Model year record

2001 Ford Econoline recalls & problems

The 2001 Ford Econoline has 5 safety recalls and 28 owner complaints on file with NHTSA. The most-reported problem area is vehicle speed control (8 complaints).

Recalls5safety recalls

Complaints28filed by owners

Crashes · fires1 · 2reported in complaints

Injuries · deaths0 · 0reported in complaints

2001 Ford Econoline in an NHTSA crash test — NHTSA crash test

Safety recalls

Exterior lightingMay 11, 2009

Headlights

Recall 09E02500042,540 vehiclesopened after NHTSA action (OVSC)

Problem: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Fix: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.

Exterior lightingApr 7, 2009

Exterior lighting

Recall 09E01200016,270 vehiclesopened after NHTSA action (OVSC)

Problem: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Fix: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

Vehicle speed controlFeb 4, 2008

Cruise control

Recall 08V051000225,000 vehicles

Problem: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Risk: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Fix: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Fuel system, gasolineAug 5, 2003

Storage

Recall 03V28200064 vehicles

Problem: ON CERTAIN CUTAWAY CHASSIS CAB WITH THE SCHOOL BUS OPTION, TWO BRACKETS AND TWO OUTRIGGER MEMBERS ARE MISSING IN THE AREA OF THE FUEL TANK.
Risk: THE BRACKETS AND OUTRIGGER MEMBERS ARE INTENDED TO ENHANCE CRASH PERFORMANCE.
Fix: FORD WILL SEND TECHNICIANS TO THE OWNER'S LOCATION TO INSPECT AND ADD THE BRACKETS AND OUTRIGGERS AS REQUIRED. OWNER NOTIFICATION BEGAN ON SEPTEMBER 3, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Child seatOct 4, 2000

Child seat

Recall 00V30400012 vehicles

Problem: VEHICLE DESCRIPTION: CERTAIN CREW VANS FAILED TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THESE VEHICLES, WHICH ARE DESIGNATED AS TRUCKS, ARE 5 PASSENGER VEHICLES WITH THREE DESIGNATED SEATING POSITIONS IN THE SECOND ROW SEATS. THEY WERE BUILT WITHOUT CHILD SEAT TETHER ANCHORAGE BRACKETS IN THE CENTER POSITION OF THE SECOND ROW SEAT. ALSO THE OWNER GUIDES DO NOT ADDRESS THE CHILD SEAT TETHER ANCHORAGES IN THE CENTER SECOND ROW SEAT POSITION.
Risk: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Fix: DEALERS WILL INSTALL THE CHILD SEAT TETHER ANCHORAGES AT THE CENTER SECOND ROW SEATING POSITION, AND ALSO REPLACE THE VEHICLE OWNER GUIDES WITH NEW VERSIONS PROVIDING THE REQUIRED WRITTEN INSTRUCTIONS. ELEVEN VEHICLES ARE AT DEALERSHIPS AND ASSEMBLY PLANT PERSONNEL WILL REPAIR THESE UNITS AT THE AFFECTED DEALERSHIPS. ARRANGEMENTS HAVE BEEN MADE FOR THE RETURN OF THE ONE UNIT THAT HAD BEEN SOLD. NO OTHER OWNER NOTIFICATION WILL BE REQUIRED.

Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.

Crash test ratings

2001 Ford Econoline

OverallNot Rated

Frontal crash	Not Rated
Side crash	Not Rated
Rollover	Not Rated

NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.

What owners report

Problem area	Complaints	Crashes	Fires	Typical mileage*
Vehicle speed controlCruise control	8	0	0	—
Engine and engine coolingEngine; Exhaust system	4	0	1	75,266 mi
Power trainAutomatic transmission; Clutch assembly	4	0	0	—
TiresSidewall	3	1	0	—
Engine	3	0	0	124,000 mi
SuspensionFront › Springs › Coil springs; Front › Wheel bearing	2	0	0	—
Electrical systemWiring › Interior/under dash	1	0	1	—
Wheels	1	0	0	—
Electronic stability controlAutomatic (asc)	1	0	0	—
Fuel system, diesel	1	0	0	—
Steering	1	0	0	—
Fuel system, gasoline	1	0	0	—

*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.

Recent owner complaints

Engine
SPARKPLUG BLOWOUT
Feb 15, 2016 · 124,000 miles
Fuel/propulsion system
BUCKING, SHAKING, LOSS OF POWER. TIRES FELT OUT OF ALIGNMENT. STALLING AND ROUGH IDLE. LINING IN THE FUEL TANK PEELS OFF AND THE MATERIAL FROM THE LINING IS CLOGGING THE FUEL PUMP. THIS AFFECTS TRUCKS, VANS FROM THE YEARS 2000 UP. THIS HAPPENED AT HIGHWAY SPEEDS ON AN INTERSTATE HIGHWAY. THERE WAS .MUCH TRAFFIC TO BE NEGOTIATED UNTIL I FINALLY MADE IT TO THE SHOULDER OF THE ROAD.
Feb 16, 2016 · 75,000 miles
Engine
NUMBER 7 CYLINDER BLEW THE SPARK PLUG OUT. TOTAL LOSS OF POWER. FORTUNATELY TRAFFIC WAS LIGHT AND I WAS ABLE TO PULL INTO A PARKING LOT. ABSOLUTELY NO WARNING SIGNS AT ALL. *TR
Jul 13, 2014 · 180,000 miles
Engine
TL* THE CONTACT OWNS A 2001 FORD ECONOLINE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THERE WAS A LOUD BANG HEARD FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE NUMBER ONE SPARK PLUG AND THE COIL WOULD HAVE TO BE REPLACED. THE FAILURE RECURRED SIX TIMES AFTER THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT AN AFTER MARKET PART COULD BE INSERTED ON THE SPARK PLUGS TO PREVENT THE FAILURE FROM RECURRING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 86,000.
Sep 15, 2010 · 86,000 miles
Fuel system, gasoline
TL* THE CONTACT OWNS A 2001 FORD ECONOLINE. WHILE DRIVING AT DIFFERENT SPEEDS, THE CONTACT NOTICED THAT THE VEHICLE WOULD LOSE POWER AND RESIST ACCELERATION. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE EXACT FAILURE. THE FUEL FILLER WAS REPLACED APPROXIMATELY TEN TIMES. THE FUEL INJECTORS WERE REPLACED TWICE. THE INDEPENDENT MECHANIC STATED THAT THE FUEL TANK WOULD HAVE TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Jan 1, 2010 · 100,000 miles
Steering
THERE IS A SMALL PLATE THAT HAS 2 ALLEN HEAD BOLTS HOLDING IT ON THE BOTTOM OF THE STEERING COLUMN SHAFT .THIS PLATE PUTS THE VEHICLE IN PARK. THE BOLTS CAME LOOSE AND THE VAN ROLLED BACKWARDS INTO THE GARAGE DOOR EVEN THOUGH IT WAS IN PARK AND THE DRIVER WAS STANDING OUTSIDE,NEXT TO THE VAN
Nov 10, 2011
Engine and engine cooling › EngineFire
TL* THE CONTACT OWNS A 2001 FORD ECONOLINE. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE EXHIBITED AN ABNORMALLY LOUD BACKFIRE NOISE FROM UNDERNEATH THE HOOD AREA. THE CONTACT MOVED THE VEHICLE FROM THE ROADWAY AND FOUND A SMALL FIRE IN THE ENGINE COMPARTMENT. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE MECHANIC ADVISED THAT THE FAILURE WAS CAUSED BY A BLOWN SPARK PLUG THAT EJECTED FROM ITS HOUSING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 220,000.
Aug 25, 2010 · 220,000 miles
Fuel system, diesel
AMBULANCE ON FORD E-450 AND F-350 CHASSIS HAVE HAD MAJOR FUEL SYSTEM FAILURES. BOTH AMBULANCES IN THE PAST YEAR HAVE HAD THE LINING OF THE DIESELF FUEL TANKS RUST OFF AND GET PULLED INTO THE FUEL SYSTEM. THE METAL FLAKES HAVE RUINED SENDING UNITS,FUEL PUMPS, DIESEL INJECTORS, FUEL FILTERS AND FILTER HOUSINGS. IT HAS CAUSED THE AMBULANCES TO STALL WHILE TRANSPORTING CRITICALLY ILL PATIENTS TO THE HOSPITAL. IR HAS ALSO COST CLOSE TO $9000.00 TO FIX BOTH AMBULANCES. THE FIX WAS TO REPLACE ALL FUEL COMPONENTS FROM THE DIESEL TANK FORWARD TO THE DIESEL MANIFOLD. *TR
Sep 20, 2009 · 74,000 miles

Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.

NHTSA defect investigations

SPARK PLUG EJECTION FROM CYLINDER HEADClosed
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006