Model year record

1993 Ford E-150 recalls & problems

The 1993 Ford E-150 has 4 safety recalls and 71 owner complaints on file with NHTSA. The most-reported problem area is fuel system, gasoline (11 complaints).

Recalls4safety recalls

Complaints71filed by owners

Crashes · fires7 · 4reported in complaints

Injuries · deaths3 · 0reported in complaints

Safety recalls

Vehicle speed controlOct 13, 2009

Vehicle speed control

Recall 09V3990004,500,000 vehiclesopened after NHTSA action (ODI)

Problem: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Fix: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Vehicle speed controlFeb 4, 2008

Cruise control

Recall 08V051000225,000 vehicles

Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Vehicle speed controlAug 3, 2007

Vehicle speed control

Recall 07V3360003,600,000 vehiclesopened after NHTSA action (ODI)

Problem: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Fix: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Interior lightingJul 11, 1994

Interior lighting

Recall 94V1280006,088 vehicles

Problem: THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.
Risk: THE OVERHEATING AND FIRES CAUSED BY THE NEON TRANSFORMER CAN RESULT IN DAMAGE TO THE LIGHTBEAM ASSEMBLY, THE ROOF OF THE VEHICLE, AND COULD RESULT IN A VEHICLE FIRE.
Fix: MARK III DEALERS WILL MODIFY THE ASSEMBLIES TO ELIMINATE THE NEON LIGHTING FIXTURE IN THE VEHICLE AND REPLACE IT WITH INCANDESCENT LIGHTS OPERATING DIRECTLY FROM THE VEHICLE 12-VOLT BATTERY.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Fuel economy

E150 Econoline 2WD

15mpg combined

City / highway	13 / 17 mpg
Fuel	Regular Gasoline

4.9 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,450/year to fuel

E150 Econoline 2WD

14mpg combined

City / highway	13 / 15 mpg
Fuel	Regular Gasoline

4.9 L · 6 cyl · Automatic 3-spd · Rear-Wheel Drive · about $4,800/year to fuel

E150 Econoline 2WD

14mpg combined

City / highway	12 / 17 mpg
Fuel	Regular Gasoline

5 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,800/year to fuel

E150 Club Wagon

14mpg combined

City / highway	12 / 17 mpg
Fuel	Regular Gasoline

4.9 L · 6 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,800/year to fuel

E150 Club Wagon

14mpg combined

City / highway	12 / 16 mpg
Fuel	Regular Gasoline

5 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $4,800/year to fuel

E150 Club Wagon

13mpg combined

City / highway	11 / 15 mpg
Fuel	Regular Gasoline

5 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $5,150/year to fuel

E150 Econoline 2WD

12mpg combined

City / highway	11 / 15 mpg
Fuel	Regular Gasoline

5.8 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $5,600/year to fuel

E150 Club Wagon

12mpg combined

City / highway	10 / 14 mpg
Fuel	Regular Gasoline

5.8 L · 8 cyl · Automatic 4-spd · Rear-Wheel Drive · about $5,600/year to fuel

EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.

What owners report

Problem area	Complaints	Crashes	Fires	Injuries	Typical mileage*
Fuel system, gasolineDelivery › Fuel pump; Storage › Tank assembly	11	0	0	0	—
Service brakes, hydraulicAntilock/traction control/electronic limited slip; Foundation components › Hoses, lines/piping, and fittings	10	0	0	0	—
SteeringGear box (other than rack and pinion); Steering wheel/handle bar	10	0	0	0	—
Engine and engine coolingEngine › Gasoline; Cooling system › Hoses/lines/piping/fittings	8	1	1	0	—
Electrical systemIgnition; Ignition › Switch	7	0	2	0	—
SuspensionFront › Control arm; Front › Control arm › Upper ball joint	7	0	0	0	—
TiresTread/belt	7	0	0	0	—
Vehicle speed control	6	4	0	1	—
Power trainAutomatic transmission; Axle assembly › Axle shaft	5	2	0	0	—
WheelsRim; Lugs/nuts/bolts/studs	4	0	0	0	—
StructureFrame and members › Underbody shields	4	0	0	0	118,600 mi
Air bagsFrontal	3	3	0	2	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Power train
The contact owns a 1993 Ford E-150. The contact stated that upon attempting to pull into a parking space and turning the steering wheel, she heard an abnormal sound coming from underneath the front driver's side seat and the steering wheel seized. There was no warning light illuminated. The contact contacted AAA who inspected the vehicle and informed the contact that the gear box had detached from the subframe. The vehicle was towed to an independent mechanic where it was diagnosed that the front driver's side subframe had three holes and one of the holes had expanded significantly and needed to be welded prior to fastening the gear box to the subframe. The independent mechanic informed the…
Jun 27, 2022 · 200,000 miles
Fuel/propulsion system
TL* THE CONTACT OWNS A 1993 FORD E-150. WHILE FUELING THE VEHICLE AT A FUEL STATION, THE FUEL WOULD LEAK OUT FROM THE TOP OF THE FUEL TANK. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT WAS CONCERNED FOR HER SAFETY AND CALLED FIRMIN FORD (LOCATED AT 921 E MAIN ST, LAURENS, SC 29360, (864) 682-3111) TO SCHEDULE A DIAGNOSTIC APPOINTMENT. THE CONTACT WAS INFORMED THAT THERE WAS NO RECALL ON THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 186,000.
Jun 22, 2019 · 186,000 miles
Tires
I WAS DRIVING ON I-95 WHEN MY VEHICLE STARTED THUMPING AND VIBRATING ERRATICALLY AND STEERING WAS VERY HARD TO CONTROL. I EXITED IMMEDIATELY TO FIND THAT MY TIRE HAD A HUGE BULGE A LITTLE LARGER THAN A SOFTBALL. A MAN STOPPED AND SAID I SHOULD BE OKAY TO DRIVE THE 2 MILES I HAD LEFT TO GET HOME. WHEN I BACKED OUT TO DRIVE HOME THE BULGE POPPED EXPOSING BROKEN PLY CORDS AND TREAD SEPARATION.
Aug 21, 2015 · 36,350 miles
Steering
DRIVING HOME FROM SHOPPING I BACKED OUT OF A PARKING SPACE AND HEARD A LOUD POPPING SOUND UPON INSPECTION THE 2 MOUNTING BOLTS HOLDING THE GEARBOX TO THE FRAME RAIL HAD SHEARED OFF AND THE 3RD ONE HAD RIPPED THROUGH THE FRAME RAIL COMPLETELY AND DROPPED THE GEARBOX HAD TO HAVE IT TOWED HOME UPON FURTHER INSPECTION THERE ARE STRESS CRACKS AROUND THE MOUNTING HOLES FOR THE GEARBOX BOLTS. *TR
Feb 1, 2013 · 143,000 miles
Tires
I WAS DRIVING EAST, JUST PAST MONROE, LA, ON I-20 JUST PRIOR TO MILE MARKER 126 WHEN THE RIGHT PASSENGER TIRE CAME OFF MY E150 1993 FORD VAN. I WAS ABLE TO MAINTAIN CONTROL OF THE VAN TO GET IT OFF THE ROAD. THANKFULLY, THE RIM/TIRE, AND BRAKE CALIPER DID NOT HIT A VEHICLE; I FOUND IT ABOUT A HALF MILE PRIOR TO WHERE I WAS ABLE TO GET THE VAN STOPPED. I THOUGHT I A BLOWOUT HAD OCCURRED BUT WHEN I LOOKED, THERE WAS NO RIM OR TIRE ON THE VAN. I BOUGHT THE VAN NEW IN LATE 1992 AND HAVE MAINTAINED IT WELL THROUGHOUT ITS LIFETIME. HOW CAN THIS HAPPEN? JUST PRIOR TO GETTING TO MONROE, THERE WAS A WOBBLE IN THE STEERING LIKE A BIG GUST OF WIND HAD HIT IT OR I HAD STRUCK A RECAP. I GOT OUT AND…
Nov 15, 2009 · 176,000 miles
Steering
WIFE WAS DRIVING VAN OUT OF DRIVEWAY HEARD A LOUD SNAPPING SOUND AND SHE LOST STEERING AND BRAKES WENT OUT SHE DID NOT MAKE IT TOO THE ROAD I WENT OUT AND LOOKED AT VAN AND THE STEERING BOX BOLTS HAD SNAPPED OFF CAUSING THE STEERING BOX TOO HIT BRAKE LINE VAN WAS TOWED TO REPAIR SHOP REPAIRS ARE PENDING. *TR
Apr 20, 2009 · 145,000 miles
Vehicle speed control
NON RESPONSIVE TO RECALL FIX. *TR
Oct 1, 2007
Electrical system › Wiring
FORD RECALL 05S28 OF THE SPEED CONTROL DEACTIVATION SWITCH. I WAS CONTACTED BY FORD TO BRING MY E-150 VAN IN FOR A RECALL ON MY SCDS. I TOOK THE VEHICLE IN QUESTION TO WADE FORD IN SMYRNA, GA. 30080. THEY DISCONNECTED THE SCDS AND SAID THAT THEY DIDN'T HAVE THE PARTS TO FIX THE PROBLEM AND IT WOULD BE OCT. BEFORE THEY WERE AVAILABLE. I HAVE WAITED PATIENTLY WHILE FORD TOOK THEIR TIME TO CORRECT THE PROBLEM. I HAVE CALLED EVERY MONTH TO GET MY VEHICLE REPAIRED AND FINALLY ON FEB. 29, 2008 I WAS TOLD BY DAVE CHANCE A SERVICE ADVISOR THAT THEY FINALLY HAD THE PARTS TO MAKE THE NECESSARY REPAIRS. THEY ASSURED ME THAT THEY HAD THE PARTS TO MAKE THE REPAIR AND I SET UP AN APPOINTMENT TO HAVE THE…
Mar 4, 2008

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

LOSS OF STEERING CONTROLClosed
There is no summary currently available
PE96072 · opened Dec 5, 1996 · closed Apr 29, 1997