The 2004 Ford Excursion has 2 safety recalls and 95 owner complaints on file with NHTSA. The most-reported problem area is engine and engine cooling (23 complaints).
Problem: FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Risk: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Fix: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
NHTSA recall 05V270000 · Jun 10, 2005 · 180,104 vehicles · opened after NHTSA action (ODI)
Problem: CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Risk: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Fix: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Engine and engine cooling Engine › Diesel; Engine
23
0
0
0
61,000 mi
Electrical system Wiring; Alternator/generator/regulator
23
0
2
0
95,500 mi
Vehicle speed control Cruise control
9
1
0
0
43,650 mi
Power train Automatic transmission; Transfer case (4-wheel drive)
7
2
0
2
5,000 mi
Engine
7
0
0
0
82,500 mi
Tires Tread/belt; Sidewall
6
0
0
0
95,000 mi
Visibility Glass, side/rear; Power window devices and controls
5
0
0
1
67,000 mi
Fuel system, gasoline Fuel injection system
5
0
0
0
33,000 mi
Service brakes, hydraulic Foundation components › Drum › Shoes/linings; Antilock/traction control/electronic limited slip
4
2
0
4
16,000 mi
Fuel system, diesel
4
0
0
0
—
Seats Mid/rear assembly
3
0
0
0
—
Suspension Front; Front › Springs › Leaf spring assembly
3
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Mar 15, 2021Unknown or other Was driving home from work at a light on a uphill street and all of a sudden lost all power engine shut down was extremely hard to slam vehicle into park was in very high traffic road at a very busy time of day!! Had to get towed vehicle would just crank n no start
Mar 15, 2021 · 59,000 milesElectrical system TOTAL LOSS OF ENGINE POWER MASSIVE AMOUNT BLACK SOOT EXITING EXHAUST WHILE DRIVING RECALL # 05V270000 WAS NOT PERFORMED ON VEHICLE ( I AM THE ORIGINAL OWNER) NEVER RECEIVED NOTICE IN MAIL AND DEALER SOMEHOW MISSED THIS "WORK" AND FORD SHOULD HAVE FOLLOWED THROUGH ON THIS SITUATION. OTHER REPAIRS DONE TO THIS VEHICLE TO "FIX" THIS PROBLEM WAS TO DRAIN THE FUEL TANK (ALGAE IN FUEL WAS THE EXCUSE-NO ALGAE) FUEL PUMP AND FILTER RAIL (NOT PROBLEM) TWO TURBOCHARGERS WERE REPLACED DUE TO EXCESSIVE SOOTING (ONE WARRANTY ONE AT MY EXPENSE) EGR VALVES AND A CAM SENSOR (FORD KNOWS THE PROBLEMS EXIST BECAUSE FORD DISCOUNTINUED THE 6.0 LITRE MOTOR) THIS PROBLEM HAS OCCURED MULTIPLE TIMES OVER MY…
Dec 2, 2019 · 200,000 miles · crashPower train CAR WAS SITTING, ENGINE RUNNING, IN PARK FOR 10 MINUTES AND THEN SUDDENLY WITH NO ONE INSIDE, MOVED FORWARD AND CRASHED INTO THE WINDOW OF A BUSINESS. THERE WAS A WITNESS THERE.
Sep 5, 2019Tires BOUGHT MICKEY THOMPSON ATZ 305 70 16 IN APRIL. HAVE TREAD SEPARATION
Jul 1, 2019 · 312,000 milesAir bags THE AIR BAG CLOCKSPRING HAS BROKEN WHICH AS TRIGGERED A AIRBAG LIGHT ALSO MY HORN AND CONTROLS HAVE STOPPED WORKING. THE CLOCKSPRING HAS BEEN DISCONTINUED AND ISNT AVAILABLE. NEED A SOLUTION TO THIS ASAP
Feb 12, 2019 · 59,000 milesElectrical system TL* THE CONTACT OWNS A 2004 FORD EXCURSION. WHILE DRIVING, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PLACED THE GEAR INTO NEUTRAL, WHILE IN TRAFFIC, AND RESTARTED THE VEHICLE. AFTERWARDS, THE VEHICLE WAS ABLE TO DRIVE NORMALLY. THE VEHICLE WAS TAKEN TO FUTURE FORD LINCOLN (LOCATED AT 650 AUTOMALL DR, ROSEVILLE, CA 95661, (888) 656-7577) WHERE A WIGGLE TEST WAS PERFORMED BECAUSE A FAILURE CODE COULD NOT BE FOUND. THE INJECTION CONTROL PRESSURE WAS REPLACED WITH A USED PART. THE CONTACT STATED THAT THE VEHICLE WAS WORSE AFTER THE REPLACEMENT OF THE USED PART AND THE STEERING WHEEL BECAME DIFFICULT TO STEER. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHO STATED THAT A WIRE HARNESS…
Sep 13, 2018Service brakes 2004 FORD EXCURSION. CONSUMER WRITES IN REGARD TO BRAKE FAILURE FROM RUPTURED BRAKE LINE. *AS *TR
Jul 1, 2014 · 137,000 milesVehicle speed control IT WILL NOT DISENGAGE WHEN CRUISE CONTROL IS IN USE. IT CONTINUES TO DO THIS IF USED.
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.
NHTSA defect investigations
DP05005 · opened Sep 22, 2005 · closed Jan 4, 2006SPARK PLUG EJECTION FROM CYLINDER HEAD ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY…
EA05003 · opened Feb 15, 2005 · closed Nov 2, 2005 · led to recall 05V270000ENGINE STALLING IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE…
PE04070 · opened Oct 7, 2004 · closed Feb 15, 2005ENGINE STALLING TWENTY FIVE OF THE ODI FAILURE REPORTS ARE DUPLICATIVE OF FORD COMPLAINTS.TWENTY ODI REPORTS DO NOT CONTAIN A VIN (AND MAY OR MAY NOT BE DUPLICATIVE OF FORD REPORTS).THE 14 ALLEGED CRASHES AND 2 ALLEGED INJURIES WERE ALL MINOR.SUBMITTED DURING PRELIMINARY EVALUATION (PE) 04-070, FORD'S RESPONSE TO ODI'S INFORMATION REQUEST (IR) LETTER CONTAINED ABOUT 5,000 CONSUMER REPORTS (MORS) AND 8,700 FIELD REPORTS (CQIS).FORD REVIEWED THE COMPLAINTS AND CATEGORIZED THEM.THE MANUFACTURER REPORTS SHOWN ABOVE REPRESENT A COUNT OF UNIQUE VEHICLES THAT FORD CATEGORIZED AS ALLEGEDLY STALLING DUE TO A SUBJECT ENGINE COMPONENT ('A' CATEGORY, SEE FORD'S IR RESPONSE LETTER FOR FURTHER DETAIL); SOME OF THESE VEHICLES RECEIVED MULTIPLE REPORTS.ODI HAS NOT YET CONFIRMED FORD'S CATEGORIZATION OF THESE REPORTS, NOR HAS ODI CONFIRMED FORD'S CATEGORIZATION OF THE REMAINING REPORTS (WHICH FORD STATES DO NOT PERTAIN…