Model year record
2006 Ford Escape Hybrid recalls & problems
The 2006 Ford Escape Hybrid has no safety recalls on file with NHTSA, and 219 owner complaints. The most-reported problem area is service brakes (57 complaints).
Safety recalls
No safety recalls have been filed for the 2006 Ford Escape Hybrid.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
Crash test ratings
2006 Ford Escape Hybrid 4-DR
| Frontal crash | Not Rated |
|---|---|
| Side crash | Not Rated |
| Rollover | Not Rated |
NHTSA 5-Star Safety Ratings (New Car Assessment Program). Ratings are comparable only between vehicles of similar size and weight, and ratings from 2011 on use tougher tests than earlier years. Photos: NHTSA.
Fuel economy
Escape Hybrid FWD Hybrid
| City / highway | 30 / 28 mpg |
|---|---|
| Fuel | Regular Gasoline |
2.3 L · 4 cyl · Automatic (variable gear ratios) · Front-Wheel Drive · about $2,300/year to fuel
Escape Hybrid 4WD Hybrid
| City / highway | 28 / 26 mpg |
|---|---|
| Fuel | Regular Gasoline |
2.3 L · 4 cyl · Automatic (variable gear ratios) · 4-Wheel or All-Wheel Drive · about $2,500/year to fuel
EPA estimates from fueleconomy.gov for each engine and transmission sold. Annual cost is the EPA's estimate for 15,000 miles a year at its current fuel and electricity price assumptions. Your results will vary.
What owners report
| Problem area | Complaints | Typical mileage* |
|---|---|---|
| Service brakes | 57 | 93,500 mi |
| Engine | 43 | 123,561 mi |
| Electrical system | 36 | 116,000 mi |
| Service brakes, hydraulicAntilock/traction control/electronic limited slip | 28 | 58,650 mi |
| Steering | 24 | 108,500 mi |
| Vehicle speed control | 19 | 122,500 mi |
| Power trainDriveline › Differential unit | 18 | 116,000 mi |
| Engine and engine coolingCooling system; Engine | 12 | 80,250 mi |
| Fuel/propulsion system | 10 | 112,000 mi |
| Hybrid propulsion system | 10 | 150,000 mi |
| StructureBody | 8 | 122,500 mi |
| Unknown or other | 7 | 92,000 mi |
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
- Hybrid propulsion system
The contact owns a 2006 Ford Escape Hybrid. The contact stated while driving at an undisclosed speed, the vehicle stalled. The vehicle was taken to an independent mechanic, who informed the contact that the brushless Motor Electronics Coolant (MEC) pump needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 14V526000 (Hybrid Propulsion System). The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.
- Hybrid propulsion system
The contact owns a 2006 Ford Escape Hybrid. The contact stated that on multiple occasions while attempting to start the vehicle, the engine turned over for two seconds and stalled. The contact stated that an unknown service warning light was illuminated, indicating to pull the vehicle over. The contact notified an independent mechanic and he was advised to contact the NHTSA Hotline to confirm any recalls; however, the vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 157,000. The VIN was invalid.
- Hybrid propulsion system
The contact owns a 2006 Ford Escape Hybrid. The contact received a recall notification for NHTSA Campaign number: 14V526000 (Hybrid Propulsion System). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The part was available for the repair. The contact had not experienced a failure. Parts distribution disconnect.
- Structure › Body
TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. WHEN THE CONTACT TOOK THE VEHICLE TO AN UNKNOWN DEALER IN FENTON, MICHIGAN FOR MAINTENANCE, IT WAS DIAGNOSED THAT THE SHOCK TOWER FRAME WAS RUSTED. THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE CONTACT WAS REFERRED TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.
- Fuel/propulsion system
THE HYBRID ELECTRONICS SYSTEM OVERHEATED, THE DASHBOARD LIGHTS WENT ON AND THE ALERT SYSTEM SAID TO "STOP CAR SLOWLY" AND THEN "CHECK EMISSIONS SYSTEM". THE CAR SLOWED DOWN AND LOST ALMOST ALL POWER. AFTER TURNING IT ON AGAIN, THE CAR HAD NO POWER AND COULD NOT ACCELERATE. IT WAS LIKE THIS FOR SEVERAL MINUTES (THIS HAS HAPPENED BEFORE BUT THE CAR SEEMED NORMAL AFTER THE INITIAL STALL). THE CAR WAS TOWED TO A NEARBY MECHANIC'S GARAGE AND THEY TOLD US THE PROBLEM WAS WITH THE MECS PUMP WHICH WAS CAUSING THE HYBRID SYSTEM TO OVERHEAT. THIS SEEMS REMARKABLY SIMILAR TO RECALL #14S19 AND I DON'T UNDERSTAND HOW MY CAR IS NOT COVERED UNDER IT. I ALSO CHATTED WITH A REP FROM FORD WHO COULDN'T TELL…
- Service brakes
AS I WAS APPROACHING AN INTERSECTION AND RED LIGHT, MY BRAKES SUDDENLY STOPPED WORKING. I LITERALLY HAD TO STAND ON THE BRAKE AND IT FINALLY STOPPED MOVING. I CONTINUED TO DRIVE HOME AT LESS THAN 10 MPH AND HAD TO LET OFF THE GAS IN ORDER TO SLOW THE VEHICLE DOWN TO ATTEMPT TO USE THE BRAKES AND CAR WOULD SHAKE WHEN BRAKE WAS APPLIED. TOOK TO MECHANIC WHO CHECKED THE CODE AND IT WAS THE TRAVEL SENSOR.
- Engine
2006 FORD ESCAPE HYBRID WITH APPROX. 140,000 MILES. INITIALLY, HAD PROBLEMS WITH VEHICLE'S GAS ENGINE STALLING OUT WHILE IN MOTION AND AT VARIOUS SPEEDS FROM 35 TO 55 MPH. MESSAGE IN DASH SAID TO PULL OVER SAFELY. THIS HAPPENED 5 TIMES IN ONE DAY AND EACH TIME THE VEHICLE WOULD RESTART AND RUN FOR ONLY A FEW MINUTES. NEXT DAY IT RAN FOR ABOUT 15 MINUTES BEFORE OCCURRING ONCE AGAIN. EVENTUALLY THE HYBRID BATTERY HAD NO MORE JUICE AND I HAVE TO BE TOWED. GARAGE, NOT DEALER DX STICKING THROTTLE LINKAGE ASSEMBLY. THEY CLEANED IT, RECHARGED THE HYBRID BATTERY AND REPROGRAMMED THE COMPUTER. VEHICLE WORKED WELL FOR 6 WEEKS AND THEN PROBLEM RETURNED. ONLY DIFFERENCE WAS THAT AFTER INITIALLY…
- Service brakes
ABS BREAK LIGHT CAME ON AND THE CAR FAILED TO STOP. WAS DRIVING ON THE ROAD IN A SMALL TOWN AND WAS STOPPING TO TURN ON TO A ROAD. THE PROBLEM HAD ALSO HAPPEN WHEN SOMEONE HAS STOPPED SUDDENLY IN FRONT OF ME AND I NEEDED TO BREAK SUDDENLY. HAD BREAK FLUID CHANGED AT FORD DEALERSHIP AND DID NOT FIX THE PROBLEM. WHEN YOU NEED TO STOP SUDDENLY AND HIT THE BREAKS HARD, THE PEDAL HARD IT STIFFENS UP AND WILL NOT STOP THE CAR. IF YOU TURN OFF THE CAR AND WAIT A FEW MINUTES AND TURN IT BACK ON, IT SEEMS TO RESET IT UNTIL YOU HIT THE BREAKS HARD AGAIN.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
- Pedestrian alert soundsClosedLed to recall 22V063000
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review…
- Electronic Throttle Body MalfunctionClosed
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and…