*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Engine
I am filing a safety complaint regarding my 2019 Ford EcoSport and Fordâs repeated failure to properly complete a safety recall. In XXX, my vehicle displayed an oil-pressure warning while driving, just two days after an oil change. I brought it to Woodbridge Ford in [XXX] for recall repairs. They kept my vehicle for three months before claiming it was repaired. However, I continued receiving notices stating the recall was incomplete. In XXX, I contacted the dealership, now Freedom Ford, and was informed that the recall had NEVER been completed. I returned my vehicle for repairs. On XXX, I was told my vehicle was ready. Before I could even leave the dealership lot, the vehicle began…
Aug 26, 2026Power train
2019 Ford EcoSport 1.0L, VIN [XXX], 23,338 miles. Ford Safety Recall 23S64/NHTSA 23V-905 was performed by Rod Baker Ford in September 2025. Repair order XXX was opened XXX and the recall work was completed/invoiced XXX at approximately 22,812 miles. The repair included replacement of the timing belt, oil-pump drive belt and oil-pump drive-belt tensioner. The Ford repair order documents the 23S64 completion and the replacement parts. On XXX, at approximately 23,338 miles, the engine suffered a catastrophic failure in traffic. This was only approximately 526 miles after the 23S64 repair. Initial diagnosis found no compression. Hawk Ford subsequently diagnosed failure/collapse of timing-belt…
Sep 14, 2026Engine
Engine shut off while driving a vibration sounded prior to shut off so I turned off a/c then restarted engine again
Sep 2, 2026Engine
My 2019 Ford EcoSport suffered sudden low oil pressure and catastrophic engine failure 10 months after receiving service under Safety Recall 23S64. NHTSA Campaign 23V905. The Authorized dealership is refusing to inspect the vehicle or honor Ford's engine replacement remedy, claiming the recall is closed and too much time has passed. This leaves me with an un-remedied safety hazard.
Aug 28, 2026Engine and engine cooling
The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact called another dealer, Shottenkirk Ford Jasper (868 GA-515, Jasper, GA 30143); and the contact was informed that the vehicle had to experience the failure before the recall repair would be performed. The manufacturer was contacted by email, but was unable to assist with having the vehicle serviced. The contact had not experienced a failure.
Aug 24, 2026Engine
The contact owns a 2019 Ford EcoSport. The contact stated that while stopped at a red light, the vehicle stalled and failed to restart. The vehicle was towed to a dealer where it was diagnosed and determined that the starter needed to be replaced. The vehicle was repaired. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the catalytic converter, a cracked flex pipe, exhaust clamps, turbo connection, and a vacuum pump assembly needed to be replaced. The vehicle was repaired. The contact was then informed of an unknown recall. The contact stated that on…
Mar 12, 2024 · 37,028 milesEngine
A young teenage driver faced a terrifying highway emergency when her vehicle suffered an abrupt, dangerous loss of motive power at 70+ MPH on the interstate due to sudden turbocharger failure. Moving at high speeds in heavy traffic, the sudden drop in acceleration left the driver vulnerable to rear-end collisions from oncoming semi-trucks. The vehicle was driven into the shop with a failed turbocharger and a completely contaminated oil ecosystem. The engine block has not seized yet, but all components are highly contaminated. The affected components are preserved and available for federal inspection. The root cause is a completely choked oil pump pick up tube screen. After a week-long…
Jul 6, 2026Fuel/propulsion system
For a month, every time I put gas in my car whether I filled up or just put half a tank my car will not start for 10-15 minutes. I took it to the ford place and my extended warranty wouldn't cover it. It seems like an evap valve would be covered. I have only had my car 11 months. This is going to cost over $1,000 to fix. It seems like ford should be responsible for the repairs.
Jul 8, 2026
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
