Model year record
The 1994 Ford Club Wagon has 1 safety recall and 17 owner complaints on file with NHTSA. The most-reported problem area is service brakes, hydraulic (7 complaints).
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
| Frontal crash | Not Rated |
|---|---|
| Side crash | Not Rated |
| Rollover | Not Rated |
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Service brakes, hydraulicAntilock/traction control/electronic limited slip | 7 | — |
| SteeringSteering wheel/handle bar | 4 | — |
| Electrical systemAlternator/generator/regulator; Wiring › Front underhood | 3 | — |
| StructureBody › Door; Frame and members | 2 | — |
| Latches/locks/linkagesDoors › Latch | 1 | — |
| Air bagsFrontal | 1 | — |
| Tires | 1 | — |
| EquipmentAppliance › Air conditioner | 1 | — |
| Engine and engine coolingEngine › Gasoline | 1 | — |
| Fuel system, gasolineStorage › Tank assembly › Filler pipe and cap | 1 | — |
| Wheels | 1 | — |
| Vehicle speed controlCruise control | 1 | — |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
AS I WAS LEAVING THE PARKING LOT AT CLEVELAND CLINIC, I HEARD TWO LOUD BANGS AND UPON LOOKING UNDER THE HOOD I NOTICED THE GEARBOX HAD PULLED FROM THE FRAME AND THREE BOLTS SHEARED OFF LEAVING THE STEERING UNUSABLE AND THIS INCIDENT HAD I BEEN DRIVING WOULD CERTAINLY HAVE RESULTED IN THE DEATH OF MY WIFE AND I. WHY NO RECALL I ASK? UPON RESEARCHING, I AM FINDING MANY OF THE SAME ISSUES FROM OWNERS OF THIS MODEL. *TR
I WENT TO THE GROCERY STORE WITH MY 3 YEAR OLD AND AS I WAS BACKING OUT THE STEERING COMPLETELY FAILED I STILL CANNOT GET THE VAN HOME YET BECAUSE IT HAS YET TO BE FIXED. THE STEERING BOX SEPARATED FROM THE FRAME, WHERE IT WAS MOUNTED AND SHEARED ALL 3 BOLTS AND PULLED ONE BOLT THROUGH THE FRAME. HAD I BEEN DRIVING ON THE HIGHWAY I WOULD HAVE WRECKED. I RESEARCHED IT ONLINE AND FOUND IT TO BE A PRETTY COMMON THING IN 93'/94' FORD CLUBWAGONS AND IVE SEEN PICTURES THAT LOOKED SIMILAR TO WHAT HAPPENED TO MY AUNTS VAN THAT I WAS DRIVING. FROM WHAT I UNDERSTAND THERE IS STILL CURRENTLY NO RECALL ON THAT DEFECT AND IT IS A DANGEROUS DEFECT THAT SHOULD BE RECALLED. *KB
THE STEERING BOX IS BOLTED TO THE FRONT LEFT FRAME WITH THREE BOLTS. ALL THREE BOLTS SHEARED, RESULTING IN COMPLETE LOSS OF STEERING ABILITY. THE INCIDENT OCCURRED AT THE TOP OF THE MT. BAKER HIGHWAY, WASHINGTON STATE RT 542. THERE WERE SIX PEOPLE IN THE VAN, AND WE HAD JUST DRIVEN UP THE WINDING STEEP MOUNTAIN ROAD WITH THOUSAND FOOT DROPS AND FEW GUARD RAILS. THE BOLTS BROKE AS WE WERE PARKING IN FRONT OF THE SKI LODGE. HAD IT BROKEN MOMENTS SOONER OR LATER, THERE IS NO DOUBT THAT WE WOULD ALL BE DEAD. INSPECTION SHOWS MUCH CRACKING IN THE FRAME AT AND NEAR THE LOWER BOLT HOLE. *TR
RECALL 08S01, FUSED JUMP HARNESS CALLED THE DEALER, SAID IT WOULD NOT BE AVAILABLE UNTIL MAY 0F 2008. LETTER RECEIVED IN FEBRUARY. *TR
TL*THE CONTACT OWNS A 1994 FORD CLUB WAGON. WHILE DRIVING 65 MPH, THE CONTACT ACTIVATED THE CRUISE CONTROL, WHICH RESULTED IN A TOTAL LOSS OF POWER FOR THE VEHICLE. THE DEALER STATED THAT THE CAUSE OF FAILURE WAS THE DISTRIBUTOR AND THEY MADE THE REPLACEMENT. APPROXIMATELY 60 MILES LATER, THE FAILURE RECURRED WHEN THE CRUISE CONTROL WAS ACTIVATED. THE VEHICLE WAS TAKEN TO ANOTHER DEALER WHO STATED THAT THE DISTRIBUTOR HAD FAILED AGAIN. AS OF JULY 3, 2007, THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 229,000. UPDATED 09/18/07. *JB
THESE VANS OPERATE WITH THE REAR WHEEL DISPLACED FROM THE FRONT WHEEL TRACK BY 2.5 IN. MR
WHILE APPLYING BRAKES THEY LOCKED UP, RESULTING IN EXTENDED STOPPING DISTANCE. DEALER NOTIFIED.*AK
FUEL TANK HAS DEVELOPED A LEAK FROM FILLER NECK WHICH COULD EVENTUALLY RESULT IN A FIRE, CAUSE HAS NOT BEEN DETERMINED.*AK CONSUMER ALSO OWNS A 2000 YEAR VAN THAT WAS INCLUDED IN RECALL 01S14 REGARDING THE EXACT SAME PROBLEM, HOWEVER CONSUMER WAS CHARGED FOR THE 1994 YEAR REPAIRS. *SLC
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.