*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Tires
KUMHO KL78 245/75R16 LOAD RANGE E TIRE. PURCHASED A SET OF KL78 TIRES IN NOVEMBER 2011 FOR MY 3/4 TRUCK. SINCE THE TIME OF PURCHASE I HAVE PUT LESS THAN 20,000 MILES ON THE TRUCK / TIRES. THREE OF THE TIRES HAVE DEVELOPED LARGE DEFORMATION ACROSS THE TREAD CAP, LIKE A BULGE. THIS IS A MANUFACTURING SAFETY DEFECT CAUSED BY THE SEPARATION OF STEEL BELTS OF THE TIRE ALLOWING THE RUBBER TO DEFORM. *TR
Jul 6, 2014 · 145,782 milesVehicle speed control
TL* THE CONTACT OWNS A 1996 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE SPEED CONTROL DEACTIVATION SWITCH BECAME OILY AND STARTED LEAKING BRAKE FLUID. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE SPEED CONTROL DEACTIVATION SWITCH WOULD NEED TO BE REPLACED. THE CONTACT WAS INFORMED OF A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOTIFIED BUT ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL AND OFFERED NO OTHER ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 131,000. UPDATED 02/12/13*LJ THE CONSUMER STATED THE SPEED CONTROL…
Sep 12, 2012 · 131,000 milesTires
PLY SEPARATION. TIRE STORE CONFIRMED THEY WERE AWARE OF OTHER OCCURRENCES. THERE'S NO SECTION TO REPORT TYPE IN FORM SO I WILL HERE. TYPE APT. M&S LT235/85/R16. OTHER I.D. INFO.120/116Q. *TR
Feb 14, 2012Fuel system, diesel
TL*THE CONTACT OWNS A 1996 FORD F250. THE CONTACT STATED THAT THE FILTER HOUSING CRACKED AND LEAKED DIESEL FLUID FROM THE TOP OF THE ENGINE DOWN INTO THE VEHICLE. HE WAS CONCERNED THAT THE LEAK COULD CAUSE A FIRE. AN INDEPENDENT MECHANIC ASSUMED THAT THE FUEL PUMP WAS CAUSING THE LEAK. AFTER THE REPAIRS WERE COMPLETED, THE MECHANIC STATED THAT THE FUEL HOUSING CRACKED AND CAUSED THE LEAK. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 230,000.
May 10, 2009 · 230,000 milesEngine and engine cooling
WHILE DRIVING IN TRAFFIC MY CAMSHAFT POSITION SENSOR FAILED WITHOUT WARNING CAUSING MY DIESEL ENGINE TO SHUT OFF, LEAVING ME WITH NO STEERING AND BRAKING ABILITY. THIS ACTION ALMOST CAUSED A TRAFFIC ACCIDENT. MY TRUCK WAS TOWED TO MY LOCAL REPAIR SHOP AND THE CAMSHAFT POSITION SENSOR WAS REPLACED. I RETAINED THE SENSOR THAT WAS REPLACED. *TR
Aug 28, 2008 · 90,848 milesEngine and engine cooling
TL*THE CONTACT OWNS A 1996 FORD F250 HD. THE CAM SENSOR WAS REPLACED ON OCTOBER 28, 2003. THE CONTACT BELIEVES THAT THE REPLACEMENT PART IS FAULTY AND WILL NEED TO BE REPLACED AGAIN. THERE IS A SAFETY RECALL ON THE CAM SENSOR, BUT IT DOES NOT APPLY TO HIS VEHICLE YEAR. THERE HAS BEEN NO RECENT FAILURE TO DATE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 113,800 AND THE FAILURE MILEAGE IN 2003 WAS 96,228. UPDATED 01/17/08 *BF UPDATED 01/17/08 *TR
Dec 18, 2007 · 96,228 milesService brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings
I HAVE A 1996 FORD F-250 HEAVY DUTY PICKUP WHICH I PURCHASED NEW AND ALL THE BRAKE LINES ARE COMPLETELY RUSTED THROUGH. I WAS TESTING THE BRAKES AFTER ADJUSTING THEM IN FRONT OF MY HOUSE WHEN THE PEDAL WENT TO THE FLOOR. ALL THE FLUID WAS BLOWN OUT OF THE RUSTED LINE ON THE FRONT BRAKES, AFTER I REPAIRED THEM AND WAS BLEEDING THE AIR FROM THEM, WHILE HOLDING DOWN ON THE PEDAL ANOTHER LINE ON THE REAR BRAKES BLEW OUT. IN SHORT, I SPENT 10 HRS. REPLACING ALL THE BRAKE LINES THAT WERE RUSTED OUT. I HAVE OLDER CARS AND TRUCKS AND HAVE NEVER HAD THIS ISSUE BEFORE. IF I HAD BEEN HAULING A LOAD THAT THIS TRUCK IS RATED TO PULL (14,000LBS.) TOWING CAPACITY,I COULD HAVE RUN RIGHT OVER SOMEONE. I…
Sep 7, 2007 · 100,700 milesEngine and engine cooling › Engine › Diesel
TRUCK STALLED OR QUIT FOR NO APPARENT REASON WHILE DRIVING. *JB
Jan 24, 2007 · 180,000 miles
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.