Model year record

1993 Ford Bronco recalls & problems

The 1993 Ford Bronco has 6 safety recalls and 40 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (13 complaints).

Recalls6safety recalls

Complaints40filed by owners

Crashes · fires4 · 2reported in complaints

Injuries · deaths2 · 0reported in complaints

Safety recalls

Vehicle speed controlFeb 4, 2008

Cruise control

Recall 08V051000225,000 vehicles

Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Vehicle speed controlAug 3, 2007

Vehicle speed control

Recall 07V3360003,600,000 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Exterior lightingMar 23, 2006

Exterior lighting

Recall 06E02600061,944 vehiclesopened after NHTSA action (OVSC)

Problem: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Fix: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

Parking brakeSep 7, 1994

Conventional

Recall 94V169001835,791 vehiclesopened after NHTSA action (ODI)

Problem: THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Risk: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Fix: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.

StructureJan 2, 1994

Body › Bumpers

Recall 94V018000370,000 vehicles

Problem: THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
Risk: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
Fix: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.

Power trainMay 17, 1993

Transfer case (4-wheel drive)

Recall 93V0890001,389 vehicles

Problem: THE TRANSFER CASES HAVE BEEN BUILT WITH THE WRONG ELECTRIC SHIFT MOTOR. THE TRANSFER CASES CAN SLIP OUT OF THE 4 X 4 HIGH GEAR POSITION DURING COASTING IN FORWARD GEARS OR WITH POWER APPLIED IN REVERSE GEAR.
Risk: IF THIS OCCURS, THE VEHICLE CAN ROLL FREELY AS IF INNEUTRAL POSITION REGARDLESS OF THE TRANSMISSION GEAR SELECTOR POSITION. THIS CANRESULT IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Fix: REPLACE DEFECTIVE TRANSFER CASES WITH THE CORRECT VERSION.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

1993 Ford Bronco 2-DR. 4x4

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

Fuel economy

Bronco 4WD

14mpg combined

City / highway	12 / 17 mpg
Fuel	Regular Gasoline

5 L · 8 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $4,800/year to fuel

Bronco 4WD

13mpg combined

City / highway	12 / 16 mpg
Fuel	Regular Gasoline

5 L · 8 cyl · Manual 5-spd · 4-Wheel or All-Wheel Drive · about $5,150/year to fuel

Bronco 4WD

12mpg combined

City / highway	11 / 15 mpg
Fuel	Regular Gasoline

5.8 L · 8 cyl · Automatic 4-spd · 4-Wheel or All-Wheel Drive · about $5,600/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Disc › Rotor	13	2	0	0	—
Power trainAutomatic transmission; Automatic transmission › Park/neutral start interlock switch	8	0	0	0	—
TiresTread/belt	6	1	0	1	—
Fuel system, gasolineDelivery › Fuel pump	4	0	1	0	—
Electrical systemIgnition › Switch; Ignition	3	1	1	1	—
StructureFrame and members; Body › Tailgate	3	0	0	0	—
SuspensionFront	2	0	0	0	—
Engine and engine coolingCooling system › Radiator assembly	1	0	0	0	—
Seat beltsFront › Anchorage	1	0	0	0	—
SteeringSteering wheel/handle bar	1	0	0	0	—
Vehicle speed control	1	0	0	0	—
Service brakes	1	0	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Power train
MY 1993 FORD BRONCO HAS AN ESOF (ELECTRONIC SHIFT ON THE FLY) TRANSFER CASE. WITH FOUR WHEEL DRIVE ENGAGED, ON ROAD AND OFF, WHENEVER THE VEHICLE IS COASTING THE TRUCK WILL SUDDENLY ACT LIKE IT IS NO LONGER IN GEAR. SHIFTING INTO PARK AND AND BACK WILL NOT CHANGE ANYTHING. THE TRUCK MUST BE TAKEN OUT OF FOUR WHEEL DRIVE IN ORDER TO START DRIVING AGAIN. I BELIEVE THIS TO BE DANGEROUS AS IT COULD ALLOW ME TO NOT REACT IN THE CASE OF AN EMERGENCY. IT THINK THAT IT IS A SIMILAR PROBLEM TO THE RECALL 93V089000.
Nov 20, 2019 · 257,000 miles
Electrical systemCrash1 injury
TL* THE CONTACT OWNS A 1993 FORD BRONCO. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND CAUSED ANOTHER VEHICLE TO CRASH INTO THE CONTACT'S VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE UNKNOWN INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION. IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE CONTACT DID NOT DISCLOSE WHERE THE VEHICLE WAS TAKEN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 05V017000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Jun 13, 1994
Power train
TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHILE COASTING HE ATTEMPTED TO ACCELERATE AND THE VEHICLE WOULD NOT RESPOND. THE CONTACT STATED THAT THE DEFECT WAS ONLY OCCURRED AFTER THE VEHICLE WAS COASTING. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE TRANSFER CASES SLIPPED OUT OF THE 4X4 GEAR DURING THE INCIDENT. THE CONTACT INDICATED THAT HE EXPERIENCED THE SAME DEFECT LISTED IN THE NHTSA CAMPAIGN NUMBER 93V089000 (POWER TRAIN) BUT THE MANUFACTURER DID NOT INCLUDE THE VEHICLE IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 37,000. UPDATE 4/7/14 VA THE…
Jan 9, 2014 · 37,000 miles
Parking brake
TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT STATED THAT WHILE PARKED, THE EMERGENCY BRAKE WAS ENGAGED AND FAILED TO RESPOND. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 94V169001 (PARKING BRAKE). THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE EXPIRED RECALL. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Jun 3, 2013 · 135,000 miles
Service brakes
TL* THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT STATED THAT WHILE PARKED HE ATTEMPTED TO APPLY THE PARKING BRAKE BUT IT DROPPED TO THE FLOOR BOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE BRAKES WOULD HAVE TO BE REPLACED. AFTER THE REPAIRS THE FAILURE RECURRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 94V169001 (PARKING BRAKE:CONVENTIONAL) THAT MAY BE RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.
Sep 20, 2012 · 109,000 miles
Vehicle speed control
TL*THE CONTACT OWNS A 1993 FORD BRONCO. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL (NHTSA CAMPAIGN ID NUMBER 07V336000). THE DEALER STATED THAT THE PARTS WOULD NOT BE AVAILABLE UNTIL DECEMBER OF 2007. THE CONTACT FELT THAT THE WAIT TIME FOR THE RECALL REPAIR WAS EXCESSIVE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 126,000. UPDATED 10/26/07. *JB
Sep 17, 2007
Tires
1993 EDDIE BAUER BRONCO RIGHT FRONT TIRE BLEW OUT. *TS WHEN THE TIRE BLEWOUT THE CONSUMER LOST CONTROL O THE VEHICLE AND ENDED UP IN A SHALLOW DITCH. THE CONSUMER WAS ABLE TO GET THE VEHICLE BACK ON THE ROAD AND PUT THE SPARE TIRE ON. THE REMAINING TIRES WERE DRIVEN ANOTHER 10000 MILES THEN REMOVED DUE TO BULGES IN THE SIDEWALL. THE TIRES WERE T HEN STORED IN THE CONSUMER'S SHED. THE CONSUMER RECEIVED A RECALL ON THE TIRE AND CONTACTED THE MANUFACTURER. THE CONSUMER WAS TOLD TO TAKE THE TIRE TO THE TIRE DEALER AND HAVE THE TIRE SENT TO THEM. THE CONSUMER RECEIVED A LETTER FROM THE MANUFACTURER STATING THAT THE TIRES WERE NO LONGER UNDER WARRANTY BECAUSE THEY WEREN'T ON THE TRUCK. *NM
Jan 1, 1901 · 10,000 miles
Structure › Body
RIGHT SIDE DASH BOARD LOOSE. NEED TO REPLACE THE BRACKET I THINK THERE WAS A RECALL ON IT.*AK
Jun 1, 2003 · 90,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.