Problem: ON CERTAIN MEDIUM DUTY CHASSIS CAB VEHICLES EQUIPPED WITH HYDRAULIC BRAKES, THE DRIVE LINE PARK BRAKE ANCHOR BOLT MAY BE SUSCEPTIBLE TO FATIGUE LOADING. THE BOLT COULD FRACTURE OVER TIME DUE TO INSUFFICIENT CLAMP LOAD AS A RESULT OF IMPROPER ANCHOR BOLT PLATING.
Risk: IF THE PARK BRAKE ANCHOR BOLT FATIGUES AND ULTIMATELY FRACTURES, THE PARK BRAKE MAY NOT FUNCTION AND THERE MAY BE NO INDICATION TO THE DRIVER OF THE MALFUNCTION WHEN THE PARK BRAKE IS SET. THIS MAY CAUSE THE VEHICLE TO ROLL AWAY WITHOUT WARNING, WHICH COULD RESULT IN A CRASH.
Fix: DEALERS WILL REPLACE THE PARK BRAKE ANCHOR BOLT. THE RECALL BEGAN ON OCTOBER 6, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Wheels
NHTSA recall 05V202000 · May 4, 2005 · 25 vehicles
Problem: ON CERTAIN CAB CHASSIS VEHICLES EQUIPPED WITH ACCURIDE ALUMINUM WHEELS, THE WHEELS WERE NOT PROPERLY PRE-STRESSED. THIS ALLOWS CRACKS TO DEVELOP OVER TIME.
Risk: THIS MAY EVENTUALLY LEAD TO WHEEL FAILURE AND POSSIBLY RESULT IN A VEHICLE CRASH.
Fix: DEALERS WILL REPLACE THE WHEELS FREE OF CHARGE. THE RECALL BEGAN ON MAY 17, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Recall repairs are free at any authorised dealer. A recall listed here may already have been fixed on a particular car: enter its 17-character VIN at nhtsa.gov/recalls to see open recalls.
What owners report
Problem area
Complaints
Crashes
Fires
Injuries
Typical mileage*
Parking brake Driveline › Hydraulic
2
0
0
0
—
Tires
1
0
0
0
—
Service brakes, hydraulic
1
0
0
0
—
Fuel system, diesel Storage › Tank assembly
1
0
0
0
—
Power train
1
0
0
0
—
*Median odometer reading when the problem happened, where owners gave one. One complaint can name several problem areas.
Recent owner complaints
Jul 3, 2012 · 103,460 milesPower train TL* THE CONTACT OWNS A 2005 FORD F-650 SD. THE CONTACT STATED THAT THE CLUTCH MASTER CYLINDER FAILED BY NOT DISENGAGING THE CLUTCH IN TIME. THE CONTACT APPLIED THE BRAKES TO STOP THE VEHICLE. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER OR CALL THE MANUFACTURER. THE CONTACT REPLACED THE CLUTCH MASTER CYLINDER AS WELL AS THE CLUTCH. THE REPAIR ONLY REMEDIED THE ISSUE TEMPORARILY. THE FAILURE MILEAGE WAS 103,460.
Jul 1, 2008 · 60,000 milesFuel system, diesel › Storage › Tank assembly TL* THE CONTACT OWNS A 2005 FORD F-650 SUPER DUTY. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE FUEL TANK WAS REPLACED. THE FAILURE RECURRED APPROXIMATELY FIVE TIMES. AFTER EACH FAILURE, THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR FACILITY WHERE THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 150,000.
Jan 1, 2008 · 27,000 milesService brakes, hydraulic I OWN AN 05 F650 AND A 07 F650 BOTH HAVE FRONT END PROBLEMS AS WELL AS BRAKE PROBLEMS SPOKE WITH FORD THEY WERE NOT WILLING TO WARRANTY A PRODUCT UNDER WARRANTY. *TR
Sep 28, 2007Tires 2005 FORD F-650 RIGHT REAR TIRE BLEW OUT. WHEN THE BLOW OUT OCCURRED THE DEBRIS RUPTURED THE AIR BRAKE LINE ON ANOTHER VEHICLE. *KB (OHIO TRAFFIC CRASH REPORT)*JB
Oct 1, 2005Parking brake › Driveline › Hydraulic I AM WRITING IN REFERENCE TO A RECALL NOTICE I RECEIVED ON OCTOBER 11, 2005 REGARDING A POSSIBLE DRIVELINE PARKING BRAKE ANCHOR BOLT FRACTURE ON MY F-650 FORD TRUCK. I PURCHASED THIS TRUCK FROM HUBCO FORD IN ALLENTOWN PA. IT HAS SINCE COME TO MY ATTENTION THAT HUBCO FORD, WHERE I PURCHASED THIS VEHICLE, HAS CLOSED ITS DOORS AND NO LONGER CAN SERVICE THIS VEHICLE. NOT ONLY WAS I NEVER NOTIFIED OF THE CLOSURE, BUT ALSO, THE CLOSEST SERVICE CENTER THAT CAN HANDLE THIS SIZE TRUCK, IS LOCATED IN ANOTHER STATE. THIS REPAIR MAY ONLY REQUIRE LESS THAN HALF A DAY TO FIX, BUT IT IS GOING TO TAKE AT LEAST THAT LONG OR BETTER GETTING THE TRUCK THERE AND BACK. THIS HAS CREATED A HARDSHIP IN TRYING TO…
Jan 1, 1901Parking brake › Driveline › Hydraulic CONSUMER COMPLAINT IN REGARDS TO RECALL FOR PARKING BRAKE, CONSUMER IS UNABLE TO HAVE THIS RECALL DONE DUE TO SERVICE CENTER BEING CLOSED. *TS THE CONSUMER STATED THE NEAREST DEALER IS LOCATED IN ANOTHER STATE, THAT IS ABLE TO HANDLE THE SIZE OF THE TRUCK. THE CONSUMER STATED FORD SHOULD NOTIFY CUSTOMERS WHEN A DEALERSHIP CLOSES ITS DOORS. *JB
Owner complaints are submitted to NHTSA by the public and are not verified. Shown as filed (NHTSA removes personal details); long reports are shortened.