; Front › Control arm › Lower arm	37	3	0	1	116,000 mi
Air bagsFrontal; Side/window	18	15	0	10	—
Unknown or other	18	1	0	2	—
StructureBody › Door; Body › Trunk lid	15	0	0	0	—
VisibilityDefroster/defogger/hvac system; Windshield wiper/washer	15	1	0	0	—
EquipmentAppliance › Air conditioner; Electrical › Radio/tape deck/cd etc.	15	0	0	0	—
Fuel system, gasolineStorage › Tank assembly; Delivery	13	0	3	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Wheels
R&R FRONT LEFT WHEEL BEARING FIX, HUB & BEARING ASSEMBLY TOTAL COST $214.55 CLEAN ENGINE TOTAL COST $83.46 ENGINE OIL LEAK, TRIED OIL STOP LEAK & SEEMS TO BE WORKING FOR THE TIME BEING. RADIATOR/ANTIFREEZE LEAK, I'M SPENDING $150 MONTH FOR ANTIFREEZE. PUTTING IN 1-2 BOTTLES A DAY. PROBABLY WILL HAVE RADIATOR FIXED SOON. MUFFLER FELL OFF, CAN'T AFFORD A NEW ONE. NEEDS NEW SPARK PLUGS, CAN'T AFFORD THAT EITHER. NEEDS MANIFOLD GASKET, CAN'T AFFORD THAT EITHER. NEEDS OIL PAN GASKET, CAN'T AFFORD THAT EITHER. NEEDS NEW WIPERS, CAN'T AFFORD THAT EITHER. *TR
Dec 4, 2014 · 167,000 miles
Tires
GENERAL TIRE ALTIMAX RT SIZE 195/70R14 BULGE ON SIDEWALL WHEN INSTALLED A BRAND NEW TIRE. AFTER INSTALLATION OBSERVED ONE OF FOUR TIRES WITH A BULGE ON SIDEWALL OF TIRE. BULGE NOT AN INDENTATION. VEHICLE WAS NOT DRIVEN AND NO OBVIOUS INSTALLATION OR BEAD DAMAGE FROM THE OUTSIDE. INSTALLER SAID SMALL BULGE BUT MAY GROW. SENT PICTURES TO DISCOUNTTIREDIRECT AND THEY SEEMED TO THINK INSTALLATION BEAD DAMAGE. TOOK TIRE OFF, NO DAMAGE FOUND INSIDE OR OUTSIDE OR ANY BEAD IRREGULARITIES. SEEMS LIKE A MANUFACTURER DEFECTIVE BUILD. OTHER 3 TIRES WERE FINE ON ALL SIDES. *TR
Jun 6, 2014
Suspension › Front › Control arm › Lower ball jointCrash
TL* THE CONTACT OWNS A 1996 DODGE STRATUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE FRONT DRIVERS SIDE TIRE SEPARATED FROM THE VEHICLE, STRUCK THE CURVE AND TRAVELED INTO TRAFFIC. THE VEHICLE WAS LATER TOWED TO THE CONTACT'S RESIDENCE. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND ADVISED HER THAT THE LOWER BALL JOINTS SEPARATED FROM THE SOCKET. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HER THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 09E056000 (SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT). THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 116,000. UPDATED 02/28/13 *BF THE LOWER BALL JOINT AND AXLE WERE REPLACED.
Dec 16, 2012 · 116,000 miles
Electrical systemFire
TL* THE CONTACT OWNED A 1996 DODGE STRATUS. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE UNEXPECTEDLY ENGULFED INTO FLAMES. THE VEHICLE WAS UNOCCUPIED AND THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES, WHICH ORIGINATED UNDERNEATH THE HOOD. THE VEHICLE WAS COMPLETELY DESTROYED AND REMAINED AT THE RESIDENCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Mar 23, 2012 · 120,000 miles
Electrical system
TL* THE CONTACT OWNS A 1996 DODGE STRATUS. THE CONTACT STATED THAT THE HORN WOULD ACTIVATE WITHOUT COMMAND AT ANYTIME AND THE AIRBAG LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER REPAIRED THE FAILURE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 80,000. UPDATED 08/31/11 *BF THE STEERING COLUMN WAS REPLACED TWICE. THE LAST TIME, THE DEALER PLACED A HORN BUTTON ON THE DASHBOARD. UPDATED 12/05/11
Jul 20, 2009 · 60,000 miles
Unknown or other
I JUST BOUGHT A 1996 DODGE STRATUS AND IT HAS MUTIPLE PROBLEMS. THE MAIN THING IS IT STALLS AND DIES WHILE YOUR DRIVING DOWN THE ROAD AND HAS ALMOST CAUSED A CRASH MORE THAN ONCE. IT HAS RECALLS AND IAM GOING TO TAKE IT TO HAVE IT FIXED. IT ALSO HAS OTHER PROBLEMS LIKE WITH THE DOOR LOCKS,THE HOOD AND THE TRUNK. *TR
Jun 5, 2011 · 155,008 miles
Engine and engine cooling
MY CAR HAD THE HEAD GASKET REPLACED AND A FEW OTHER THINGS ON IT. BUT I CAN SMELL BURNING OIL FROM SOME WERE AND THE LIGHT IS ON FOR THE OIL. I ONLY DRIVE SHORT DISTANCES BECAUSE I AM AFRAID OF A FIRE. NOT ONLY THAT IT WELL MAYBE ONLY GO ABOUT 2 MILES BEFORE IT SHUTS DOWN. THEN I HAVE TO WAIT FOR IT TO COOL DOWN TO START IT AND GET IT BACK HOME. *TR
Jul 1, 2006
Power train › Automatic transmission › Control module (tcm/pcm/tecm)Fire
TL*THE CONTACT OWNS A 1996 DODGE STRATUS. WHILE THE VEHICLE WAS PARKED AT A GAS STATION, THE CONTACT WAS INFORMED THAT HER VEHICLE WAS SMOKING UNDER THE HOOD. SHE WAS ABLE TO TAKE THE VEHICLE TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE ENGINE COMPARTMENT SUFFERED A MELT DOWN. A REPORT WAS FILED WITH THE MANUFACTURER, BUT THEY WOULD NOT ASSIST. THE CURRENT AND FAILURE MILEAGES WERE 193,000. UPDATED 8/7/09 *CN THE PCM AND POWER SHIFTER WERE FAULTY. UPDATED 08/11/09.*JB
Jun 2, 2009 · 193,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

AUTO TRANS IGNITION-PARK INTERLOCKClosedLed to recall 04V021000
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE…
EA03011 · opened Jul 17, 2003 · closed Jan 30, 2004
SAFETY BELT CINCHING LATCH PLATEClosed
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE02082 · opened Nov 6, 2002 · closed Apr 23, 2003
LOWER CONTROL ARM BALL JOINT FAILUREClosedLed to recall 97V201000
BY LETTER DATED NOVEMBER 6, 1997, THE MANUFACTURER ADVISED THIS AGENCY OF ITS DECISION TO INITIATE A SAFETY RECALL CAMPAIGN OF THE SUBJECT VEHICLES TO CORRECT THE DEFECT IDENTIFIED IN THIS EA.THE RECALL WILL ALSO COVER 1996 AND 1997 CHRYSLER CIRRUS/DODGE STRATUS VEHICLES, AS WELL AS 1995 THROUGH 1997 CHRYSLER SEBRING CONVERTIBLE AND PLYMOUTH BREEZE VEHICLES EQUIPPED WITH IDENTICAL LOWER CONTROL ARM BALL JOINTS.AN ESTIMATED TOTAL OF 599,00VEHICLES ARE AFFECTED BY THIS RECALL.THE MANUFACTURER'S INVESTIGATION DISCLOSED THAT PROCESS VARIABILITY, TOGETHER WITH THE BALL JOINT HOUSING COVER CRIMPING OPERATION, CAN RESULT IN AN INEFFECTIVE SEAL THAT PERMITS A LOSS OF LUBRICATION AND ACCELERTED WEAR OF THE BALL JOINT ASSEMBLY.THIS CONDITION CAN LEAD TO FAILURE AND SEPARTION OF THE LOWER CONTROL ARM BALL JOINT.THE RECALL IS IDENTIFIED AS NHTSA 97V-201 AND A COPY OF CHRYSLER'S LETTER TO NHTSA IS…
EA97016 · opened Sep 29, 1997 · closed Nov 20, 1997